Part Manual S02001059 10xTT Pelindo IV, Makassar

DEALER: Cargotec Asia Limited
SR # : SH20263-SH20272
TABLE OF CONTENTS SHIPPED:
Item # S02001059 OT4X2,RHD 24V OFF-HWY QSB6.7-1
Part Number ID Part Description ID Page Number ID
AI1178 AIR INTAKE GROUP

AIR RESTRICTION INDICATOR - UNDER HOOD AI1529
AIR CLEANER INSTALLATION AI1546
AIR INTAKE INSTALLATION - PIPING AI5518
AIR CLEANER AIX90029855
AS0139 AIR SYSTEM GROUP
AIR TANK INSTALLATION AS1523
AIR DRYER INSTALLATION AS1531
AIR COMPRESSOR PLUMBING AS1640
TRACTOR AND TRAILER BRAKE VALVES AS1751
PNEUMATIC SYSTEM AS1793-1
PNEUMATIC SYSTEM AS1793-2
AIR SYSTEM - AIR GAUGE PANEL AS1911
CONNECTION - INSTALLATION ASX53576581
AIR DRYER - 24V ASX90024883
BP1033 BUMPER GROUP
BUMPER INSTALLATION BP1033
BS1114 BRAKE SYSTEM GROUP
BRAKE LINE INSTALLATION BS1504A
BRAKE LINE INSTALLATION BS1504B
BRAKE LINE INSTALLATION BS1504C
GLADHANDS BS1511
OPTIONS BULKHEAD INSTALLATION BS1571
CA1000 CAB ACCESSORIES GROUP
NONE CA1000 NONE
CB1189 CAB GROUP
VENT INSTALLATION - CAB SIDE CB1506
STEERING COLUMN SUPPORT CB1515
INSTRUMENT PANEL INSTALLATION CB1516
ENGINE HOOD INSTALLATION CB1517
PANEL INSTALLATION - CAB FRONT CB1567
REAR DOOR INSTALLATION CB1582
CAB - RHD - FLAT ROOF CB1587
CAB INSULATION CB1593
CAB SIDE DOOR INSTALLATION - (RHD) CB1660
GUIDE ASSEMBLY - REAR DOOR CBX53561159
ENGINE COVER ASSEMBLY CBX53569702
DOOR ASSEMBLY - REAR FRC - RHD CBX53569970
DOOR ASSEMBLY - RHD CBX53576964
CD1021 CAB DECK GROUP
DECK-BOLTED-RHD CD1021A
DECK-BOLTED-RHD CD1021B
CF1000 CAB FAN GROUP
NONE CF1000 NONE
CG1050 CAB GLASS GROUP
Item # S02001059
10-11-12[14:59] Page 1
CG1050 CAB GLASS GROUP

CAB GLASS CG1050
WINDOW INSTALLATION LH FIXED CGX90017053
WINDOW INSTALLATION LH SLIDING CGX90025942
CM1185 CAB MOUNTING GROUP
SWITCH INSTALLATION CM1554
"PIN INSTALLATION, CAB PIVOT" CM1558
TILT PUMP INSTALLATION CM1567
CAB MOUNTING INSTL. - TILT CYL/SAFETY BAR CM1593
CAB MOUNTING INSTL. - SUSPENSION RHD CM1601
TILT GROUP-TILT PLUMBING CM1653
CAB SUSPENSION - AIR RIDE KIT CMX90032205
CP1000 CAB PROTECTION GROUP
NONE CP1000 NONE
CS1234 COOLING SYSTEM GROUP
COOLING SYSTEM CS1234
CW1000 COLD WEATHER GROUP
NONE CW1000 NONE
DL1015 DRIVELINE GROUP
DRIVELINE DL1015
DP1402 DASH PANEL GROUP
TACHOMETER INSTALLATION DP1539
DASH MODULE - ENGINE GAUGE AND WARNINGS 24V DP1628
DASH PANEL INSTALLATION - CAB CONTROLS DP1665
DASH MODULE-OPTION PANEL DP1672
PANEL ASSY-ENGINE GAUGES AND WARNINGS RHD 24V DPX53573866
PANEL ASSEMBLY-CAB CONTROLS DPX53575105
PANEL ASSEMBLY-OPTIONAL SWITCHES DPX53575740
DS1083 DRIVERS SEAT GROUP
SEAT INSTALLATION DS1083
EA1042 ELECTRICAL ALTERNATOR GROUP
ELECTRICAL ALTERNATOR INSTALLATION EA1042
EB1447 ELECTRICAL BATTERY GROUP
CABLE INSTALLATION - CAB POWER EB1509
POWER CABLE GROUP - ENGINE EB1547
BATTERY BOX INSTALLATION EB1655
BATTERY BOX CABLE ROUTING SK8080
EF1073 ELECTRICAL FLOODLIGHT GROUP
FLOODLIGHT INSTALLATION EF1073
FLOODLIGHT MODIFICATION EFX53567603
EG1472 ENGINE GROUP
ENGINE/TRANS FRAME SIDE MOUNTS EG1503
FAN INSTALLATION EG1517
ENGINE AIR COMPRESSOR PLUMBING EG1650
START RELAY INSTALLATION EG1705
CHARGE AIR COOLER INSTALLATION EG1709
BAFFLE INSTALLATION - RADIATOR EG1712
FRONT ENGINE MOUNT INSTALLATION EG1741
ENGINE SIDEMOUNTS-MD TRANSMISSION EG1810
CHARGE AIR COOLER PIPING EG1833
ENGINE INSTALLATION EG1988
Item # S02001059
10-11-12[14:59] Page 2
EG1472 ENGINE GROUP

RADIATOR REWORK - BAFFLE MOUNTS EGX53545889
EL1059 ELECTRICAL LIGHTS GROUP
HEADLIGHTS/TAILLIGHTS/CAB LIGHTS EL1547
EO1122 ENGINE OPTIONS GROUP
ENGINE SHUTDOWN - (PARAMATERS) NO PARTS EO1015
ENGINE OPTION - DIAGNOSTICS CONNECTION EO1118
ES1199 ELECTRICAL SYSTEM GROUP
TRAILER ELECTRIC CONNECTION ES1568
ELECTRICAL SYSTEM - 24 VOLT ES1603A
ELECTRICAL SYSTEM - 24 VOLT ES1603B
ELECTRICAL SYSTEM INSTALLATION ES1617
ELECTRICAL SYSTEM - CHASSIS ES1622
ACCELERATOR PEDAL ES1628
HARNESS - MAIN CAB ESX53573791
HARNESS ASSEMBLY - MAIN CAB ESX53573795
DIAGNOSTIC SWITCH ASSEMBLY ESX53574388
SCHEMATIC - WIRING DIAGRAM SK8176A
SCHEMATIC - WIRING DIAGRAM SK8176B
SCHEMATIC - WIRING DIAGRAM SK8176C
SCHEMATIC - WIRING DIAGRAM SK8176D
SCHEMATIC - WIRING DIAGRAM SK8176E
SCHEMATIC - WIRING DIAGRAM SK8176F
SCHEMATIC - WIRING DIAGRAM SK8176G
SCHEMATIC - WIRING DIAGRAM SK8176H
SCHEMATIC - WIRING DIAGRAM SK8176I
SCHEMATIC - WIRING DIAGRAM SK8176J
EX1103 EXHAUST GROUP
MUFFLER INSTALLATION EX1558
EXHAUST PIPING INSTALLATION EX1609
FA1113 FRONT AXLE GROUP
FRONT AXLE ASSEMBLY FA1113A
FRONT BRAKE ASSEMBLY FA1113B
HUB AND DRUM ASSEMBLY FA1113C
FD1010 FLUIDS NONE
NONE FD1010 NONE
FF1181 FENDER AND FLAPS GROUP
MUD FLAP INSTALLATION - FRONT RH SIDE FF1064
FENDER AND FLAP INSTALLATION FF1128
FL1192 FUEL LINE GROUP
FUEL LINE INSTALLATION FL1192
FR0074 FRAME GROUP
CROSSMEMBER INSTALLATION FR1501
FRAME BOLT INSTALLATION FR1681
FRAME BUSHINGS FR2037
FS1001 FRONT SUSPENSION GROUP
SUSPENSION ASSEMBLY FS1001
FT1043 FUEL TANK GROUP
FUEL TANK INSTALLATION FT1043
LOW FUEL LIGHT INSTALLATION FTX53575651
FW1290 FIFTH WHEEL GROUP
Item # S02001059
10-11-12[14:59] Page 3
FW1290 FIFTH WHEEL GROUP

5TH WHEEL - STATIONARY - FW3500 FW1290
5TH WHEEL SUB-ASSEMBLY FWX90027837
5TH WHEEL ASSEMBLY FWX90027838
GH1022 GRAB HANDLE GROUP
GRAB HANDLE INSTALLATION GH1022
HC1213 HEATING AND COOLING GROUP
HEATER PLUMBING KIT HC1523
AIR CONDITIONING CONTROLS HC1543
HEATER / AC COMPONENTS - 24 VOLT HC1575
HEATER CONTROLS HC1581
A/C COMPRESSOR INSTALLATION HC1592
A/C CONDENSOR COMPONENTS HC1618
HEATER-A/C PLUMBING HC1627
BLOWER ASSEMBLY - 24 VOLT HCX90032011
HEATER/AC ASSEMBLY HCX90032013
HEATER CONTROLS PACKAGE HCX90032108
HN1004 HORN GROUP
ELECTRIC HORN 24 VOLT HN1004
HS1000 HYDRAULIC SYSTEM GROUP
NONE HS1000 NONE
LL1000 LUBE SYSTEMS GROUP
NONE LL1000 NONE
LT1001 LITERATURE NONE
NONE LT1001 NONE
MR1070 MIRROR GROUP
LOW VIBRATION MIRROR GROUP MR1070
LOW VIB CAB SIDE MIRROR ASSEMBLY MRX53576538
LOW VIB POST SIDE MIRROR ASSEMBLY MRX53576539
OP1000 OPERATIONAL OPTIONS
NONE OP1000 NONE
PF1151 PLATFORM GROUP
PLATFORM INSTALLATION - SIDE PF1546
PLATFORM INSTALLATION - FRAME PF1557
PLATFORM INSTALLATION - REAR CAB PF1602
PO1017 PAINT OPTION
NONE PO1017 NONE
RA1186 REAR AXLE GROUP
REAR AXLE ASSEMBLY RA1186A
REAR AXLE RA1186B
WHEEL HUB RA1186C
WHEEL BOLTS RA1186D
HUB REDUCTION RA1186E
PLANETARY GEAR RA1186F
AXLE SHAFTS RA1186G
DIFFERENTIAL CARRIER ASSEMBLY RA1186H
BRAKE ASSEMBLY RA1186I
RD1000 RADIO GROUP
NONE RD1000 NONE
RS1033 REAR SUSPENSION GROUP
REAR SUSPENSION RS1033
Item # S02001059
10-11-12[14:59] Page 4
SL1002 STROBE LIGHT GROUP

AMBER STROBE LIGHT SL1002
SP1025 SPEEDOMETER GROUP
SPEEDOMETER INSTALLATION SP1025
SS1360 SAFETY SYSTEMS
BACK-UP ALARM INSTALLATION SS1570
DECALS - SAFETY SYSTEM SS1789
"DECAL INSTALLATION, CAB TILT CAUTION" SSX53546434
"DECAL INSTALLATION, NO RIDERS" SSX53549725
SAFETY WALK INSTALLATION SSX53567648
ST1010 STEERING GROUP
STEERING CHASSIS INSTALLATION ST1510
STEERING CAB INSTALLATION - RHD ST1511
DRAGLINK ASSEMBLY STX90021195
STEERING GEAR ASSEMBLY STX90022655
SV1005 SUNVISOR GROUP
SUNVISOR INSTALLATION SV1005
TP1021 TOW PACKAGE GROUP
HITCH PIN TP1021
TR0043 TRANSMISSION GROUP
TRANSMISSION SCHEMATIC SK8343A
TRANSMISSION SCHEMATIC SK8343B
TRANSMISSION SCHEMATIC SK8343C
TRANSMISSION SCHEMATIC SK8343D
TRANSMISSION TAIL SUPPORT INSTALLATION TR1585
DIPSTICK INSTALLATION TR1597
SHIFTER PANEL INSTALLATION TR1762
TRANSMISSION ADAPTATION KIT TR1763
TRANSMISSION INSTALLATION TR1828
TRANSMISSION SHIFTER GROUP TR1848
TRANSMISSION COOLING COMPONENTS TR1852
TRANSMISSION TEMP GAUGE INSTALLATION TR1853
TRANSMISSION E.C.U. INSTALLATION - 3000RD TR1887
WP1069 WIPER GROUP
WIPER GROUP WP1069
WIPER MOTOR-24 VOLT WPX90033100
WT1415 WHEELS AND TIRES GROUP
WHEELS AND TIRES WT1415
Item # S02001059
10-11-12[14:59] Page 5
AI1529
AIR RESTRICT INDICATOR
UNDER HOOD
ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

1 90003940 INDICATOR, AIR CLEANER SERVICE 1
2 90709340 REDUCER BUSHING 1/4 M 1/8F NPT 1
6/16/2003 AI1529
AI1546
AIR CLEANER INSTALLATION 11" (REAR FILTER RHD)

1 53569834 WELDMENT, AIR CLEANER BRACKET 1
2 90812099 CLAMP, HOSE 2"-7" DIAMETER 5
3 53569217 WELDMENT, BRACKET 11" 2
4 53570027 ANGLE, INTAKE TUBE SUPPORT 1
5 90005166 FLATWASHER 5/16 HARDENED 8
6 95210420 LOCKNUT ESNA, 5/16-18 4
7 90804035 CAPSCREW, 5/16-18 X 1 4
8 90029855 AIR CLEANER, 11" 1 AIX90029855
9 90007939 CAPSCREW 5/8 -11 X 1 3/4 GRADE 8 4
10 90005159 FLATWASHER, 5/8 HARDENED 8
11 90017712 NUT, CROWNLOCK 5/8-11 GRADE C 4
12 70000014 TUBE, FLEXAUST 5 1/2" DIAMETER 24"
13 90000904 ELBOW, RUBBER 90 DEG. 5.5" X 5.5" 1
14 53569044 TUBE, 5.5" OD X 5" LONG 1
15 90804485 CAP SCREW 3/8-16 X 1 1/4 4
16 90017717 NUT, CROWNLOCK 3/8-16 UNC GRADE B 4
17 90005165 FLATWASHER, 3/8 HARD ZINC SAE 8
18 53569839 AIR INTAKE HOUSING WELDMENT 1
19 90027537 SCREW, TAPTITE 1/4-20 X 1" TORX 4
20 90027717 NUT, TINNERMAN 1/4-20 4
6/16/2003 AI1546
AI5518
AIR INTAKE PIPING
ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

1 53573882 TUBE, AIR INTAKE 1
2 90004873 ELBOW, RUBBER 90 DEG 4 X 4 1
3 90016101 ELBOW, RUBBER 90 DEG 4 X 5 1
4 90022397 CLAMP BREEZE 2
5 90022399 CLAMP BREEZE 1
6 90003587 PLUG 1/4-18NPT BRASS HEX HEAD 1
7 53570408 BRACKET, AIR INTAKE TUBE SUPPORT 1
8 90002305 CLAMP 4 IN ZINC COATED 1
10 98415020 LOCKWASHER 1/4 2
11 90804016 CAPSCREW 1/4-20 X 3/4 2
1/25/2007 AI5518
90029855
AIR CLEANER

-- 90029855 AIR CLEANER -
SERVICE PARTS
1 90023953 REPLACABLE FILTER ELEMENT 1
2 90027024 VACUATOR 1
3 90029379 FILTER ACCESS COVER 1
4 90029380 PLASTIC THUMB SCREWS 2
12/26/2002 AIX90029855
AS1523
AIR TANK INSTALLATION

