In Salah Gas

Supplier Document - Job No 6683

Purchase Order Number ISGP-6683-PMJ002

Supplier Document LP0907-RRPE-006
Number
Revision B
Description DATA SHEET AC GENERATOR

Purchaser review and comments shall not be assumed to indicate either responsibility or liability for
accuracy and completeness of this document or to alter any contractual terms and conditions.
Item Numbers
J-XM-080101 & J-XM-080201
Purchasers Disposition

No Comments Comments as Noted Rejected

Date Name Initial

Signature

SDRL Code Document Number Rev

(Purchase Order Number - Sequential No)
D03 ISGP-6683-PMJ002-0073 004
 JOB NO. 6683 ITEMNO.XM-080101 /201
REQUISITION NO. MJ7001
Salah Gas DATASHEET NO. JB09-B-MJFM-080-0001
A.C. GENERATOR REVISION NO. B DATE
DATA SHEET PAGE 13 OF 34 "BY P.O.
SI UNITS
1 APPLICABLE Q»: PROPOSAL PURCHASE O AS BUILT
2 FOR MANUFACTURER ABB Automation Technology Products
3 SITE ^HHZHZZZIZ SERIAL NO. 8266861 and 8266 862
4 SERVICE NO. REQUIRED TWO
PURCHASER'S DATA
5 Rated Output (MW) (NOTE 1) Max/Min 18/8 Primary Coolant AIR
6 Rated Power Factor (cos Phi) 0.8 Secondary Coolant AIR
7 Service Voltage (V) 10,000 Cooling Classification CACA
8 Rated Frequency (Hz) 50 Cooling Temperature f C) -Max 55
9 No. of Phases 3 -Min 1
10 Duty Type S1 Area Classification NOTE 2
11 Generator Neutral Earthing NOTE 3 Generator Enclosure Classification INDUSTRIAL
12 Earth Fault Current (A) 750 Generator Ingress Protection IP55
13 Neutral Earth Resistor Rating (A, sees) 750, 10 Current Transformers
14 Excitation BRUSHLESS - In Phase : Line End YES
15 Direct Axis Sub Transient Reactance (%) NOTE 4 - In Phase : Neutral End YES
16 Direct Axis Transient Reactance (%) - In Neutral Connection YES
17 Parallel Operation YES /NO Insulation Class F
18 Unbalanced Load YES /NO Temperature Rise Class B total
19 Surge Overvoltage Protection YES /NO Vibration Detection YES
20 Mains Terminals - Cable YES Winding Temp Detection YES
21 - Cable Size TEA Bearing Temp Detection YES
22 - Cable Type XLPEPVCSWAPVC Mounting FOOT
23 Neutral Terminals - Cable Size TBA Space Heater Voltage BY SUPPLIER
24 - Cable Type XLPEPVCSWAPVC Environmental Conditions NOTE 2
25 NOTES
26 NOTE 1 - GENERATORS SHALL BE CONTINUOUSLY RATED FOR THE MAXIMUM POTENTIAL POWER DEVELOPED BY THE GAS
27 TURBINE DRIVER WHEN OPERATING WITH THE MINIMUM SITE AMBIENT TEMPERATURE.
28 NOTE 2 - REFER TO COMBUSTION GAS TURBINE DATASHEET FOR SITE CONDITIONS, UTILITIES, AREA CLASSIFICATION, NOISE
29 LIMITS AND GENERAL REQUIREMENTS.
30 NOTE 3 - NEUTRAL EARTHING RESISTOR BY GENERATOR SUPPLIER. REFER TO SKETCH ON PAGE 14 .
31 NOTE 4 - 20% NOMINAL OR 17% WITH NO NEGATIVE TOLERANCE.
32
SUPPLIER'S DATA
33 Generator Generator Parameters (All)
34 Type Positive Sequence Resistance (R1) %, Tor*/. 0.52%+-15%
35 Frame Designation AMS 1250 LC Zero Sequence Resistance (RO) %, Tol+/. 0.26%+-15%
36 Degree of Protection IP55 Negative Sequence Resistance (R2) %, Tol */. 0,74%-i-15%
37 Synchronous Speed rpm 1500 Zero Sequence Reactance (XO) %, Tol */.
38 1st Critical Speed rpm 2050 Negative Sequence Reactance (X2) 23,5%+-15%
39 Direction of Rotation seen Towards Drive CW / CCW Direct Axis Synchronous Reactance (Xd) %, Tol /. Unsat/sat 162/159%+-15%
40 Rated Voltage V 10000 Direct Axis Transient Reactance (X'd) %, Tol */. Unsatfeat 34,2/29,3%+-15%
41 Rated Frequency Hz 50 Direct Axis Sub-Transient Reactance (X"d) %, Tol */. Unsat/sat 23,5/20,0% +-15%
42 Rated Oulput at40°C Base kVA MW 20.3 Short Circuit Ratio 0.63
43 Rated Oulput at DE Side Max Power 10 degC MW 28.3 Generator Parameters (>1MVA only) ijijijijiiijijiijijijijilijijijiijjijljilijijjjjjijijljiji
44 Power Factor cos Phi 0.8 Quadrature Axis Synchronous Reactance (Xq) %, Tol */. Unsat/sat 97,0/94,6% +-15%
45 Duty Type S1 Quadrature Axis Transient Reactance (X'q) %, Tol */. NA
46 Rated Current A 1465 Quadrature Axis Sub-Transient Reactance (X"q) %, Tol /. Uinsatfeat35,2/30,0%+-15%
47 Thermal Rating Direct Axis O.C. Transient Time Constant (Tdo) sees 6.7