1 90025548 RESERVOIR AIR 9.5 DIA X 27 REAR DRAIN 2
2 53555914 BRACKET, AIR TANK SUPPORTT FRMD 2" HI 2
3 53113726 BRACKET, AIR TANK 9 1/2 DIA 8
4 90804485 CAPSCREW 3/8-16 X 1 1/4 16
5 98421135 FLATWASHER 3/8 16
6 90017717 NUT, CROWNLOCK 3/8-16 GRADE B 22
7 53555374 BAR, AIR TANK SPACER X 1.12 CTRS 4
8 90024678 CAPSCREW, AIR TANK 3/8-16 X 6 (SPECIAL LG THREADS) 6
9 90003587 PLUG, 1/4-18 NPT BRASS HEX HEAD 4
10 91603180 ADAPTER, 90 BRASS 5/8 ODT X 1/2P NYL 3
11 90003594 ELBOW, 90 1/2 BRASS STREET 1
12 53109165 VALVE CHECK 1/2 MALE X 1/2 FEMALE 2
13 90003542 ELBOW 45 5/8 OD X 1/2 NPT 3
14 99802342 TUBE, NYLON AIRBRAKE 5/8 BLACK 12
15 99802342 TUBE, NYLON AIRBRAKE 5/8 BLACK 30
16 90030058 ELBOW, 45 1/2 OD TUBE X 1/2 NPT 1
17 53112311 BAR, MOUNTING 2
18 91603181 ELBOW, 90 1/4 NYLON TUBE X 1/4 NPT 1
19 90029164 VALVE, MANUAL DRAIN AIR RESERVE 3
20 90008707 KIT, CABLE AIR DRAIN VALVE 60 LG 3
21 90027609 FERRULE, 3/32 CABLE COMPSLEEVE 6
22 90008600 EYE BOLT 3/16-NC X 2 2
23 90013050 LOCKNUT ESNA #10-24NC 2
24 98045023 FLATWASHER #10 2
25 90025547 RESERVOIR AIR 7"DIA X 24" REAR DRAIN 1
26 53113727 BRACKET, AIR TANK 7 DIA 4
27 90011966 TEE 1/2NPT MALE BRANCH BRASS 2
28 90003582 NIPPLE HEX 1/4 BRASS 1
29 90003590 TEE STREET 1/4 BRASS 1
30 90004391 VALVE PRESSURE PROTECTION AIR 1
31 91603183 ELBOW 90 3/8 OD TUBE X 1/4 PIPE NYLON 1
32 90029163 VALVE, PRESSURE RELIEF 1/4NPT 1
3/19/2003 AS1523
AS1531
AIR DRYER INSTALLATION

1 53565066 MOUNTING BRACKET, AIR DRYERS RHD 1
2 90804485 CAPSCREW 3/8-16 X 1-1/4 8
3 90005165 WASHER, FLAT 3/8 HARD ZINC SAE 8
4 90017717 NUT CROWNLOCK 3/8-16UNC (GRADE B) 8
5 90024883 AIR DRYER, B/W AD-9 24V 1 ASX90024883
6 96082227 ADAPTER 90 #12 JIC x 1/2 MNPT 1
7 NOT USED
8 91603181 ELBOW 90 1/4 NYL TUBE x 1/4 NPT 1
9 99802342 TUBE, NYLON AIRBRAKE 5/8 BLACK 100 IN
10 90003542 ELBOW 45 5/8 OD X 1/2 NPT 2
12 53100533 CONN MALE 1/4OD X 1/8P BRASS 1
13 90022735 CLAMP, SILICONE COATED 5/8 ID 1
14 53101504 CLAMP, RUBBER COATED 3/8 ID 2
15 95210420 LOCKNUT ESNA 5/16-18 NC 4
17 90804035 CAPSCREW 5/16-18 X 1 1
18 90709320 REDUCER BUSHING 3/4M 1/2F NPT 2
ITEMS NOT SHOWN

--- 90030151 BREAKER, 24V TYPE III MANUAL RESET ATC 10A 1
1/13/2010 AS1531
AIR COMPRESSOR PLUMBING W/ AIR DRYER - RHD
AS1640
AS1640
AIR COMPRESSOR PLUMBING W/ AIR DRYER

1 90028806 NUT .75 O.D. COPPER TUBE 1
2 90028805 SLEEVE .75 O.D. COPPER TUBE 1
3 53572520 HOSE ASSY H24312-612Y62-13200 1
4 91603181 ELBOW 90 1/4 NYL TUBE X 1/4 NPT 1
5 99802339 TUBE, NYLON AIRBRAKE 1/4 BLACK 100 IN.
6 90028234 CLAMP, SILICONE COATED 7/8 IN ID (HIGH TEMP) 3
7 53527753 BRACKET, HOSE SUPPORT/ROUTING 1
8 95210420 LOCKNUT ESNA 5/16-18 NC 4
10 90804035 CAPSCREW 5/16-18 X 1 1
11/8/2004 AS1640
AS1751
AIR SYSTEM - TRACTOR AND TRAILER BRAKE VALVES - RHD

1 90007281 VALVE, AIR CONT. BRAKE SP 1
2 90007283 VALVE, AIR CONTROL-TRAILER EMERGENCY 1
3 91603176 ELBOW, 90 3/8ODT X 1/8P NYL 5
4 91603183 ELBOW, 90 3/8ODT X 1/4P NYL 1
6/22/2007 AS1751
AS1793
PNEUMATIC SYSTEM

1 90001264 VALVE, BRAKE TREADLE B/W 1
2 90019933 VALVE TRACTOR PROTECTION 1
5 90022473 CAPSCREW HEX HD 5/16-18 X 3/4 SS 18-8 3
6 95210420 LOCKNUT ESNA 5/16-18 NC 10
7 90804039 CAPSCREW, 5/16-18 X 1-1/4 FULL THREAD 2
8 53576581 CONNECTION INSTALLATION 1 ASX53576581
9 91603183 ELBOW, 90 3/8ODT X 1/4P NYL 4
10 91603177 ELBOW, 90 1/2ODT X 3/8 P NYL 2
11 90804485 CAPSCREW 3/8-16 X 1-1/4 3
14 91603176 ELBOW, 90 3/8ODT X 1/8P NYL 2
15 90028167 DUAL CLAMP TIE 19.2" W/ 1/4" MTG HOLE 5
16 90007335 VALVE, DOUBLE CHECK DC-4 BW278614 1
17 NOT USED -- ---
19 90027222 TUBE, NYLON AIRBRAKE 1/2 YELLOW 100 IN
20 90027221 TUBE, NYLON AIRBRAKE 1/2 GREEN 14 IN
22 95670140 PLUG 3/8-18NPT HEX SOCKET 4
23 90013920 SCREW, MN BUT HD 10-24X5/8 SS 2
24 90013050 LOCKNUT ESNA #10-24 NC 2
25 92003011 BULKHEAD 1/4 NPT 4
26 53574437 BRACKET, STOPLIGHT/BRAKE SWITCH BULKHEAD MOUNT 1
28 90029255 SWITCH STOP LIGHT 1
30 91603181 ELBOW 90 1/4 NYL TUBE x 1/4 NPT 1
31 53101500 CLAMP, RUBBER COATED 1 ID 6
33 90003344 TUBE, NYLON AIRBRAKE 1/2 BLUE 101 IN
34 90802007 CAPSCREW 5/16-18 X 2-3/4 2
35 98005596 VALVE, PUSH BUTTON-5TH UNLATCH 1
36 90009596 SPIRAP PLASTIC TUBING 45 IN
37 98421145 FLATWASHER 5/16 5
39 53109268 CLAMP, RUBBER COATED 1-1/4 ID 2
1/12/2010 AS1793-1
AS1793
PNEUMATIC SYSTEM

40 90003339 TUBE, NYLON AIRBRAKE 3/8 ORANGE 330 IN
43 90003342 TUBE, NYLON AIRBRAKE 3/8 BLUE 265 IN
44 90003513 TEE UNION 3/8 OD BRASS TUBE 4
45 90012944 ELBOW, 45 3/8OD3/8NPT BRASS 1
46 91603188 ELBOW, 90 3/8ODT X 3/8P NY 2
47 90003593 ELBOW 90 3/8 NPT BRASS STREET 1
48 90003338 TUBE, NYLON AIRBRAKE 3/8 RED 419 IN
49 90003340 TUBE, NYLON AIRBRAKE 3/8 YELLOW 120 IN
50 91201080 DIAL, FIFTH WHEEL CONTROL 1
51 90025962 UNION, 3/8T X 3/8T PUSH-IN 1
52 90022268 CONDUIT, ASSY 1
53 90013917 SCREW,MN BUT HD 1/4-20X1 SS 4
55 90013919 LOCKNUT ESNA 1/4-20 NC 4
56 NOT USED -- ---
58 90003586 PLUG, 1/8 NPT HEX HEAD BRASS 1
59 NOT USED -- ---
60 90003587 PLUG 1/4-18NPT BRASS HEX HEAD 1
61 98415060 LOCKWASHER 3/4 1
ITEMS NOT SHOWN

--- 90804035 CAPSCREW 5/16-18 X 1 3
1/12/2010 AS1793-2
AS1911
AIR SYSTEM INSTALLATION - AIR GAUGE PANEL

1 53100508 SWITCH, AIR PRESS N.C. 70PSI 2
2 53575754 PANEL, AIR GAUGE ASSEMBLY - 24V RHD 1
3 53569959 HARNESS DASH PANEL AIR GAUGE RHD 1
4 90005172 TEE-BRASS 1/8 NPT 2
5 90020773 SCREW, #10-24 X 3/4 4
6 90033212 AIR PRESSURE GAUGE, HDI 24VDC 2
7 90030917 ELBOW 90 3/8 ODT X 1/8NPT SWIVEL 2
8 90001952 BUZZER, LOW AIR PRESSURE 24V 1
9 96002102 ADAPTER 1/8M X 1/4F NPT 2
11/10/2010 AS1911
53576581
CONNECTION - INSTALLATION

1 53573609 BRACKET, BULKHEAD MOUNTING 1
2 90030776 BULKHEAD TEE, T-1314 1/4 NPTF 2
5 92003011 BULKHEAD 1/4 NPT 3
6 91603183 ELBOW, 90 3/8 ODT X 1/4P NYL 9
8 91603186 ELBOW, 90 1/2 ODT X 1/4P NYL 2
1/11/2010 ASX53576581
ASX90024883
AIR DRYER - 24V

1 90024883 AIR DRYER - 24VDC 1
- 90022187 DESICCANT CARTRIDGE KIT -
- 90028746 BRACKET KIT -
- 90028747 PURGE VALVE KIT -
- 90028840 24V HEATER & THERMOSTAT -
12/26/2002 ASX90024883
BP1033
BUMPER INSTALLATION
(RHD)

1 53570002 BUMPER, WELD CAC - RHD - 98" WIDE 1
2 90804405 CAPSCREW 3/4-10 X 1-3/4 4
3 90014217 NUT, CROWNLOCK 3/4-10 (GRADE C) 4
4 98421120 FLATWASHER 3/4 4
8/10/2007 BP1033
BS1504
BRAKE LINE INSTL
OFF HWY SPLIT BRAKE

1 90828097 CONNECTOR, NYLON 3/8 OD X 3/8 P 1
2 91603188 ELBOW, 90 3/8 ODT X 3/8 P NYL 1
3 91603178 ELBOW, 90 1/2 ODT X 1/2 P NYL 3
4 90003937 REDUCER BUSHING BRASS 3/8 X 1/4 4
5 91603186 ELBOW, 90 1/2 ODT X 1/4 P NYL 2
6 91603183 ELBOW, 90 3/8 ODT X 1/4 P NYL 5
7 90003344 TUBE, NYLON AIRBRAKE 1/2 BLUE 30 IN.
9 90003339 TUBE, NYLON AIRBRAKE 3/8 ORANGE 18 IN.
11 90010640 TEE STREET 1/2 NPT BRASS 1
13 91603176 ELBOW, FITTING NY 3/8 OD - 1/8 P 1
14 53520655 HOSE ASSY 3/8 X 24 2
16 92003011 BULKHEAD 1/4 NPT 2
18 90027222 TUBE, NYLON AIRBRAKE 1/2 YELLOW 48 IN.
20 90828102 CONNECTOR, NY TUBE 1/2 OD - 1/2 P 1
22 91603196 CONNECTOR, 90 3/8 OD 1/2 P 1
23 90015034 VALVE, QUICK RELEASE 3/8 1
24 53542907 RUBBER SPACER 3
25 95210420 LOCKNUT ESNA 5/16-18 NC 10
26 90803066 CAPSCREW 5/16-18 X 1 1/2 4
27 90029254 VALVE, QUICK RELEASE 1/2 I, 3/8 O 1
28 90001353 CONNECTOR MALE 1/2" OD 3/8 P 2
29 53557886 ANGLE, VALVE MOUNT 1
30 90804039 CAPSCREW 5/16-18 X 1 1/4 4
31 53543908 BRACKET, VALVE 1
32 90020596 VALVE, PROPORTION 1
33 90003589 PLUG 1/2-14 NPT BRASS HEX HEAD 1
12/26/2002 BS1504A
BS1504
BRAKE LINE INSTL
OFF HWY SPLIT BRAKE

2 91603188 ELBOW, 90 3/8 ODT X 3/8 P NYL 1
3 91603178 ELBOW, 90 1/2 ODT X 1/2 P NYL 3
5 91603186 ELBOW, 90 1/2 ODT X 1/4 P NYL 2
6 91603183 ELBOW, 90 3/8 ODT X 1/4 P NYL 5
14 53520655 HOSE ASSY 3/8 X 24 2
16 92003011 BULKHEAD 1/4 NPT 2
22 91603196 CONNECTOR, 90 3/8 OD 1/2 P 1
25 95210420 LOCKNUT ESNA 5/16-18 NC 10
26 90803066 CAPSCREW 5/16-18 X 1 1/2 4
30 90804039 CAPSCREW 5/16-18 X 1 1/4 4
12/26/2002 BS1504B
BS1504
BRAKE LINE INSTL
OFF HWY SPLIT BRAKE

2 91603188 ELBOW, 90 3/8 ODT X 3/8 P NYL 1
3 91603178 ELBOW, 90 1/2 ODT X 1/2 P NYL 3
5 91603186 ELBOW, 90 1/2 ODT X 1/4 P NYL 2
6 91603183 ELBOW, 90 3/8 ODT X 1/4 P NYL 5
14 53520655 HOSE ASSY 3/8 X 24 2
16 92003011 BULKHEAD 1/4 NPT 2
22 91603196 CONNECTOR, 90 3/8 OD 1/2 P 1
25 95210420 LOCKNUT ESNA 5/16-18 NC 10
26 90803066 CAPSCREW 5/16-18 X 1 1/2 4
30 90804039 CAPSCREW 5/16-18 X 1 1/4 4
12/26/2002 BS1504C
BS1511
GLADHANDS - RED AND BLUE COILED

1 53452488 GLADHAND, SERVICE 1
2 53452489 GLANDHAND, EMERGENCY 1
3 90019027 AIR HOSE SET - 15' WORKING LENGTH 1
4 90028863 ADAPTER 1/2" MNPT X 1/2" FNPT PVC 2
5 53105026 COUPLING DUMMY, GLADHAND 2
6 90804035 CAPSCREW 5/16-18 X 1 4
7 98415035 LOCKWASHER 5/16 4
12/26/2002 BS1511
BS1571
OPTIONS BULKHEAD INSTALLATION

1 90029996 CONNECTOR, 12 CAVITY RECEPTACLE (BULKHEAD) 1
2 90026396 SECONDARY LOCK, 12 PIN RECEPT (NOT SHOWN) 1
3 90025055 CONNECTOR, 12 CAVITY PLUG 1
4 90025057 SECONDARY LOCK, 12 PIN PLUG (NOT SHOWN) 1
5 90019585 PLUG, SEALING 12
6 90029890 SCREW #8 X 1/2 HEX WASH HD SELF TAP ZINC PLTD 4
6/23/2007 BS1571
VENT INSTALLATION - CAB SIDE - RIVETED
CB1506
CB1506
VENT INSTALLATION - CAB SIDE - RIVETED

1 90030112 VENTILATOR, 2-WAY (CAB SIDE) 1
2 90030115 GASKET, BOLT ON SIDE VENT 1
3 90030146 POP RIVET .188 X .325 ALUM/STEEL CLOSER END 12
2/18/2003 CB1506
CB1515
STEERING COLUMN SUPPORT - BOLT IN - RHD

1 53569917 STEERING COLUMN SUPPORT WELDMENT - RHD 1
2 98421145 FLATWASHER 5/16 5
3 98415035 LOCKWASHER 5/16 5
4 90804035 CAPSCREW 5/16-18 X 1 5
6/25/2007 CB1515
CB1516
INSTRUMENT PANEL INSTALLATION W/ HINGE

1 53570041 INSTRUMENT PANEL & HINGE ASSY RHD 1
(INCLUDES ITEMS 2, 3 & 4)
2 53569972 INSTRUMENT PANEL WELDMENT RHD 1
3 53562785 HINGE FOR INSTRUMENT PANEL 1
4 90020773 SCREW #10-24 X 3/4 SELFTAP 3
5 53451200 PLUG, NYLON 3/4 DIA HOLE 1
6 90024199 PLUG, NYLON 1-3/16 DIA HOLE BLACK 1
7 90028959 CAPSCREW/WASHER 5/16-18 X 1-1/4 BUTTON HD 2
8 90028771 CAPSCREW 1/4-20 X 1 BUTTON HD (GRADE 8) 6
9 98421150 FLATWASHER 1/4 6
6/25/2007 CB1516
CB1517
ENGINE HOOD INSTALLATION

1 53569702 ENGINE COVER ASSEMBLY RHD 1 CBX53569702
2 90804035 CAPSCREW 5/16-18 X 1 5
3 98421145 FLATWASHER 5/16 5
4 90013614 LOCKNUT ESNA #8-32 NC 3
5 90022652 BUMPER, RUBBER .50 DIA. X .25 THK 3
6 90017754 WEATHERSEAL, D SECT .53 X .75 (2 - 12") 24 IN.
7 53141335 LATCH ASSEMBLY 1
6/25/2007 CB1517
PANEL INSTALLATION - FRONT CAB
CB1567
CB1567
PANEL INSTALLATION
FRONT CAB

1 53568941 PANEL, FRONT REMOVABLE 1
2 53567291 SEAL, FRONT PANEL OUTER 2
3 53567292 SEAL, FRONT PANEL CENTER 1
4 53567293 INSULATION, FRONT PANEL 1
12/26/2002 CB1567
CB1582
REAR DOOR
ALUMINUM - (RHD)

1 53569970 DOOR ASSEMBLY, REAR 1 CBX53569970
2 90004129 WEATHER SEAL, REAR DOOR/HOOD 156 IN.
3 90004217 HANDLE, CAB REAR DOOR 1
4 90027569 SCREW #10-24 X 3/4 FLATHD. (USE THREAD LOCK) 2
6/25/2007 CB1582
CAB - RHD - FRC
CB1587
CB1587
CAB - RHD - FLAT ROOF CAB,
SEALS AND HARDWARE

1 53569969 CAB WELDMENT, RHD FRC 1
2 53565463 WASHER, FRONT CAB MOUNT 2
3 53565665 PLATE, FRONT CAB MOUNTING SPACER 1
4 53569991 SEAL, CAB/DECK FRONT - RHD 1
5 53569992 SEAL, CAB/DECK REAR - RHD 1
6 53569993 SEAL, CAB/DECK RH SIDE - RHD 1
- 90024231 GROMMET, 7/16 ID X 3/32 G X 5/8 GD 1

- 90004097 FLAT RUBBER 24 IN.
- 53549491 BRACKET, FLOODLIGHT/STROBE - RHD 1
- 90803051 CAPSCREW 5/16-18 X 5/8 3

- 98415035 LOCKWASHER 5/16 3
- 90028773 CAPSCREW 3/8-16 X 1.50 G8 BUTTON HD TORX+ 3
- 90005165 FLATWASHER 3/8 HARD ZINC SAE 5
- 90017717 NUT CROWNLOCK 3/8-16 UNC GD B 4
- 90005159 FLATWASHER 5/8 HARDENED 27
- 90017712 NUT CROWNLOCK 5/8-11 GRADE C 4
- 90802064 CAPSCREW 5/8-11 X 1 3/4 2
- 90804301 CAPSCREW 1/2-13 X 3 3/4 5
- 90017719 NUT CROWNLOCK 1/2-13 GRADE C 13
- 90804204 CAPSCREW 5/8-11 X 4 1/2 2
- 97205054 SCREW #10-24 X 3/4 MACH RD HD 2
- 90804090 CAPSCREW 3/8-16 X 3-1/4 1
- 90804271 CAPSCREW 1/2-13 X 1 3/4 8
ADDED 12/12/08 (NOT SHOWN)

53542109 WELD, DEFROSTER COVER RHD 1
90021292 SCREW, 1/4-20 X 3/4 ROUND HEAD 4
6/4/2009 CB1587
CAB INSULATION - RHD
CB1593
CB1593
CAB INSULATION
RHD

1 53570096 INSULATION, UNDER FLOOR (FRONT) 1
2 53570130 INSULATION, ENGINE COMPARTMENT CEILING REAR 1
3 53570095 INSULATION, UNDER CAB FLOOR (REAR INNER) 1
4 53570094 INSULATION, UNDER CAB WALL (REAR OUTER) 1
5 53570213 INSULATION, DASH - LH SIDE REAR 1
6 53570133 INSULATION, RECESS PANEL WITH HOLES 1
7 53570092 INSULATION, CAB REAR WALL 1
8 53570192 WALL MAT, INTERIOR FIREWALL 1
9 53570129 INSULATION, FIREWALL REAR 1
10 53570134 INSULATION, RECESS PANEL SIDE 1
11 53570131 INSULATION, ENGINE COMPARTMENT CEILING FRONT 1
12 53570132 INSULATION, RECESS PANEL BOTTOM 1
13 53570215 INSULATION, DASH - REAR MOUNTING FLANGE 1
14 53570218 INSULATION, DASH - PANEL DIVIDER & LH MTG FLANGE 2
15 53570217 INSULATION, DASH - LH SEALING FLANGE 1
16 53570216 INSULATION, DASH - UNDER DASH 1
17 53570136 INSULATION, FIREWALL FRONT 1
18 53570212 INSULATION, DASH - LH SIDE FORWARD 1
19 53570214 INSULATION, DASH - PANEL DIVIDER 1
20 53540984 INSULATION, CAB ROOF SIDE GREY 2
21 53540985 INSULATION, CAB ROOF MIDDLE GREY 1
9/9/2003 CB1593
CB1660
CAB SIDE DOOR INSTALLATION - (RHD)

1 53576964 DOOR ASSMEBLY SIDE - RHD 1 CBX53576964
2 53570018 DOOR COVER ASSEMBLY, ABS 1
4 90008447 BRACKET, HOLDER 2
5 90029880 SCREW #10-24 X 1 PN HD PHL SS 2
6 90015498 DOOR RESTRAINT, FLEXIBLE 2
7 90017754 WEATHERSEAL, D SECT .53 X .75 52 IN.
8 53451200 PLUG, NYLON 3/4 DIA HOLE (NOT SHOWN) 1
9 90029850 HANDLE, CAB INTERIOR SIDE DOOR 1
10 90032525 SCREW, #8 X 1" LG 17
11 NOT USED -- --
12 53574917 GASKET, SIDE DOOR CAB - RHD 1
13 90025949 SCREW 1/4-20 X 1 SS RND HD 4
14 98415020 LOCKWASHER 1/4 4
12/30/2009 CB1660
53561159
GUIDE ASSEMBLY
REAR DOOR

1 53561751 BRACKET WELD, SLIDER - REAR DOOR 1
2 90027629 SCREW, #10-24 X 3/4 PAN HEAD SELF TAP 8
3 53560774 BLOCK, SLIDER - REAR DOOR 4
4 90804035 CAPSCREW, 5/16-18 X 1 (GUIDE TO DOOR ASSY) 4
5 90004335 STAR WASHER #10 4
6 98415035 LOCKWASHER 5/16 4
6/25/2007 CBX53561159
53569702
ENGINE COVER ASSEMBLY - RHD

1 53569703 ENGINE COVER FRONT RHD 1
2 53569704 ENGINE COVER REAR RHD 1
3 53569705 CHANNEL, CENTER ENCLOUSRE RHD 1
4 60000056 HOOD WELDMENT, ENGINE ENCLOSURE 1
5 90029921 SCREW, 5/16-18 X 1-3/4 PAN HEAD PHILLIPS 4
6 90004090 SCREW, 5/16-18 X 3/4 PAN HD. 8
7 95210420 LOCKNUT ESNA 5/16-18 NC 12
9 53561460 BLOCK, PIVOT, HOOD 2
10 90022102 WASHER, SNUBBING 1.36 OD X .085 THK 4
6/25/2007 CBX53569702
53569970
ALUMINUM REAR DOOR
FLAT ROOF CAB - RHD

1 53570581 REAR DOOR WELDMENT 1
2 53565910 PLATE, ROLLER SUPPORT 2
3 90022069 ROLLER ASSEMBLY 2
4 90025938 LATCH HANDLE W/ INNER HANDLE 1
5 90804018 CAPSCREW HEX HD 1/4-20 X 1 4
6 90804016 CAPSCREW HEX HD 1/4-20 X 3/4 4
7 95210295 NUT, CROWNLOCK 1/4-20 4
8 53561159 GUIDE ASSEMBLY, REAR DOOR 1 CBX53561159
9 90022152 STRIKER (NOT SHOWN) 1
10 98421150 FLATWASHER 1/4 6
11 53567346 PLATE WELD, LATCH MOUNTING 1
12 53567347 PLATE, COVER - REAR DOOR ACCESS 1
13 90029228 SCREW #8 X 1/2 PAN HD. SELF-TAP 4
14 53568426 SHIM, REAR DOOR ROLLER .063 IN. AR
15 53568427 SHIM, REAR DOOR ROLLER .032 IN. AR
16 98415020 LOCKWASHER 1/4 4
6/25/2007 CBX53569970
53576964
DOOR ASSEMBLY SIDE - RHD

1 90002698 CHANNEL, WINDOW 1
2 53576427 ANGLE BRACKET, FILLER BELOW WINDOW 1
3 90033252 SIDE WINDOW, DRIVERS DOOR 2PC 1
4 90032977 CAPSCREW, #8-18 X .50 20
5 90029444 SCREW #8-32 X 1/2 PAN HEAD 6
6 53571005 ROD, VERTICAL LATCH RHD 1
7 53567420 CONNECTING ROD, VERTICAL LOCK 1
8 53571006 ROD, HORIZONTAL LOCK RHD 1
9 53571007 ROD, HORIZONTAL LATCH RHD 1
10 90008543 COTTER PIN .094 X .750 4
11 90029428 CAPSCREW, 1/4-20 X 1-1/2 3
12 90005325 CAPSCREW, SELF LOCK 1/4-20 X 1/2 8
13 98421150 FLATWASHER 1/4 4
14 90029040 FASTENER, ROD CLIP 2
15 90029041 RETAINING RING, 0.25 X 0.25 4
16 90030401 HANDLE, PADDLE, DOOR OUTSIDE 1
17 90029043 COLLAR, 1/4 ROD 4
18 90030400 HANDLE, DOOR, INSIDE LOCKING 1
19 90030402 LATCH, LOCKING SINGLE ROTOR 1
20 90029084 BOLT, STRIKER SINGLE ROTOR 1
21 90008570 CAPSCREW 5/16-18 X 1-1/2 13
22 90004171 CAPSCREW, HEX HD G5 5/16-18 X 3/4 13
23 95210420 LOCKNUT ESNA 5/16-18 NC 13
24 98421145 FLATWASHER 5/16 39
25 53567435 DOOR LATCH, SPACER, LH 1
26 53570577 HINGE, SIDE DOOR RHD CAB 1
27 53570580 WELDING, SIDE DOOR RHD 1
28 90008564 CLEVIS PIN, 3/8 X 2-1/4 4
29 53543986 ANGLE, DOOR JAM RHD 1
30 NOT USED -- --
31 53570862 PANEL, WELD CENTER, SIDE DOOR RHD 1
1/28/2010 CBX53576964
CD1021
DECK - BOLTED - RHD

1 REF. GRILL WELDMENT (NOT SERVICED SEPERATELY) 1
2 53569720 FLOOR WELDMENT, RH SIDE (RHD) 1
3 53567608 FLOOR WELDMENT, LH SIDE (RHD) 1
4 53569724 BRACKET, LH REAR CORNER FILLER 1
5 53569725 CHANNEL, LH REAR CORNER BRACE 1
6 53565707 BRACKET, PLATFORM MOUNT (SIDE) 1
7 53568894 CHANNEL, MID DECK SUPPORT 1
8 53568888 BRACKET, CAB REINFORCEMENT RH REAR CORNER 1
9 53568895 ANGLE, CAB SUSPENSION MOUNT RH 1
10 53565695 ANGLE, BRACKET MOUNTING 2
11 53565696 ANGLE, SEAT MOUNTING 2
12 53576197 GASKET, MIRROR POST 1
13 53569726 CHANNEL, DECK REAR 1
14 53565699 BRACKET WELD, CHANNEL SUPPORT 1
15 53569727 CHANNEL, ENGINE HOUSING 1
16 53576706 CHANNEL, LH DECK SUPPORT 1
17 53568898 BRACKET, PLATFORM MOUNT (REAR) 1
18 90028722 CAPSCREW 3/8-16 X 1.25 BUTTON HD (GRADE 8) 79
21 90017717 NUT CROWNLOCK 3/8-16 UNC (GRADE B) 93
22 90017719 NUT CROWNLOCK 1/2-13 (GRADE C) 30
23 90005165 FLATWASHER 3/8 HARD ZINC SAE 168
25 90028724 NUT, SHEET METAL U-TYPE 5/16-18 7
26 53563396 BRACKET, CAB MOUNTING, REAR 1
27 53565712 ANGLE, SIDE PLATFORM SUPPORT 1
28 53576709 MIRROR POST WELD, SQUARE TUBE RHD 1
29 NOT USED ---
30 53569735 ANGLE BRACKET, MIRROR POST SUPPORT 1
31 90028790 PLUG, POLY HOLE 1-1/8 1
32/37 NOT USED ---
38 53568899 ANGLE, REAR FLOOR SUPPORT 1
40 90027537 SCREW SELF TAP 1/4-20 X 1" 5
41 98421150 FLATWASHER 1/4 5
42 90013919 LOCKNUT ESNA 1/4-20 NC 5
43 90029287 CAPSCREW 3/8-16 X 3-1/4 BUTTON HD (GRADE 8) 3
44 53568900 BRACKET, REAR PLATFORM SUPPORT 1
ITEMS NOT SHOWN

--- 90030586 SCREW, 1/2-13 X 1" WASHER HEAD SELF TAP (TYPE F) 1
--- 90028721 CAPSCREW 5/16-18 X 1.25 B. (GRADE 8) SILVER 1
--- 90017716 NUT CROWNLOCK 5/16-18 YBC (BRADE B) 1
--- 90005166 FLATWASHER 5/16 HARDENED 2
--- 53565665 PLATE, FRONT CAB MOUNTING SPACER 1
--- 90032590 CAPSCREW, 3/8-16 X 3.5 BUTTON HD 1
--- 90020563 FLATWASHER 3/8 SS 6
9/18/2008 CD1021A
CD1021
DECK - BOLTED - RHD