48 Max. Allowable Neg. Phase Seq. Current 8 Direct Axis S.C. Transient Time Constant(T'ds) sees 1.04
49 Max. Allowable Content of Overharmonics 0 Direct Axis O.C. Sub-Trans. Time Constant (T"do) sees 0.04
50 Efficiency- 100% Base kVA 97.75 Direct Axis S.C. Sub-Trans. Time Constant (T'ds) sees 0.027
51 - 75% Base kVA 97.53 Quad. Axis O.C. Transient Time Constant (T'qo) sees NA
52 - 50% Base kVA 96.89 Quad. Axis S.C. Transient Time Constant(T'qs) sees NA
53 Field Current No Load A 210 Quad. Axis O.C. Sub-Trans. Time Constant (T"qo) sees 0.113
54 Field Current Full Load A 491 Quad. Axis S.C. Sub-Trans. Time Constant(T"qs) sees 0.041
55 Insulation Cla - Stator / Rotor F / H Potier Reactance (Xp) %, Tol /.
56 Temp Rise Cl - Stator / Rotor B total / B total Damping Factor 3.2
57 Overload Capability % , hrs Saturation Factor 1.2
58 Overload Capability % , sees 150%30; Basic Impulse Level kV
59 Substained Short-Circuit %,sees 300%10! Dimensions & Weights
60 Moment of Inertia of Rotor kg m2 3431 Overall Dimensions - LxWxH
61 Cooling Method IC6A1A6 Weight of Machine 73,000
62 Cooling Water Flow Rate m3/h NA Weight of Stator kg 27,150
63 Cooling Water Design Pressure Barg NA Weight of Heat Exchanger - (Dry) kg 13,000
64 Leak Detection System NA Weight of Coolant NA
 JOB NO. 6683 ITEM NO. XM-080101/201
REQUISITION NO. MJ7001
iSalah Gas DATASHEET NO. JB09-B-MJFM-080-0001
A.C. GENERATOR REVISION NO. B
DATASHEET PAGE 14 OF 34 BY P.O.
SI UNITS
SUPPLIER'S DATA
1 System Response Bearings
2 Volfag£Bns|te(iteepeed Radial - Drive End Sleeve diameter 355
3 - Load Change From 50 To 0% % , sees .+20, 2 Radial - Non Drive End Sleeve diameter 355
4 -Load Change From 100To50% %, sees .+20, 2 Thrust Bearing NA
5 - Load Change From 0 To 50% % , sees .-15, 1 Bearing Vibration Detector Type / Manufacturer 3300 / Bently Nevada
6 - Load Change From 50 To 100% % , sees .-14, 1 Number in Each Bearing 2
7 Frequency Response: Bearing Temperature Detector Type PT100
8 -Sudden Load Change From 50To0% %,sees Number in Each Bearing 1
9 - Sudden Load Change From 100 To 50% %,sees Method of Bearing Lubrication Forced
10 - Sudden Load Change From 0 To 50% % , sees Lubrication Oil Flow Rate m3/h 4.2
11 - Sudden Load Change From 50 To 100% % , sees Lubrication Oil Pressure Barg 1,5
12 Exciter Windings
13 Type GLA 600 D Stator Connection Y
14 Full Load Current (40°C) A 12 Number of Stator Winding Terminals 12
15 Full Load Voltage V 69 Winding Temperature Detector Type PT100
16 Ceiling Current (40°C) A 24.3 Number in Each Phase 2
17 Ceiling Voltage V 138 Heater Ratings
18 Nominal Exciter Response ratio 1/S 1.6 Alternator kW 2
19 Current at alternator base kVA A 12 Exciter kW 0,5
20 Insulation Cla - Stator / Rotor F / F Aux. Cooling Fans
21 Temp Rise Cl - Stator / Rotor B /B Rating kW 6,3 per fan "1
22 AVR ijiiiiiijijijiiiijiiiiijiiijii Manufacturer Brook Hansen
23 Model No Unitrol F Frame Design 6-pole D 132-26
24 Manufacturer ABB Number Off 3
25 Range of No Load Adjustment .+-10% Duty 3x 50 %
26 Steady State Accuracy 0.5 Neutral Earthing Resistor
27 AVR Data (>1MVA only) Type
28 Forward Gain (KA) Resistance Ohms 7.7
29 Feedback Gain (KF) Resistor Rating A , sees 750/10
30 Regulator Amplifier Time Constant (TA) sees Degree of Protection IP23
31 Regulator Feedback Time Constant (TF1) sees
32 Maximum Regulator Output (VR MAX)
33 Minimum Regulator Oulput (VR MIN)
34 Max. Rate of Change of Reg. Output (VR MAX)
35 Input Filter Time Constant (TR) sees
36 Exciter Gain (KE)
37 Exciter Time Constant (TE) sees
38 . Exciter Oulput (E MAX)
39 Exciter Oulput (E MIN)
40 Exciter Saturation at 75% E MAX (SE75)
41 Exciter Saturation at 100% E MAX (SE100)
42 IEEE Model Type
43 Regulator Feedback Time Constant (TF2) sees
44
45 REMARKS: AVR Data will be given as a transfer function
46 See attached drawing XYK 214 119 - DDV
47 *1 Fan 6,75/6,3/6.0 kW at 1/20/55.deg C :
48 Motor output power to fanshaft
49
50
51
52
53
54
55
56
57
58
f