1 REF. GRILL WELDMENT (NOT SERVICED SEPERATELY) 1
2 53569720 FLOOR WELDMENT, RH SIDE (RHD) 1
3 53567608 FLOOR WELDMENT, LH SIDE (RHD) 1
4 53569724 BRACKET, LH REAR CORNER FILLER 1
5 53569725 CHANNEL, LH REAR CORNER BRACE 1
6 53565707 BRACKET, PLATFORM MOUNT (SIDE) 1
7 53568894 CHANNEL, MID DECK SUPPORT 1
8 53568888 BRACKET, CAB REINFORCEMENT RH REAR CORNER 1
9 53568895 ANGLE, CAB SUSPENSION MOUNT RH 1
10 53565695 ANGLE, BRACKET MOUNTING 2
11 53565696 ANGLE, SEAT MOUNTING 2
12 53576197 GASKET, MIRROR POST 1
13 53569726 CHANNEL, DECK REAR 1
14 53565699 BRACKET WELD, CHANNEL SUPPORT 1
15 53569727 CHANNEL, ENGINE HOUSING 1
16 53576706 CHANNEL, LH DECK SUPPORT 1
17 53568898 BRACKET, PLATFORM MOUNT (REAR) 1
26 53563396 BRACKET, CAB MOUNTING, REAR 1
27 53565712 ANGLE, SIDE PLATFORM SUPPORT 1
28 53576709 MIRROR POST WELD, SQUARE TUBE RHD 1
29 NOT USED ---
30 53569735 ANGLE BRACKET, MIRROR POST SUPPORT 1
31 90028790 PLUG, POLY HOLE 1-1/8 1
32/37 NOT USED ---
38 53568899 ANGLE, REAR FLOOR SUPPORT 1
40 90027537 SCREW SELF TAP 1/4-20 X 1" 5
41 98421150 FLATWASHER 1/4 5
42 90013919 LOCKNUT ESNA 1/4-20 NC 5
43 90029287 CAPSCREW 3/8-16 X 3-1/4 BUTTON HD (GRADE 8) 3
44 53568900 BRACKET, REAR PLATFORM SUPPORT 1
ITEMS NOT SHOWN

--- 90030586 SCREW, 1/2-13 X 1" WASHER HEAD SELF TAP (TYPE F) 1
--- 90028721 CAPSCREW 5/16-18 X 1.25 B. (GRADE 8) SILVER 1
--- 90017716 NUT CROWNLOCK 5/16-18 YBC (BRADE B) 1
--- 53565665 PLATE, FRONT CAB MOUNTING SPACER 1
--- 90020563 FLATWASHER 3/8 SS 6
9/18/2008 CD1021B
CG1050
CAB GLASS
RHD FRC TINTED

1 53540214 WINDSHIELD, TINTED 1
2 90025729 WEATHERSTRIP SEAL, WINDSHIELD 1
3 53576615 GLASS, WINDOW REAR DOOR TINTED 1
4 90029414 GASKET, REAR DOOR WINDOW RRC 1
5 53576614 WINDOW, REAR CAB WALL RRC TINTED 1
6 90029414 GASKET, REAR WINDOW RRC 1
7 90025942 WINDOW, SLIDING LH TINT 3PC 1 CGX90025942
8 90029417 GASKET, RH SLIDING WINDOW 1
NOT SHOWN
--- 90017053 WINDOW, LH FIXED TINTED 1 CGX90017053
--- 90029418 GASKET, FIXED SIDE WINDOW 1
9/22/2009 CG1050
90017053
WINDOW LH FIXED
TINTED

1 90009578 RUBBER, WINDOW SEAL SLF LUBE (OBS. 01-07-02) 93 IN.
90029418 GASKET, FIXED SIDE WINDOW 1
2 90017053 WINDOW, LH FIXED TINTED 1
7/26/2003 CGX90017053
90025942
WINDOW
RHD SLIDING LH TINT 3PC

1 90025942 WINDOW, SLIDING (ITEMS #3 - #15) 1
2 90009577 WEATHERSEAL, "H" TYPE (OBS. 01-07-02) 153 IN.
90029417 GASKET, RH SLIDING WINDOW 1
3 90026524 FELT, CHANNEL 1

4 90026552 FORWARD GLASS WITH LATCH 1
5 90026551 REAR GLASS WITH LATCH 1
6 90026527 WEATHER STRIP 2
7 90026528 VERTICAL END RAIL 2
8 90026529 CHANNEL - GLAZING 1
9 90026530 GLASS - CENTER FIXED 1
10 90026531 RUBBER - FILLER 21.5" 1
11 90026532 RUBBER - FILLER 14.5" 1
12 90026533 WINDOW STOP 2
13 90026534 FRAME - OUTSIDE 1
14 90026505 LATCH ASSEMBLY - REAR WINDOW 1
15 90026515 LATCH ASSEMBLY - FRONT WINDOW 2
3/15/2005 CGX90025942
CM1554
SWITCH INSTALLATION
CAB TILT (RHD)

1 53569958 HARNESS, CAB TILT SWITCH RHD 1
2 53546407 BRACKET, TILT SWITCH MTG/GUARD 1
4 90804024 CAPSCREW 1/4-20 X 1 1/4 2
5 90022251 BOOT, RUBBER TOGGLE SWITCH COVER 1
6 90022252 SWITCH, TOGGLE MOM ON-OFF-MOM ON 1
7 90011099 EYEBOLT 1/4-20 SHOULDERED 3/4 ID 1
8 90013919 LOCKNUT ESNA 1/4-20 NC 1
6/26/2007 CM1554
CM1558
CAB PIVIOT PIN AND BUSHING INSTALLATION (RHD)

1 90028876 BUSHING, CAB PIVOT 3" OD X 1" ID 2
2 53569017 BRACKET, CAB PIVOT SPACER RH 1
3 53567369 PIN, CAB PIVOT 2
4 98421145 FLATWASHER 5/16 1
5 95210420 LOCKNUT ESNA 5/16-18 NC 1
6 98415042 LOCKWASHER 3/8 2
7 90030311 CAPSCREW 3/8-16 X 1 (GRADE 8) 2
8 53567368 RETAINER, CAB PIVOT BAR 2
9 90022679 TAPE, DOUBLE-SIDED 2 IN.
10 53567335 BUSHING, CAB PIVOT-BOLT DECK 2
6/26/2007 CM1558
TILT PUMP INSTALLATION - 24V STD. VALVE
A B
SECTION B - B
SECTION A - A
CM1567
CM1567
TILT PUMP INSTALLATION - STANDARD VALVE - 24 VOLT

1 53552988 BRACKET WELDMENT, TILT PUMP/HYD VALVE STD. 1
2 90804267 CAPSCREW 1/2-13 X 1 1/2 3
3 90019661 STARWASHER, INTERNAL 1/2 1
4 53543752 CABLE, ASSEMBLY 2 GA B 36 1/2 & 1/2 1
5 90029519 MOTOR PUMP, 24 VOLT 1
6 90804185 CAPSCREW 3/8-16 X 1 3
7 98415042 LOCKWASHER 3/8 2
9 90027604 CLAMP, HOSE 3.5 IN. - 5.5 IN WORM 1
10 NOT USED -
12 90017717 NUT CROWNLOCK 3/8-16 UNC GRADE B 1
13 98415036 STARWASHER INTERNAL 3/8 1
14 53551035 CABLE ASSY 2GA R 26 5/16 & 5/16 1
15 53551018 BRACKET, SOLENOID MOUNTING 1
16 90804018 CAPSCREW 1/4-20 X 1 4
17 90013919 LOCKNUT ESNA 1/4-20 NC 4
19 90023391 SOLENOID, INTERMITTENT 200 AMP - 24 VOLT 1
20 53551034 CABLE ASSY 2 GA RED 10 1/4 & 5/16 1
21 90009383 STARWASHER EXTERNAL 1/4 4
22 95210391 NUT, JAM 5/16-18 HEX GRADE 2 2
23 NOT USED -
24 95210010 NUT, #10-32 HEX BRASS 2
25 98415017 LOCKWASHER #10 2
26 98415035 LOCKWASHER 5/16 2
27 53553521 CABLE ASSY 2 GA B 16 5/16 & 7/16 1
3/18/2004 CM1567
CM1593
CAB MOUNTING INSTALLATION

1 53549644 SAFETY PROP WELD RHD 1
2 53566378 BRACKET WELD, TILT CYLINDER MOUNT LOWER RHD 1
3 NOT USED ---
4 53565986 SHAFT, LOWER TILT CYL MNT 1
5 90005369 CAPSCREW 1/2-13 X 1-1/2 (GRADE 8) 2
7 90010636 CABLE, 3/16 DIA NYLON COATED 140 IN
9 90011098 SLEEVE, CABLE COMPRESION 3/16 2
10 90009066 CAPSCREW 3/4-10 X 7 (GRADE 8) 1
11 90802085 CAPSCREW 1-14 X 5.5 (GRADE 8) 1
12 90831092 COTTERPIN 3/16X1-3/4 1
13 90014363 NUT CROWNLOCK 1-14 (GRADE C) 1
14 95210420 LOCKNUT ESNA 5/16-18 NC 6
6/26/2007 CM1593
CM1601
CAB MOUNTING INSTALLATION

1 90032205 CAB SUSPENSION, 3-POINT LINK 1 CMX90032205
2 90015383 CAPSCREW 5/8-11 X 2-1/4 (GRADE 8) 4
5 96000714 PLUG O-RING #4 1
6 90030171 CAB SUSPENSION, CATCH BRACKET, LINK 1
7 90027579 CARRIAGE BOLT 1/2-13X1 3/4 (GRADE 8) 4
11 90024675 VALVE, CHECK 1/4NPT BRASS 1
12 90021317 VALVE NEEDLE 1/4TUBE 1
14 90002984 CAPSCREW 5/8-11 X 2 (GRADE 8) (NOT SHOWN) 2
15 96051608 ADAPTER #4 O-RING - #4 JIC 1
11/15/2006 CM1601
CM1653
TILT GROUP - TILT PLUMBING

1 96003830 TEE STREET 3/4 HP STEEL 1
2 96081625 ADAPTER #12 X 3/4 NPTM 1
3 53563618 HOSE, ASSY 03912U-612612-05200 1
4 90000315 ADAPTER 1 5/16-12 O-RING X 3/4 NPT 1
5 90709320 REDUCER BUSHING 3/4M 1/2F NPT 1
6 96081617 ADAPTER #6 X 1/2 NPTM 1
7 83012781 HOSE ASSY,16606E-606606-01100 1
8 90024719 HOSE BARB 45 5/8ID X #8 O-RING 2
9 90027435 HOSE WH#H20110-5/8ID 142 IN
10 90812097 CLAMP, HOSE #12 1/2 X 1-1/4 2
11 96052220 ADAPTER 90 #8 JIC #8 O-RING 2
12 53537387 HOSE ASSY 1503-8-411-190296-86 1
13 96052208 ADAPTER 90 #4 JIC #4 O-RING 1
14 53574675 HOSE, ASSY WH43604E-604684-04900 1
16 NOT USED ---
17 53574691 HOSE, ASSY WH43604-604664-09800 1
18 96051606 ADAPTER #6 O-RING- #4 JIC 1
19 96051616 ADAPTER #6 O-RING- #6 JIC 1
20 90804366 CAPSCREW 5/8-11 X 2 2
21 98415055 LOCKWASHER 5/8 2
22 90029665 RESERVOIR, 2 QUART POWER STEERING W/ O-RING 1
23 90029669 CYLINDER, HYDRAULIC CAB TILT 1
90029670 REPAIR KIT FOR 90029669 ---
24 53101502 CLAMP, RUBBER COATED 1/2 ID (NOT SHOWN) 1
25 90804035 CAPSCREW 5/16-18 X 1 4
27 95210420 LOCKNUT ESNA 5/16-18 NC 6
28 90818006 CLAMP,RUBBER COATED 1-1/2 ID (NOT SHOWN) 2
29 90030074 PUMP, P/S 4.36 GPM CCW (REPLACES 90024820) 1
30 90009782 GASKET, POWER STEER PUMP 1
31 90007549 LOCKWASHER M10 2
32 90005362 CAPSCREW M10-1.5 x 30mm CL8.8 2
33 53570063 BRACKET, FUEL FILTER 1
34 NOT USED ---
35 NOT USED ---
36 90014274 DECAL, WARNING ROTATING SHAFT 2
37 90025710 SLEEVE NYLON HOSE COVER .86 ID 29 IN
AFTER 5/20/09 USE THESE PARTS

3 H50712120121325 HOSE ASSY, H507 OAL 1325MM, STRAIGHT 1
7 H50806060060325 HOSE ASSY, H508 OAL 325MM, STRAIGHT 1
12 H50808089082450 HOSE ASSY, H508 OAL 2450MM, 90 1
6/9/2009 CM1653
90032205
CAB SUSPENSION AIR RIDE KIT

1 90030880 SPRING, AIR 1
2 1600839 SHOCK ABSORBER 2
3 90030883 VALVE-CONTROL, HEIGHT 1
4 99802329 AIRLINE-NYLON .250 OD 6 IN.
5 53100533 CONNECTOR, MALE 1/4OD X 1/8P BRASS 1
6 91603044 ELBOW, 1/4 TB X 1/8 M-NPT 2
7 90804027 1/4 X 1-3/4 UNC HEX CAP SCREW (GRADE 5) 2
8 90803066 5/16 x 1-1/2 UNC HEX CAP SCR (GRADE 5) 2
9 90804485 3/8 X 1-1/4 UNC HEX CAP SCR (GRADE 5) 4
12 90804088 7/16 X 2-1/2 UNF HEX CAP SCR (GRADE 5) 2
13 90804235 7/16 x 3-1/4 UNF HEX CAP SCR (GRADE 5) 1
14 90804236 7/16 X 4 UNF HEX CAP SCR (GRADE 5) 1
15 CU 3/8 X 1/2 UNC HEX SOCKET SET SCREW 4
16 CU #4 X 1/4 DRIVE SCREW 2
17 95210058 1/4 UNC HEX NUT (GRADE 8) 2
18 95210330 3/8 UNC HEX NUT (GRADE 8) 8
19 90017720 1/4 UNC HEX CTR LOCK NUT (GRADE 8) 2
20 90012247 5/16 UNC HEX CTR LOCK NUT (GRADE 8) 2
21 90022278 7/16 UNF HEX TOP LOCK NUT (GRADE 8) 4
22 98415020 1/4 LOCK WASHER 2
23 90005165 3/8 LOCK WASHER 4
24 CU 3/8 TYPE A PLAIN WASHER 3
25 90030881 BUMPER 2
26 90030884 BALL-PIVOT, THREADED 2
27 90030885 LINKAGE-VALVE, HEIGHT CONTROL 1
28 90030887 3/4 RETAINER RING 1
29 CU RING-RETAINING, EXTERNAL 4
30 90032200 LATCH 1
31 REF. ID PLATE ---
32 90032201 1/4-15 X 1/2 PLASK H/L PAN HEAD SCREW 1
33 90032202 LEVER 1
34 90030890 PIN-HINGE ARM 2
35 90030886 LINKAGE-CONTROL 1
36 90030891 WASHER-NYLON 4
37 90032207 BRACKET-MOUNT, LATCH RHD 1
38 90030888 HINGE ARM TYPE A 1
39 90032206 BRACKET-MOUNT, FRAME RHD 1
11/15/2006 CMX90032205
CS1234
COOLING SYSTEM

1 90032038 RADIATOR CT144 1
90031180 RADIATOR CAP 1
2 53575233 SPLIT SHROUD, FAN (TOP) 1
53573762 SPLIT SHROUD, FAN (BOTTOM) 1
3 90009818 MOUNT, CENTER BOND RUBBER RAD. 4
4 53569909 PLATE, RADIATOR FRAME MOUNT 2
5 90023091 WASHER .66 ID X 2 OD .94 THK 4
6 53549793 THREADED ROD 5/8-11 X 10 1
8 95210398 NUT, JAM 5/8-11 HEX (GRADE 2) 4
10 90802047 CAPSCREW 5/8-11 X 2-1/2 2
12 90804267 CAPSCREW 1/2-13 X 1-1/2 4
14 53560155 FLANGE WELD 1.75 OD X #24 BEND 1
15 90009702 HOSE, FLEX 1-3/4 X 23.5 1
16 53103024 CLAMP, HOSE #32 1-9/16 X 2-1/2 2
17 90000890 GASKET, RADIATOR FLANGE 2
18 53559754 FLANGE WELD, LOWER RADIATOR - ISB 1
19 90812137 CLAMP, EX BD #40 2-1/16 X 3 3
20 90014994 HOSE, FLEX 2-1/4 X9" LG 1
-- 53573163 HOSE, 2.25 ID X 3 IN LG 1
-- 53569239 ELBOW, 2.24 ID X 4 X 4 WITH 3/4 NPT. 1
21 90804226 CAPSCREW 7/16-14 X 1 4
22 98415045 LOCKWASHER 7/16 4
23 99802351 HOSE, 1" ID 52 IN.
24 90804016 CAPSCREW 1/4-20 X 3/4 12
25 98415020 LOCKWASHER 1/4 12
27 90817033 CLAMP, HOSE #4 7/32 X 5/8 2
28 90021614 HOSE, FUEL WH H057-06 3/8 ID 32 IN.
29 96084016 HOSE BARB 1/4 NPT X 3/8 ID 1
30 90027449 HOSE BARB 90 3/4 NPT X 1" ID 1
31 90009596 SPIRAL WRAP PLASTIC TUBING 30 IN.
32 96084224 HOSE BARB 90 1/2 NPT X 5/8 ID 1
33 90812097 CLAMP, HOSE #12 1/2 X 1-1/4 2
34 99802336 HOSE, 5/8 - HEATER 250 IN.
35 90022527 DECAL, RADIATOR FILL PROCEDURES 1
36 90032350 SENSOR, COOLANT LEVEL 1
37 53574507 HARNESS, COOLANT LEVEL SENSOR 1
38 53550499 RADIATOR MOUNT ASSEMBLY 3 IN EXT. 1 CSX53550499
INSTALLATION - SEE SEPARATE PAGE

-- 53570410 COOLANT RECOVERY INSTALLATION CSX53570410
ITEMS NOT SHOWN

--- 53101502 CLAMP, RUBBER COATED 1/2 ID 2
--- 53103347 CLAMP, HOSE #20 13/16 X 1-3/4 2
--- 90016002 CLAMP, RUBBER COATED 1-3/8 ID 1
--- 90804035 CAPSCREW 5/16-18 X 1 1
--- 95210420 LOCKNUT ESNA 5/16-18 NC 1
--- 98421145 FLATWASHER 5/16 2
--- 90032215 HOSE, ID REDUCER 2-1/4 TO 2.0 IN. ID 1
--- 90005361 CAPSCREW M10-1.5 X 20MM 1
--- 98415017 LOCKWASHER #10 1
--- 90033102 CLAMP, RUBBER COATED 1" DOUBLE 3
12/30/2009 CS1234
DL1015
DRIVELINE
1710 SERIES 1/2 RND

1 REF. TRANSMISSION YOKE (SEE TRANSMISSION) 1 TR GROUP
2 REF. AXLE YOKE (SEE REAR AXLE) 1 RA GROUP
3 90022411 DRIVELINE 1710 1/2 RND 32.6 1
SERVICE PARTS
4 90022392 CROSS-BEARING KIT - 1/2 RND YOKE 1
5 53501015 YOKE SLEEVE ASSY 1
6 53501034 DUST CAP KIT 1
7 90003949 CROSS-BEARING KIT - 1710 DRIVE SHAFT 1
8 53141155 GREASE FITTING 1
12/26/2002 DL1015
TACHOMETER INSTALLATION - 24V RHD
DP1539
DP1539
TACHOMETER INSTALLATION 24V RHD

1 53570011 HARNESS OPTIONAL GAUGE PWR/GND/LTS 1
2 53570010 HARNESS TACHOMETER - DASH PANEL 1
3 53570009 HARNESS TACHOMETER - CAB INTERIOR 1
4 90029110 TACHOMETER HDI 0-3000 AC TAP 1
5 53570007 HARNESS TACHOMETER CHASSIS RHD 1
6 53570008 HARNESS TACHOMETER CAB EXTERIOR 1
NOT ILLUSTRATED
-- 90016010 BULB, 24V WEDGE 655 T-3 1/4 1
8/11/2003 DP1539
DP1628
DASH MODULE - 24 V -
ENGINE GAUGES AND WARNINGS - RHD

1 53573866 PANEL ASSY, ENGINE GAUGES & WARNINGS 1 DPX53573866
2 90029094 GAUGE, HDI FUEL LEVEL 24V 1
3 90029097 GAUGE, HDI OIL PRESSURE 0-100 PSI 24V 1
4 90029105 GAUGE, HDI WATER TEMPERATURE 100-280F 24V 1
5 90032930 SCREW #10-24 X 1 (BLACK) 4
6 53568715 SWITCH ASSEMBLY, HEADLIGHTS 1
7 53573816 HARNESS, DASH PANEL ENG GAUGE & WARNING 1
NOT ILLUSTRATED
-- 90012893 BULB, 12V MINI BAYONET #53 5
11/13/2009 DP1628
DP1665
DASH PANEL INSTALLATION

1 53575105 PANEL ASSY 24V RH CAB CONTROLS 1 DPX53575105
2 90030655 HOUR METER 1
3 53573821 HARNESS, IGNITION SWITCH 1
4 90029102 GAUGE HDI VOLTMETER 1
5 53569029 SWITCH ASSY, FLOOD AND BEACON LIGHTS 1
6 53573818 HARNESS, CAB CONTROLS 1
7 90012893 BULB, 24V MINI BAYONET 4
8 90032930 SCREW #10-24 X 1 (BLACK) 5
9 90030281 SWITCH, IGNITION 2 POSITION SEALED 1
10 53102153 SWITCH, PUSHBUTTON 1
11 53569682 WIRE ASSY IGNITION JUMPER 1
11/13/2009 DP1665
DP1672
DASH MODULE OPTION PANEL

1 53575740 PANEL ASSY - OPTIONAL SWITCHES 1 DPX53575740
2 90032930 SCREW, #10-24 X 1 (BLACK) 4
3 53569249 HARNESS - OPTION PANEL LIGHT BAR 1
11/13/2009 DP1672
PANEL ASSEMBLY - ENGINE GAUGES WARNINGS - 24VOLT - RHD

1 53569995 PANEL, ENGINE GAUGES & WARNINGS 1
2 53566098 PLATE, BACKING - 6 POSITIONS 2
3 90029069 LIGHT TOWER, ALUMINUM 12
4 90029273 LIGHT BAR, PEEL & GLOW 1
5 90029085 CAPSCREW, FLAT HEAD #6-32 X 3/4 8
6 95210656 LOCKNUT ESNA #6-32 X 3/4 8
7 53542724 TILE INDICATOR LIGHT - BLANK 7
8 53563333 TILE INDICATOR LIGHT - TURNSIGNAL SYMBOL GREEN 1
9 53563306 TILE INDICATOR LIGHT - STOP ENGINE RED 1
10 53563310 TILE INDICATOR LIGHT - CHECK ENGINE AMBER 1
11 53563312 TILE INDICATOR LIGHT - SERVICE SOON AMBER 1
12 53567109 TILE LEGEND LIGHT - HEAD LIGHT SYMBOL 1
13 --- NOT USED --
14 53563321 TILE INDICATOR LIGHT - WAIT TO START AMBER 1
11/15/2006 DPX53573866
53575105
PANEL ASSEMBLY - CAB CONTROLS

1 53570020 PANEL CAB CONT. RHD PB START/KEYLESS 1
2 53566098 PLATE, BACKING 6 POSITIONS 1
3 90029069 LIGHT TOWER, ALUMINUM 6
4 90029276 LIGHT BAR, PEEL & GLOW 5.88 1
5 90029277 LIGHT BAR, PEEL & GLOW .75 X 3.00 3
6 90029085 CAPSCREW, FLAT HEAD #6-32X3/4 11
7 95210656 LOCKNUT ESNA #6-32 NC 11
8 53563334 TILE INDICATOR LIGHT - HI-BEAM SYMBOL BLUE 1
9 53563333 TILE INDICATOR LIGHT - TURNSIGNAL SYMBOL GREEN 1
10 53542724 TILE INDICATOR LIGHT - BLANK 5
11 53563325 TILE INDICATOR LIGHT - CHECK TRANS RED 1
12 53563308 TILK INDICATOR LIGHT - BRAKE AIR RED 1
6/26/2007 DPX53575105
53575740
PANEL ASSEMBLY - OPTIONAL SWITCHES

1 53570101 PANEL, OPTIONAL SWITCHES 1
2 53542724 TILE IND LIGHT - BLANK 5
3 90029275 LIGHT BAR, PEEL & GLOW 6.50 24V 1
4 90029085 CAPSCREW, FLAT HEAD #6-32X3/4 2
5 95210656 LOCKNUT ESNA #6-32 NC 2
2/12/2008 DPX53575740
DRIVERS SEAT - RHD
DS1083
DS1083
DRIVERS SEAT - RHD

1 90029846 SEAT, NS - MID BACK GRAY VINYL 1
CALL FOR SERVICE - PLEASE INCLUDE THE
SERIAL NUMBER OF THE SEAT.
2 90000305 SEAT BELT ASSEMBLY, W/ TETHER - BLACK 1
3 53569941 FLOORMAT, RHD DRIVE - BOLTED DECK 1
4 90002993 CAPSCREW 3/8-16 X 1 1/4 GRADE 8 4
7 -------- AIR LINE (PART OF SEAT) -
8 91603181 ELBOW 90 1/4 NYL TUBE X 1/4 NPT 1
9 92003011 BULKHEAD 1/4 NPT 1
10 91603183 ELBOW, 90 3/8 ODT X 1/4 P NYL 1
12 53567619 HOLD DOWN CLIP, FLOORMAT 1
13 53543435 TRIM, FLOOR MAT - REAR 1
14 90021373 SCREW, MN BUT HD 10-24 X 3/8 SS 4
15 NOT USED
16 53569003 TRIM, SIDE DOOR HARNESS COVER 1
17 90021373 SCREW, MN BUT HD #10-24 X 3/8 SS 5
PARTS NOT ILLUSTRATED

95210420 LOCKNUT ESNA 5/16-18 NC 1
98415060 LOCKWASHER 3/4 1
90804160 CAPSCREW 7/16-20 X 1 1/2 3
53527753 BRACKET, HOSE SUPPORT / ROUTING 1
90804035 CAPSCREW 5/16-18 X 1 1
90005166 FLATWASHER 5/16 HARDENED 1
90017717 NUT, CROWNLOCK 3/8-16 UNC GRADE B 1
53101504 CLAMP, RUBBER COATED 3/8 ID 1
9/10/2003 DS1083
ELECTRICAL ALTERNATOR - B/C - ISC - ISB02 - 24 VOLT
EA1042
EA1042
ELECTRICAL ALTERNATOR - B/C - ISC - ISB02 - 24 VOLT

1 90029891 ALTERNATOR, 70 AMP 24 VOLT 1
2 90019770 STARWASHER, INTERNAL 5/16 1
3 90000658 GROUND STRAP, BRAIDED 4GA 8"L 1
4 60000012 CABLE ASSEMBLY, 4 GAUGE RED 99" LONG 1
12/29/2004 EA1042
EB1509
CABLE INSTALLATION
CAB POWER - LH BOX

1 53567579 CABLE ASSY, 1/0 RING PS 127" (RED) 1
2 53567580 CABLE ASSY, 1/0 RING NG 127" (BLACK) 1
3 90026618 CAP, VINYL 0.562 X 0.75 RED 2
4 90026619 CAP, VINYL 0.562 X 0.75 BLACK 2
5 90001830 CROWN NUT, BATTERY TERMINAL 3/8-16 2
8/31/2009 EB1509
POWER CABLE - S40E - RH
EB1547
EB1547
POWER CABLE - S40E - RH

1 53568693 HARNESS, ELEC ENG - ECM GROUND - RH BOX (126 IN) 1
12/2/2003 EB1547
EB1655
BATTERIES -(2) - 24V - SHORT CABLE

1 53570395 COVER WELD, BATTERY BOX W/RUBBER LATCH 1
2 53558009 STEP, BATTERY BOX 1 1/2 OPEN GRIP 3
3 90804018 CAPSCREW 1/4-20 X 1 12
5 90013919 LOCKNUT ESNA 1/4-20 NC 12
6 90802064 CAPSCREW 5/8-11 X 1 3/4 4
7 53572009 BATTERY CASING WELD W/RUBBER LATCH 1
8 53141335 LATCH ASSEMBLY 2
9 53518981 BOARD, BATTERY BOX 12.75 X 13.50 1
10 90001830 CROWN NUT, BATTERY TERMINAL 3/8-16 4
11 90011317 CABLE ASSY, 2/0 24V CROSS STUD 1
12 53557040 CABLE ASSY 3/0 1
13 53558216 CABLE ASSY 3/0 ST/45 RNG PS 65" 1
14 NOT USED ---
15 REF. BATTERIES ---
16 90695909 BOLT, BATTERY HOLD DOWN 4
17 90001821 HOLDDOWN, BATTERY 2
19 95210451 NUT, WING 5/16-18 NC 4
20 90026619 CAP, VINYL 0.562 X 0.75 BLACK 1
21 90012822 SWITCH, BATTERY DISCONNECT 1
22 90012817 COVER PLATE, BATTERY DISCONNECT SWITCH 1
23 53567865 ANGLE, STEP SUPPORT 2
24 53551883 CABLE ASSY., 3/0 1B STUD PS 20 1
SCHEMATICS - SEE SEPARATE PAGE

--- SK8080 BATTERY BOX CABLE ROUTING - 24V --- SK8080
ITEMS NOT SHOWN

--- 53527753 BRACKET, HOSE SUPPORT / ROUTING 1
--- 90804035 CAPSCREW 5/16-18 X 1 2
--- 90804039 CAPSCREW 5/16-18 X 1 1/4 4
--- 53101500 CLAMP, RUBBER COATED 1 IN. ID. 4
--- 90812057 CLAMP, RUBBER COATED 7/8 DOUBLE 1
--- 98421145 FLATWASHER, 5/16 8
--- 90005166 FLATWASHER, 5/16 HARDENED 4
--- 95210420 LOCKNUT ESNA 5/16-18 ESNA 10
8/1/2007 EB1655
EF1073
FLOODLIGHT
STANDARD 24V (RHD)

1 53567603 FLOODLIGHT (MODIFIED), STD RH REAR OF CAB - 24V 1 EFX53567603
2 90019769 STARWASHER, EXTERNAL 5/16 1
3 95210420 LOCKNUT ESNA 5/16-18 NC 1
4 90017836 SWITCH, TOGGLE DPST 1" SEALED 1
6/27/2007 EF1073
53567603
FLOODLIGHT MODIFICATION - 24V

1 90016372 FLOODLIGHT HOUSING FOR 5" LAMP 1
2 90013640 WIRE, SXL 18GA BLACK 11 IN.
3 NOT USED -
4 90010419 TUBING, HEAT SHRINK 1/4 ID 2 IN.
5 90011314 TERM BULLET .156 M 18-20 GA 1
6 90013641 WIRE, SXL 18GA WHITE 19 IN.
7 90011316 TERM BULLET .156 F 18-20 GA 1
8 NOT USED -
9 94422004 CONVOLUTED CONDUIT 1/4 15 IN.
10 90016373 SEALED BEAM FLOODLIGHT 24V 5" 1
6/27/2007 EFX53567603
EG1503
ENGINE/TRANSMISSION
FRAME SIDE MOUNTS

1 53542788 E/T FRAME SIDE MOUNT WELD LH 1
2 90011043 CAPSCREW 1/2-13 X 1-3/4 GRADE 8 6
3 90017719 NUT CROWNLOCK 1/2-13 GRADE C 6
4 53542789 E/T FRAME SIDE MOUNT WELD RH 1
12/26/2002 EG1503
FAN INSTALLATION - ISB
EG1517
EG1517
FAN INSTALLATION