JOB NO. 6683 ITEM NO. XM-080101 /201

REQUISITION NO. MJ7001
Salah Gas DATASHEET NO.,_ JB09-B-MJFM-080-0001
A.C. GENERATOR REVISION NO. B
DATA SHEET PAGE 15 OF 34 BY P.O.
SI UNITS
SYSTEM DATA

CB1/2

/ X
\ x
X
NC

NC CB1 N s*—sc~s' CB2

\ \
PURCHAS

SUPPLI
ER

G1 G2

I
N.E.R. ; N.E.R.
750 AMPS 750 AMPS
! 10 SECS 10SECS
I 7,7 OHMS 7,7 OHMS
V _ _

N.E.R NEUTRAL
EARTHING

1 REMARKS:
2 1) THE REGULATION CAPABILITY OF THE MAIN A.C. GENERATION AND AVR SYSTEM UNDER STEADY STATE AND
3 TRANSIENT CONDITIONS SHALL BE CHOSEN FROM VOLTAGE REGULATION GRADES 2.13 (VR2.13), 2.23 (VR2.23), 2.33 '
4 (VR2.33) OR 3.11 (VR3.11) AS DEFINED IN BS 4999 PART 140. TRANSIENT PERFORMANCE IS DEFINED WITH RATED KVA
5 AT 0.8 POWER FACTOR REJECTED. THE LOWEST TOLERABLE REGULATION GRADE SHALL BE SELECTED TO OPTOMISE
6 EQUIPMENT COSTS AND FAULT LEVELS. SUPPLIER TO ADVISE FREQUENCY EXCURSIONS.
7
8
9
10
11
12
13
14
15
16