1 90027162 FAN 24" 9 BLADE ISB/ISC 1
2 90026221 SPACER, FAN 2.5 1
3 90022688 CAPSCREW M10-1.50 X 100MM CL10.9 4
4 90007549 LOCKWASHER M10 4
5 90013242 FLATWASHER 10MM SPEC HARDENED 4
6 90029479 CLAMPING PLATE 1
12/26/2002 EG1517
EG1650
ENGINE AIR COMPRESSOR PLUMBING

1 90029931 GOVERNOR ASSEMBLY, AIR 1
2 53140297 GASKET, GOVERNOR 1
3 90029935 CAPSCREW SOC HD M8-1.25 X 70MM CL12.9 2
4 98415035 LOCKWASHER 5/16 2
5 90008345 PLUG 1/8-27 NPT ALLEN HEAD 4
6 90029813 ADAPTER, 90 ADJ M27 X 2 O-RING MALE X #12 JIC 1
7 NOT USED ---
8 53568658 TUBE ASSY, AIR COMPRESSOR OUTLET 1
9 53100533 CONNECTOR MALE 1/4 ODT X 1/8 P BRASS 1
10 90028528 CLAMP, SILICONE COATED 3/4" ID 1
11 90804035 CAPSCREW 5/16-18 X 1 1
12 95210420 LOCKNUT ESNA 5/16-18 NC 1
1/13/2009 EG1650
START RELAY INSTALLATION - 24V STD/CROSSMEMBER
EG1705
EG1705
START RELAY INSTALLATION
24V STD CROSSMEMBER

1 90023391 SOLENOID, INTRMT 200A 24V 1
2 53551022 WIRE ASSY 8 RD/WE #10 & 5/16 38" 1
3 53568699 HARNESS, MID FRAME CROSSMEMBER 1
4 53551222 CABLE ASSY 2GA SP RING RED 46" 1
5 95210010 NUT #10-32 HEX BRASS 2
6 98415017 LOCKWASHER #10 2
7 95210391 NUT JAM 5/16-18 HEX GRADE 2 2
8 98415035 LOCKWASHER 5/16 2
8/8/2003 EG1705
CHARGE AIR COOLER INSTALLATION - RHD - 3" CORE
EG1709
EG1709
CHARGE AIR COOLER INSTALLATION
RHD - 3" CORE

1 90029914 CHARGE AIR COOLER, 3" CORE RHD 1
2 90022099 MOUNT, CENTER BOND 4
3 90022102 WASHER, SNUBBING 1.36 OD X .085 THK 4
4 90803066 CAPSCREW 5/16-18 X 1 1/2 4
5 98415035 LOCKWASHER 5/16 4
3/13/2003 EG1709
BAFFLE INSTALLATION
EG1712
EG1712
BAFFLE INSTALLATION - RHD

1 REFERENCE RADIATOR REWORK, BAFFLE MOUNT 1 EGX53545889
2 NOT USED
3 53570071 BAFFLE, RADIATOR LH - RHD 1
4 90027537 CAPSCREW, TORX 1/4-20 X 1 4
5 NOT USED
6 53570072 BAFFLE, RADIATOR RH - RHD 1
7 53550488 BAFFLE, RADIATOR BOTTOM SIDE PORTS 1
8 90804016 CAPSCREW 1/4-20 X 3/4 12
10 90013919 LOCKNUT ESNA 1/4-20 NC 10
11 90804018 CAPSCREW 1/4-20 X 1 6
12 98415020 LOCKWASHER 1/4 12
13 70000015 WEATHER SEAL, CAC BAFFLE 28 IN.
14 ------ ADHESIVE AR
15 90009685 FLATWASHER 9/32 ID X 1 1/4 OD 10
16 90022102 WASHER SNUBBING 1.36 OD X .085 THK 4
17 95210420 LOCKNUT ESNA 5/16-18 NC 4
19 53569000 PLATE, BAFFLE SUPPORT 2
4/23/2007 EG1712
EG1741
FRONT ENGINE MOUNT

1 53568622 MOUNT WELD, FRONT 1
2 90804495 CAPSCREW 3/8-16 X 1-1/2 6
3 98421135 FLATWASHER 3/8 16
4 90008871 LOCKNUT ESNA *USE 90017717* 3/8-16 NC 8
5 90029818 MOUNT, ENGINE ANTI-VIBRATION 0.68 MTG HOLE 1
6 90804485 CAPSCREW 3/8-16 X 1-1/4 2
7 53567717 CAPSCREW 0.09 HOLE (M16-2 X 80MM) 1
9 REF. THREAD LOCK A/R
10 90011335 WIRE, .051 STAINLESS STEEL SAFETY 10 IN.
1/30/2008 EG1741
EG1810
ENGINE SIDE MOUNTS - MD TRANSMISSION

1 53573655 BRKT WELD, ENGINE MOUNTING 2
2 NOT USED ---
3 90029828 CAPSCREW M12-1.75 X 40MM 8
4 90019912 CAPSCREW 7/8-9 X 5 (GRADE 8) 2
6 90017517 WASHER, SNUBBING 2
7 90017516 RUBBER ISO 2PC ENG/TRANS REAR 2
9 98415050 LOCKWASHER 1/2 8
12/6/2006 EG1810
EG1833
CAC PIPING

1 53573867 TUBE, CAC UPPER QSB 6.7 RHD 1
2 53568957 TUBE, CAC LOWER ISB02 1
3 90020702 HOSE FLEX CAC 3.50ID X 6LG 3
4 53571781 HOSE, 3.00 ID X 4" LG 1
5 90021754 CLAMP, 90" 6
6 90018126 CLAMP, 90" 2
1/26/2007 EG1833
EG1988
ENGINE - CUMMINS - QSB6.7 - 173HP

1 90032468 ENGINE,QSB6.7-173@2200 12V 1
2 70000013 SWITCH, PRESSURE 2LBS TO GRND 1
(SENDING UNIT FOR HOURMETER) ---
3 90018285 SENDER, TEMP 100-280 1
4 NOT USED ---
5 90027267 SENDER, OIL PRESS 100 PSI 1
6 90026784 ADAPTER 1/8FNPT X M10-1.0 1
8 NOT USED ---
9 90009596 SPIRAP PLASTIC TUBING 32 IN.
10 90020738 DECAL, WARNING - ETHER START AIDS 2
11 90027214 DECAL, CAUTION - BATTERY COMPARTMENT 1
12 NOT USED ---
13 53552725 ANGLE, HEATER & A/C HOSE MOUNT 1
14 53576861 HARNESS - ELECT ENG 1
15 90028166 DUAL CLAMP TIE 1
16 NOT USED ---
17 NOT USED ---
18 90032116 STARTER MOTOR 2.7 KW 12 V 1
ITEMS NOT SHOWN

--- 90804035 CAPSCREW 5/16-18 X 1 6
--- 98421145 FLATWASHER 5/16 5
--- 95210420 LOCKNUT ESNA 5/16-18 NC 6
--- 98415017 LOCKWASHER #10 1
--- 90008201 CAPSCREW M8-1.25 X 20MM 1
--- 90030696 HOSE BARB, COOLANT VENT .12 ORFICE 1
--- 90020068 NUT, METRIC 8MM-1.25 2
--- 90030697 FAN CLAMPING PLATE 25.4MM PILOT 1
--- 91603098 ELBOW, 45 STREET 1/8 NPT STEEL 1
--- 90029924 ADAPTER, M14 X 1/8 NPT 1
9/3/2009 EG1988
RADIATOR REWORK - BAFFLE MOUNTS
EGX53545889
53545889
RADIATOR REWORK
BAFFLE MOUNTS

1 REFERENCE RADIATOR -
2 53546921 BRACKET WELDMENT, LOWER BAFFLE MOUNT LH 1
3 53546922 BRACKET WELDMENT, LOWER BAFFLE MOUNT RH 1
2/3/2004 EGX53545889
EL1547
HEADLIGHTS - TAILIGHTS - CAB LIGHTS - 24V REPLACABLE BULBS

1 53565824 BRACKET, HEADLIGHT BUCKET 2
2 53542459 HEADLIGHT ASSY, 24V RECT HALOGEN 2
- 90020856 HEADLIGHT, 24V WO/BULB -
- 90020455 REPLACEMENT BULB FOR HEADLAMP 24V HALOGEN -
4 90027717 NUT, TINNERMAN, 1/4-20 8
5 90009610 GROMMET, RUBBER 5
6 90029314 LIGHT, YELLOW TURN/PARK (HOUSING & LENSE) 2
7 90027619 LIGHT, RED STOP/TURN/TAIL (HOUSING & LENSE) 2
8 90027621 LIGHT, CLEAR BACK-UP (HOUSING & LENSE) 1
9 90028288 DOMELIGHT, W/SWITCH & GROUND WIRE 1
- 53141191 REPLACEMENT LENS -
- 90001939 REPLACEMENT BULB, 24V D.C. BAYONET -
10 90028694 SCREW #6-32 X 3/8 PAN HD TORX 3
11 NOT USED
12 53570221 HARNESS, TAIL LIGHTS - REPLACABLE BULBS 1
13 NOT USED
14 90029313 BULB, 24V D.C. BAYONET 5
12/6/2004 EL1547
EO1118
ENGINE OPTION - DIAGNOSTIC CONNECTION

1 53574716 WIRING HARNESS - J1939 TERM RESIST ENGINE 1
1/10/2007 EO1118
TRAILER ELECTRIC CONNECTION - 24 VOLT - OFF HIGHWAY
ES1568
ES1568
TRAILER ELECTRIC CONNECTION
24 VOLT - OFF HIGHWAY

1 NOT USED -
2 90030130 CABLE ASSEMBLY, 7-WIRE 1
3 95210420 LOCKNUT ESNA 5/16-18 NC 2
4 90804035 CAPSCREW 5/16-18 X 1 2
5 90029035 BRACKET, 6 STATION CB MOUNT 1
6 90020863 CIRCUIT BREAKER 15 AMP 24 VOLT SNAP-IN 5
12/22/2003 ES1568
ES1603
ELECTRICAL SYSTEM - 24 VOLT

1 53573798 HARNESS, CAB EXTERIOR 1
2 53568686 HARNESS, UPPER CAB 1
3 53573795 HARNESS ASSY., MAIN CAB 1 ESX53573795
4/9 NOT USED --
10 60000063 WIRE ASSEMBLY 1
11 NOT USED --
12 53542305 SWITCH ASSEMBLY, TURN SIGNAL 1
13 90032482 NUT, PLASTIC PANEL SHELL SIZE 24 3
14 90032483 LOCKWASHER, WAVY STEEL SHELL SIZE 24 3
15/17 NOT USED --
18 90020504 FUSE, 5 AMP 2
19 90020286 FUSE, 10 AMP 3
20 90020737 FUSE, 20 AMP 2
21/22 NOT USED --
23 90030151 BREAKER, TYPE III 10 AMP MANUAL RESET 5
25/26 NOT USED --
27 90017801 RELAY, 1-FORM-C 40 AMP 24V 9
28 90030148 RELAY, 1-FORM-C 70 AMP 24V W/BRACKET 2
29 90001959 FLASHER, TURN SIGNAL 24 V 1
30 90026618 CAP, VINYL 0.526 X 0.75 RED 2
31 90026619 CAP, VINYL 0.526 X 0.75 BLACK 1
32 90029571 STUD, TERMINAL 3/8-16 RED 1
33 90029269 STUD, PASS THRU 3/8-16 RED 1
34 90029342 STUD, PASS THRU 3/8-16 BLACK 1
35 90029407 NUT, HEX 3/8-16 BRASS 3
36 90027282 SCREW, THUMB 1/4-20 X 3/4 2
37 90027645 WASHER, NYLON .5 X .25 X .031 4
38 90027228 RETAINER, PUSH ON 2
39 90027537 SCREW, 1/4-20 X 1 SELF TAP 4
40 90020773 SCREW #10-24 X 3/4 SELF TAP (BLACK) 2
41 90029285 SCREW #10 AB X 1/2 PAN SELFTAP 2
ITEMS NOT SHOWN

-- 90005165 FLATWASHER 3/8 HARD ZINC 5
-- 90019771 STARWASHER EXTERNAL 3/8 4
-- 90005167 FLATWASHER 1/4 HARDENED 1
-- 90013919 LOCKNUT ESNA 1/4-20 NC 1
-- 90004335 STARWASHER EXTERNAL #10 2
-- 53102444 CLAMP, RUBBER COATED 2 IN. ID. 1
-- 53102803 PLUG, NYLON 1 IN. DIA HOLE 1
-- 90032419 SCREW, PAN HD. SELF TAP #10X3/8 4
-- 90001830 CROWN NUT, BATTERY TERMINAL 3/8-16 2
SCHEMATICS
SK8176 SCHEMATIC E6 12/24 VOLT LHD 1 SK8176 A-J
4/18/2008 ES1603A
ES1603
ELECTRICAL SYSTEM - 24 VOLT

1 53573798 HARNESS, CAB EXTERIOR 1
2 53568686 HARNESS, UPPER CAB 1
3 53573795 HARNESS ASSY., MAIN CAB 1 ESX53573795
4/9 NOT USED --
10 60000063 WIRE ASSEMBLY 1
11 NOT USED --
12 53542305 SWITCH ASSEMBLY, TURN SIGNAL 1
13 90032482 NUT, PLASTIC PANEL SHELL SIZE 24 3
14 90032483 LOCKWASHER, WAVY STEEL SHELL SIZE 24 3
15/17 NOT USED --
18 90020504 FUSE, 5 AMP 2
19 90020286 FUSE, 10 AMP 3
20 90020737 FUSE, 20 AMP 2
21/22 NOT USED --
25/26 NOT USED --
27 90017801 RELAY, 1-FORM-C 40 AMP 24V 9
28 90030148 RELAY, 1-FORM-C 70 AMP 24V W/BRACKET 2
29 90001959 FLASHER, TURN SIGNAL 24 V 1
30 90026618 CAP, VINYL 0.526 X 0.75 RED 2
31 90026619 CAP, VINYL 0.526 X 0.75 BLACK 1
32 90029571 STUD, TERMINAL 3/8-16 RED 1
33 90029269 STUD, PASS THRU 3/8-16 RED 1
34 90029342 STUD, PASS THRU 3/8-16 BLACK 1
35 90029407 NUT, HEX 3/8-16 BRASS 3
36 90027282 SCREW, THUMB 1/4-20 X 3/4 2
37 90027645 WASHER, NYLON .5 X .25 X .031 4
38 90027228 RETAINER, PUSH ON 2
39 90027537 SCREW, TAPTITE 1/4-20 X 1 SELF TAP 4
41 90029285 SCREW #10 AB X 1/2 PAN SELFTAP 2
ITEMS NOT SHOWN

-- 90005165 FLATWASHER 3/8 HARD ZINC 5
-- 90019771 STARWASHER EXTERNAL 3/8 4
-- 90013919 LOCKNUT ESNA 1/4-20 NC 1
-- 90004335 STARWASHER EXTERNAL #10 2
-- 53102444 CLAMP, RUBBER COATED 2 IN. ID. 1
-- 53102803 PLUG, NYLON 1 IN. DIA HOLE 1
-- 90032419 SCREW, PANHD. SELF TAP #10X3/8 4
-- 90001830 CROWN NUT, BATTERY TERMINAL 3/8-16 2
SCHEMATICS
SK8176 SCHEMATIC E6 12/24 VOLT LHD 1 SK8176 A-J
4/18/2008 ES1603B
ES1617
ENGINE ELECTRICAL COMPONENTS

1 53573964 DECAL, FUSE PANEL 12V 1
2 90020504 FUSE, 5 AMP 1
3 90020181 FUSE, 30 AMP 1
4 NOT USED --
5 53568932 DECAL, RELAY BLOCK - STANDARD 1
6 53568933 DECAL, RELAY BLOCK - STANDARD/OPTION 1
7 53568934 DECAL, RELAY BLOCK - OPTION 1
8 53574388 SWITCH ASSEMBLY, DIAGNOSTICS 1 ESX53574388
9 90020773 SCREW #10-24 X 3/4 SELFTAP (BLACK) 2
10 90709340 REDUCER BUSHING 1/4M X 1/8F NPT 1
11 53573895 HARNESS, BRAKE SWITCH 1
ITEMS NOT SHOWN

--- 90026967 SWITCH, BRAKE GOLD CONTACTS 1
6/21/2007 ES1617
ES1622
ELECTRICAL SYSTEM - CHASSIS

1 53573802 WIRING HARNESS, RHD CHASSIS REPLACEABLE BULBS 1
11/17/2006 ES1622
ES1628
ACCELERATOR PEDAL

1 90029952 PEDAL, ACCELERATOR ELECTRONIC FLOOR MOUNTED 1
2 90028959 CAPSCREW / WASHER 5/16-18 X 1-1/4 BUTTON HD BLACK 3
4 95210420 LOCKNUT ESNA 5/16-18 NC 3
3/20/2009 ES1628
53573791
HARNESS - 12/24V - RHD - MAIN CAB

1 53573791 WIRING HARNESS, 12/24V RHD MAIN CAB 1
11/20/2006 ESX53573791
53573795
HARNESS ASSEMBLY - 12/24V - RHD - MAIN CAB

1 53573791 WIRING HARNESS, 12/24V RHD MAIN CAB 1 ESX53573791
2 53569977 BRACKET ASSY, FUSE PANEL MOUNTING UPPER 1
3 53568924 BRACKET ASSY, FUSE PANEL MOUNTING SIDE 2
4 53568926 PLATE, FUSE PANEL MOUNTING LOWER 1
5 53569979 COVER, FUSE PANEL RHD 1
6 53570022 BRACKET WELD, RELAY MOUNTING RHD 1
7 90020773 SCREW #10-24 X 3/4 SELFTAP (BLACK) 10
8 90029285 SCREW # 10-AB X 1/2 PAN SELFTAP 11
9 90004335 STARWASHER EXTERNAL #10 10
10 98415017 LOCKWASHER #10 1
11 90005168 FLATWASHER #10 HARDENED (3/16) 2
12 90032214 POP RIVET, LARGE FLANGE 1/8 X .313 GRIP .126-.187 1
11/20/2006 ESX53573795
53574388
DIAGNOSTIC SWITCH ASSEMBLY

1 53574389 WIRING HARNESS, DIAGNOSTIC SWITCHES 1
2 90017836 SWITCH, TOGGLE ON-OFF 1.25" SEALED 1
3 90022252 SWITCH, TOGGLE MOM ON-OFF-MOM ON 1.25" SEALED 1
4 53574387 BRACKET, DIAGNOSTIC SWITCH MOUNTING 1
5 53559819 DECAL, DIAGNOSTIC 1
6 53574713 WIRING HARNESS, DIAGNOSTIC CAB CONNECTION 1
ITEMS NOT SHOWN

--- 97205174 SCREW, RDHD #4-40 X 3/8 LG 4
--- 98410011 FLATWASHER, 1/8 ID #4 4
--- 95210662 LOCKNUT ESNA #4-40 NC 4
11/17/2006 ESX53574388
MUFFLER INSTALLATION - VERTICAL - QSB - RHD
EX1558
EX1558
MUFFLER INSTALLATION VERTICAL - QSB - RHD

1 60000000 CHANNEL, WELDMENT VERTICAL MUFFLER 1
2 53570452 EXHAUST, STANDOFF WELDMENT 1
3 90802064 CAPSCREW 5/8-11 X 1 3/4 6
5 90804366 CAPSCREW 5/8-11 X 2 6
6 90017712 NUT, CROWNLOCK 5/8-11 GRADE C 6
7 90002305 CLAMP, 4 IN. ZINC COATED 2
9 98421135 FLATWASHER 3/8 4
10 90007177 MUFFLER, VERTICAL 9X50.5 1
11 90007234 BRACKET, VERTICAL MUFFLER CAGE 2
12 90007233 CAGE, VERTICAL MUFFLER 1
13 90000966 EXHAUST STACK 4 IN. OD X 48 IN. LONG 1
6/14/2004 EX1558
EX1609
EXHAUST PIPING - VERTICAL - QSB

1 53570488 TUBE WELDMENT, EXHAUST AT TURBO 1
2 60000098 TUBE, EXHAUST AT MUFFLER RHD 1
3 53573896 BRACKET, EXHAUST MOUNT/HEAT SHIELD 1
4 60000099 BRACKET, EXHAUST SUPPORT (UPPER) RHD 4" MUFFLER 1
5 53570380 TUBE EXHAUST, RHD AT MUFFLER 1
6 90017791 CLAMP, V-BAND EXHAUST 3" 1
8 90010787 CLAMP, EXHAUST 4" 6
9 98421135 FLATWASHER 3/8 6
10 90015036 TUBING, FLEX EXHAUST 4" ID 16 " LONG 1
11 90024217 CAPSCREW M8-1.25 X 30MM 4
12 98415035 LOCKWASHER 5/16 4
13 53570489 TUBE, EXHAUST LOWER TURBO 1
14 53574087 TUBE , EXHAUST UNDER INGINE 4 IN. 1
15 90005166 FLATWASHER 5/16 HARNDENED 4
1/26/2007 EX1609
FA1113 - 90028792
FRONT AXLE ASSEMBLY

1 90024546 AXLE CENTER BEAM 1
2A 90024602 KNUCKLE ASSEMBLY LH 1
2B 90024603 KNUCKLE ASSEMBLY RH 1
3 90028741 KNUCKLE PIN 2
4 90014012 DRAW KEY - UPPER 2
5 90014013 DRAW KEY - LOWER 2
6 90002452 NUT 4
7 90002446 UPPER SEAL 2
8 90002447 SHIM .005 AR
90002448 SHIM .010 AR
90007521 SHIM .015 AR
9 90002446 LOWER SEAL 2
10 90024414 THRUST BEARING 2
11 90024415 STOP SCREW 2
12 90024416 NUT 2
13 90008413 BUSHING 4
14 90014014 GASKET, CAP 4
15 90009894 CAP - KNUCKLE PIN 4
16 90026079 CAPSCREW 12
17 90025792 LOCKWASHER 12
19 90024603 STEERING ARM 1
20 90025793 KEY 1
21 90000355 NUT 1
22 90000353 COTTER PIN 1
26 90026898 TIE ROD ARM LH 1
26A 90026899 TIE ROD ARM RH 1
27 90025793 KEY 2
28 53141802 NUT 2
29 90000353 COTTER PIN 2
30 90026900 CROSS TUBE ASSY. W/ENDS 1
90028256 CROSS TUBE ONLY - NO ENDS -
31 53100736 CLAMP 2
32 90002457 CAPSCREW 2
33 95210150 NUT 2
34 90003920 TIE ROD END LH 1
34A 90003919 TIE ROD END RH 1
35 53100737 NUT 2
36 90017182 COTTER PIN 2
NOT ILLUSTRATED
-- 90013937 KING PIN KIT (BOTH ENDS) -
9/16/2003 FA1113A
FA1113 - 90028792
FRONT BRAKE ASSEMBLY

1 90027989 BRAKE SHOE & LINING 4
2 90026087 RETAINING SPRING 4
3 90003466 ANCHOR PIN BUSHING 4
4 90003469 ANCHOR PIN 4
5 90024403 CAMSHAFT LH 1
90024404 CAMSHAFT RH 1
6 90026086 WASHER 2
7 90003463 SEAL - CAMSHAFT 4
8 90024551 BUSHING, SPIDER 4
9 53140862 PIN, BRAKE SHOE RETURN SPRING 4
10 90028324 ROLLER, BRAKE SHOE 4
11 90008606 RETAINER, SHOE ROLLER 4
12 90024626 RETURN SPRING, BRAKE SHOE 2
13 90028325 BRAKE SPIDER LH 1
90028326 BRAKE SPIDER RH 1
90002312 CAPSCREW 14
90001875 WASHER, FLAT 28
90007938 NUT, LOCK 14
14 90022039 O-RING CHAMBER BRACKET 2
15 90026076 BRACKET, CAMSHAFT & CHAMBER LH 1
90026072 BRACKET, CAMSHAFT & CHAMBER RH 1
16 90003470 FLATWASHER 8
17 90028327 CAPSCREW 8
19 90024459 WASHER - SPACER 2
90024460 WASHER - SPACER 2
20 90024850 SLACK ADJUSTER - AUTO LH 1
90024851 SLACK ADJUSTER - AUTO LH 1
21 90003476 WASHER, OUTER SPACER 2
22 90005485 LOCKRING, CAMSHAFT 2
23 90008610 DUST SHIELD 2
24 90024413 CAPSCREW 12
NOT ILLUSTRATED
-- 90024412 BRAKE CHAMBER - RH 1
-- 90024763 BRAKE CHAMBER - LH 1
-- 90028656 MINOR BRAKE KIT (1 WHEEL END) -

-- 90028824 MAJOR BRAKE OVERHAUL KIT (1 END) -
9/16/2003 FA1113B
FA1113 - 90028792
HUB AND DRUM

-- 90028328 HUB, DRUM, CUPS & STUDS -
1 90024615 WHEEL NUTS M22-1.5 20

3 90021506 BRAKE DRUM 2
4 90025791 SCREW - HUB CAP 12
5 90025792 LOCKWASHER 12
6 90024354 HUB CAP 2
7 90024424 GASKET, HUB CAP 2
8 53100721 JAM NUT 2
9 53100723 RING, LOCKWASHER 2
10 53100722 NUT LOCK, PIERCED 2
11 53140509 NUT, FRONT WHEEL BEARING ADJ. 2
12 53141813 OUTER CONE 2
13 90010076 OUTER CUP 2
14 90028329 HUB ASSEMBLY (W/CUPS & STUDS) 2
15 90024356 WHEEL STUD 20
16 90010077 INNER CUP 2
17 90007534 INNER CONE 2
18 90002479 SEAL - WHEEL BEARING 2
9/16/2003 FA1113C
FF1064
MUD FLAP INSTALLATION
FRONT AXLE - 20X20 RIGHT SIDE

1 60000071 BRACKET, MUD FLAP MOUNT 1
2 53558072 MUD FLAP 20 X 20 BLACK 1
3 90804018 CAPSCREW 1/4-20 X 1 4
4 90009685 FLATWASHER 9/32 ID X 1 1/4 OD 4
5 90013919 LOCKNUT ESNA 1/4-20 NC 5
2/6/2003 FF1064
FF1128
FENDER AND FLAP INSTALLATION

1 53547610 BRACKET WELD, FENDER HANGER RH RR STD 1
2 53547615 BRACKET WELD, FENDER HANGER LH RR STD 1
3 90019683 CAPSCREW 5/8-11 X 5 1/2 (GRADE 8) 2
4 98421125 FLATWASHER 5/8 2
5 90022640 SPRING, DIE MEDIUM HEAVY LOAD 2
6 53551827 FENDER, BELTED 27" X 48" 2
7 90023067 MUD FLAP, 24 X 20 X NO LOGO 2
8 90019911 CAPSCREW 1/2-13 X 2 1/2 (GRADE 8) 4
9 90804018 CAPSCREW 1/4-20 X 1 40
10 90009685 FLATWASHER 1 1/4 X 9/32 X .05 THK 40
12 90013919 LOCKNUT ESNA 1/4-20 NC 40
13 53552149 FENDER HANGER WELD, RH FRT STD 1
14 53552152 FENDER HANGER WELD, LH FRT STD 1
16 53526870 SPACER, 1 OD X 1/2 ID X 3/8 LG 2
6/28/2007 FF1128
FL1192
FUEL LINE GROUP

1 53559696 ANGLE, MUD FLAP/FUEL FLTR RHD 1
3 90804366 CAPSCREW 5/8-11 X 2 2
4 53558071 MUD FLAP MOD 20 X 30 BLACK 1
6 90804018 CAPSCREW 1/4-20 X 1 3
7 90009685 FLATWASHER 9/32 ID X 1 1/4 OD X .05 THK 3
8 90013919 LOCKNUT ESNA 1/4-20 NC 3
9 96082218 ADAPTER, 90 #8 JIC X 3/8 MNPT 1
10 90817033 CLAMP, HOSE #4 7/32 X 5/8 3
11 90005480 HOSE FUEL 5/16 ID 16 IN.
12 H508088089082750 HOSE ASSY H508 OAL 2750 MM 1
14 95210420 LOCKNUT ESNA 5/16-18 NC 1
15 90005480 HOSE FUEL 5/16 ID 72 IN.
16 H50808089082300 HOSE INSTALLATION H508 OAL 2300MM 1
17 90021818 HOSE BARB 90D 3/8 NPT X 5/16 ID 1
18 53569999 HARNESS CP FUEL SENDER (NOT SHOWN) 1
19 53574119 BRACKET, FILTER HEAD MNT 1
20 90804271 CAPSCREW 1/2-13 X 1 3/4 2
23 90029916 ADAPTER M12-1.5 X #8 JIC 3
24 90804485 CAPSCREW 3/8-16 X 1 1/4 2
27 90029919 SEAL, FITTING 12MM 3
28 NOT USED --
29 53573122 HARNESS CP FUEL SENDER (NOT SHOWN) 1
30 53575820 WIRING HARNESS (NOT SHOWN) 1
7/9/2009 FL1192
FR1501
CROSSMEMBER INSTALLATION
MID FRAME

1 53546710 PLATE CROSSMEMBER PLATE 1
2 90802036 CAPSCREW 1/2-13 X 2 4
4 53546711 BAR, FORMED MID FRAME XMBR 2
5 90005369 CAPSCREW 1/2-13 X 1 1/2 GRADE 8 4
12/26/2002 FR1501
FR1681
FRAME COMPONENTS

1 90007939 CAPSCREW 5/8-11 X 1-3/4 (GRADE 8) 55
4 90011043 CAPSCREW 1/2-13 X 1-3/4 (GRADE 8) 6
6 90012404 CAPSCREW 3/4-10 X 1-1/2 (GRADE 8) 4
7/19/2007 FR1681
FR2037
FRAME 110WB STATIONARY FIFTH WHEEL

1 53500027 BUSHING, BRONZE - REAR SPRING HANGER 2
FRAME NOT SERVICEABLE
FOR REPAIR OR REPLACEMENT CALL:

PARTS AND SERVICE
KALMAR CORP.
6/13/2008 FR2037
FS1001
FRONT SUSPENSION
10 LEAF LH - 9 LEAF RH

1 ------ FRONT AXLE - SEE FA SECTION - FA
2 53540075 SPRING, 9 LEAF FRONT 1
3 90022880 SPRING, 10 LEAF FRONT 1
4 NOT USED SPACER WELD, FRONT AXLE -
5 90001931 BUSHING, BRONZE - SPRING END 4
6 53540500 SHACKLE WELD, SPRING 2
7 53502863 PIN WELD KIT, SPRING HANGER 6
92408022 ZERK, GREASE STR. 1/8 PIPE 6
10 53540501 PLATE, SPRING SHACKLE 2
11 53500027 BUSHING, BRONZE - REAR SPRING HANGER 2
12 53540449 RUBBER BLOCK, FRONT AXLE STOPS 2
13 90804495 CAPSCREW 3/8-16 X 1 1/2 4
98421135 FLATWASHER 3/8 4
90017717 NUT CROWNLOCK 3/8-16 UNC GRADE B 4
16 53540768 AXLE STOP WELDMENT 2
19 90009066 CAPSCREW 3/4-10 X 7 GRADE 8 4
20 90009067 CAPSCREW 3/4-10 X 7 1/2 GRADE 8 4
12/26/2002 FS1001
FT1043
FUEL TANK INSTALLATION

1 90021763 BRACKET, FUEL TANK 24" DIA 2
2 90021764 STRAP, FUEL TANK 24"DIA 2
3 90021758 RUBBER, FUEL TANK STRAP 2X37 2
6 70000018 FUEL TANK, 50 GAL 24" DIA 1
7 90018974 CAPSCREW 5/8-11X2 COUNTER BORE 4
8 98415055 LOCKWASHER 5/8 4
10 53575651 LOW FUEL LEVEL LIGHT & SIREN INSTALLATION 1 FTX53575651
11 90019272 FILL CAP 1
6/27/2008 FT1043
53575651
LOW FUEL LEVEL LIGHT INSTALLATION

1 90017145 SENDER, FUEL LEVEL/ALARM 24V 1
2 90030585 SCREW, #10-32 X 1-1/4" OVAL PHILLIPS HD SS 5
3 53573121 HARNESS CP FUEL SENDER- 4 WIRE 1
4 53570000 HARNESS CP LOW FUEL WARNING - CHASSIS 1
5 53575781 WIRING HARNESS, CAB, LOW FUEL WARNING EXTERIOR 1
6 53575782 WIRING HARNESS, CAB, LOW FUEL WARNING INTERIOR 1
7 53575459 WIRING HARNESS, LOW FUEL WARNING DASH-LIGHT/SIREN1
8 53563323 TILE IND LIGHT - LOW FUEL AMBER 1
9 90012893 BULB, 24V MINI BAYONET 356 G-3 1/2 (SHORT) 1
10 53573123 DECAL, FUSE BLOCK OVERLAY 5 AMP 1
11 90020504 FUSE 5 AMP 1
12 90010212 SIREN, MINI 1
8/9/2007 FTX53575651
FW1290
FIFTH WHEEL GROUP - FW3500

-- 53572857 STATIONARY 5TH WHEEL ASSEMBLY 1
-- -- ITEMS 1, 2, & 3 --
1 90027838 5TH WHEEL ASSEMBLY 1 FWX90027838
2 53572105 SPACER, .750 X 4.0 X.14.0 2
3 53570113 PLATE MOUNTING FIFTH WHEEL FEET 4
4 90008358 CAPSCREW 3/4-10 X 4 (GRADE 8) 16
7 90028339 ELBOW 90 SWIVEL PUSH CONN 3/8 OD X 3/8 NPT 2
9 91603183 ELBOW, 90 3/8ODT X 1/4P NYL 2
10 92003011 BULKHEAD 1/4 NPT 1
11 99802340 TUBE, NYON AIRBRAKE 3/8 BLACK 105 IN.
12 92408022 ZERK, GREASE STR. 1/8 PIPE 2
11/12/2010 FW1290
90027837
FIFTH WHEEL SUB-ASSEMBLY
TOP PLATE - ON HIGHWAY

1 REF. FIFTH WHEEL PLATE 1
2 90026589 YOKE SUB-ASSEMBLY 1
3 90028181 PLATE, UNLATCH CAM 1
4 90029180 WASHER, UPPER 1
90028183 WASHER, LOWER 1
5 90028180 CAPSCREW 5/8-18 X 1 3/4 1
6 53102524 ROLLER 1
7 53102509 SPRING 1
8 53102537 YOKE SHAFT 1
9 53141423 ROLL PIN 1
10 53141422 TORSION SPRING 1
11 90008689 LOCK BAR 1
12 90008682 WASHER 3
13 90028187 SPRING 1
14 90026593 RELEASE HANDLE 1
15 90028182 WASHER 3
16 90008685 SECONDARY LOCK HANDLE 1
17 90028184 NUT, FLANGE 3/8-16 2
18 90028339 CONN 90 DEG 3/8 PTC SWIVEL 1
19 90026594 AIR CYLINDER SUB ASSEMBLY 1
20 90026595 SPRING, EXTENSION 1
22 90027070 CAPSCREW 1/2-20 X 1 3/4 1
23 90027071 LOCKNUT CROWNLOCK 1/2-20 1
24 53102538 ROLLER 1
25 90831099 COTTER PIN 1/4" X 2" 2
90035047 SNAP RING (NOT SHOWN) 2
(REPLACES COTTER PIN AFTER 8/1/09)
26 90026597 LOCK JAW SET 1
27 90026598 LOCK PIN 2
90035048 PIN, GOOVED (NOT SHOWN) 2
(REPLACES LOCK PIN AFTER 8/1/09)
28 ------------- POP RIVET 2
29 ------------ NAME TAG 1
30 90028185 BOLT, SOCKET HD SHLDR 3/8-16 X 1 5/8 2
31 90028338 CONN 90 DEG 1/4 PTC SWIVEL EXHAUST 1
32 90012849 LINER 2
33 90012850 STOP, LINER - FIFTH WHEEL 4
** 90027760 REBUILD KIT --
FWX90027837
9/10/2009
90027838 - FIFTH WHEEL ASSEMBLY
FWX90027838
90027838
FIFTH WHEEL ASSEMBLY

1 90027837 FIFTHWHEEL TOP PLATE ASSEMBLY 1 FWX90027837
2 53573505 FIFTH WHEEL FOOT 2
3 90008854 5TH WHEEL PIVOT PIN 2
4 90011909 5TH WHEEL PIVOT BUSHING 2
5 90008855 5TH WHEEL ROLL PIN 2
5/8/2008 FWX90027838
GH1022
GRAB HANDLES
RHD CAB

1 90804035 CAPSCREW 5/16-18 X 1 6
2 98415035 LOCKWASHER 5/16 6
4 90804185 CAPSCREW 3/8-16 X 1 4
9 53569954 GRAB HANDLE WELD, REAR 1
7 53567502 GRAB HANDLE WELD, REAR CAB SIDE 1
8 98415042 LOCKWASHER 3/8 2
6/28/2007 GH1022
HC1523
HEATER PLUMBING KIT

1 90020989 VALVE, SHUT-OFF 5/8 ID HOSE 1
2 92413004 GROMMET, 1" ID X 1/4 G X 1 - 1/4 GD 2
3 90812097 CLAMP, HOSE #12 1/2 X 1 1/4 2
4 99802336 HOSE, HEATER - 5/8" ID 8 IN.
12/26/2002 HC1523
HC1543
AIR CONDITIONING CONTROLS

1 53569004 SWITCH ASSEMBLY, A/C ON/OFF 1
2 53569006 HARNESS, A/C COLD CONTROL/LOW PRESSURE SWITCH 1
12/26/2002 HC1543
HC1575
HEATER / AC INSTALLATION
24 V

1 90017562 AIR DIFFUSER BALL LOUVER ASSEMBLY 1
2 NOT USED --
3 90008862 CLAMP, EX BD #36 1 13/16 X 2 3/4 2
4 90027604 CLAMP, HOSE 3.5" - 5.5" WORM 2
5 90032216 HOSE 5" FLEXIBLE DUCT 8.5" LG 1
6 90032013 HEATER/AC ASSEMBLY 1 HCX90032013
7 90032011 BLOWER ASSEMBLY, 24 V 1 HCX90032011
8/9 NOT USED --
10 90032087 EVAPORATOR DRAIN KIT, MOBILE CLIMATE CONTROLS 2
11 NOT USED --
12 92413000 GROMMET, 11/16 ID X 1/8 G X 1 GD 2
13 90021161 HOSE 2 1/2" ID FLEXIBLE DUCTING 52 IN.
14 90804016 CAPSCREW 1/4-20 X 3/4 3
15 98415020 LOCKWASHER 1/4 3
17 98415035 LOCKWASHER 5/16 2
18 98421145 FLATWASHER 5/16 2
19 90017716 NUT CROWNLOCK 5/16-18UNC GDB 2
11/17/2006 HC1575
HC1581
HEATER CONTROLS

1 90032108 HEATER CONTROL PACKAGE 1 HCX90032108
2 90028861 SCREW, #6 X 1/2 FLAT HEAD PHILLIPS (BLACK OXIDE) 4
12/27/2005 HC1581
HC1592
A/C COMPRESSOR INSTALLATION

1 70000010 COMPRESSOR MTG KIT CUMMINS "ISB02" 1
2 90005420 V-BELT .50 WIDTH X 43.25 (1) 1
3 53574722 COMPRESSOR, A/C 1
4 90010381 CAPSCREW M8-1.25 X 100MM 4
5 90020346 PULLEY, V-BELT (INCLUDED IN KIT-SEE ITEM 1) 1
12/13/2006 HC1592
HC1618
A/C CONDENSOR COMPONENTS
ITEM NO. PART NO. DESCRIPTION QTY.

1 90030759 COIL A/C CONDENSOR 22 X 32 X HATCHED CORE 1
2 53549607 BRACKET, A/C CONDENSOR MOUNT W/CAC UPPER 4
3 90804016 CAPSCREW 1/4-20 X 3/4 4
5 98415020 LOCKWASHER 1/4 4
6 53570089 PLATE RECIEVER DRYER MTG 1
7 90804037 CAPSCREW 5/16-18 X 3/4 2
8 98415035 LOCKWASHER 5/16 4
9 98421145 FLATWASHER 5/16 2
10 90030745 FILTER RECEIVER DRIER A/C 12 CUBIC IN DESICCANT 1
11 90032347 CLAMP, EX BD #48 2-9/16 X 3-1/2 2
5/14/2008 HC1618
HC1627
HEATER - A/C PLUMBING

1 53551712 SWITCH, (MODIFIED) A/C 350-250PSI 1
2 90024287 ADAPTER 90 #10M X #10F 1
3 90024288 ADAPTER 90 #8M X #8 FBMP-TB 1
4 53575954 HOSE, ASSY, P2856-15S26-15T26-04350 1
5 90812057 CLAMP RUBBER COATED 7/8 DOUBLE 3
6 90804037 CAPSCREW 5/16-18 X 3/4 3
7 98421145 FLATWASHER 5/16 3
8 NOT USED ---
9 53576479 HOSE, ASSY P2856-1S526-15T26-09000 RHD 1
10 53576480 HOSE, ASSY P28510-1S526PR-15S26-08900 RHD 1
11 53552685 SWITCH (MODIFIED) A/C 34-6PSI 1
13 95210420 LOCKNUT ESNA 5/16-18 NC 3
14 REF. REFRIGERANT R-134A 2 LB
15 90028144 ADAPTER 90 #6M X #6F BUMP TUBE O-RING 1
16 NOT USED ---
17 53575963 HOSE, ASSY, P2858-15S26-15T26-04800 1
18 98415035 LOCKWASHER 5/16 3
20 95210420 LOCKNUT ESNA 5/16-18 NC 1
21 90029927 ADAPTER, 90 #10, X #10F BUMP TUBE O-RING 1
4/8/2008 HC1627
90032011
BLOWER ASSEMBLY - 24 VOLT

1 90031377 BLOWER HOUSING RHD 1
2 90031227 HOSE ADAPTER 2.5" 2
3 90032070 DIFFUSER ASSY. 1
4 90032069 COVER 1
5 90032068 FLAPPER DOOR 1
6 90032066 SIDE MTG BRACKET - L 1
7 90032067 SIDE MTG BRACKET - R 1
8 90031215 CABLE CLAMP 1
9 90031220 PVC FOAM 1
10 90031221 3/16" SNAP BUSHING 2
11 90032065 INSULATION 1/4 " 1
12 90031381 INSULATION 1/4 " 1
13 90031236 WIRING HARNESS 1
14 90031247 MOTOR 24 V RHD 1
15 90031246 RESISTOR 24 V RHD 1
16 90031379 MOTOR PLATE RHD 1
17 90031380 BLOWER WHEEL (CW) RHD 1
18 90031237 VENT TUBE RHD 1
11/16/2006 HCX90032011
90032013
HEATER AND EVAPORATOR ASSEMBLY - 12/24 VOLT - RHD

1 90032071 EVAPORATOR COIL 1
2 90032072 HEATER COIL 1
3 90031207 VALVE BRACKET 1
4 90032073 CASING 1
5 90032074 COVER 1
6 90032075 FRONT COVER 1
7 90032076 DUCTING/COVER 1
8 90032077 FILTER DOOR 1
9 90032078 FLAPPER, DOOR 1
10 90032079 COIL COVER 1
11 90031213 THERMOSTAT 1
12 90031215 CABLE CLAMP 1
13 90031216 BLOCK VALVE 1
14 90032080 AIR FILTER 1
15 90031218 GROMMET, HEATER/AIR COND SMALL 1
16 90031219 GROMMET, HEATER/AIR LARGE 2
17 90032081 INSULATION 1/4 IN. 1
18 90031220 PLVC FOAM 1/2 IN. 1
19 90031221 3/16 IN. SNAP BUSHING 2
20 90031223 RECEPLTACLE 1
21 90031224 RETIANER 1
22 90032082 STUD, BAIL STYLE RA 1
4/20/2006 HSX90032013
HCX90032108
HEATER CONTROL PACKAGE

1 90032091 HEATER CONTROL ASSEMBLY 1
(1) 90032092 CONTROLLER BRACKET 1
(2) 90032093 CABLE MOUNTING BRACKET 1
(3) 90032094 CONTROL ARM 3
(4) 90032095 CABLE CLAMP 3
(5) 90032096 CABLE 35 IN. 1
(6) 90032097 CABLE 57 IN. 1
(7) 90032096 CABLE 35 IN. 1
(8) 90032099 CLEVIS PIN 1/4 X 1/2 3
(9) 90032100 SCREW, PHILLIPS 3
(10) 90032101 COTTER PIN 3
(11) 90032102 RETAINING WASHER 3
(12) 90032103 SCREW, M4 X 8 SELF TAP (PLATED) 2
(13) 90032204 FLATWASHER 1/4 (SS) 3
(14) 90032104 WASHER M6 SS 9
ITEMS SHIPPED LOOSE
2 90032107 LEVER KNOBS W/ ATTACHMENT HARDWARE 3

3 90021127 4 POSITION SWITCH W/ NUT (FAN SPEED CONTROL) 1
90021126 SWITCH NUT 1
4 90031675 SWITCH KNOB 1
5 90021676 PUSH NUT 3/16 3
REV. 12/3/2007 HCX90032108

HN 1004
HORN
24V ELECTRIC

1 90804035 CAPSCREW 5/16-18 X 1 1
2 90019769 STARWASHER EXTERNAL 5/16 1
3 90010420 LOCKNUT ESNA 1/4-20 NC 1
4 90030620 HORN, ELECTRIC 24V 1
5 53572368 WIRE ASSY 1
6 90027274 MALE TAB 1/4" TO #8 SCREW 1
6/28/2007 HN1004
MR1070
LOW VIBRATION MIRROR GROUP

1 53576538 MIRROR, ASSEMBLY CAB SIDE STD MIRROR LOW VIB 1 MRX53576538
2 53576539 MIRROR, ASSEMBLY POST SIDE STD MIRROR LOW VIB 1 MRX53576539
3 90804035 CAPSCREW 5/16-18 X 1 2
4 90015767 FLATWASHER 5/16 SS 4
5 90021440 WASHER, 5/16 NYLON 2
6 95210420 LOCKNUT ESNA 5/16-18 NC 2
7 53576270 COVER, MIRROR POST 2
8 90027537 CAPSCREW, SELF TAP 1/4-20 X 1" 4
9 90804016 CAPSCREW 1/4-20 X 3/4 4
10 98415020 LOCKWASHER 1/4 4
6/25/2008 MR1070
53576538
LOW VIBRATION CAB SIDE MIRROR ASSEMBLY

1 90019010 MIRROR, HEAD, 7 X 16 BLACK 1
2 53576878 BAR, MIRROR MOUNT CONVEX EXTENSION 2
3 90804035 CAPSCREW 5/16-18 X 1 4
4 90015767 FLATWASHER 5/16 SS 12
5 90021440 WASHER, 5/16 NYLON 4
6 95210420 LOCKNUT ESNA 5/16-18 NC 6
7 53576199 MIRROR, LOOP DRIVER SIDE 1
8 90021354 BRACKET, CABFOOT MIRROR LH 2
3/20/2009 MRX53576538
53576539
LOW VIBRATION POST SIDE MIRROR ASSEMBLY

1 90019010 MIRROR, HEAD, 7 X 16 BLACK 1
2 53576196 BAR, MIRROR MOUNT 2
3 90015767 FLATWASHER 5/16 SS 4
4 95210420 LOCKNUT ESNA 5/16-18 NC 2
6/25/2008 MRX53576539
PF1546
PLATFORM INSTALLATION
SIDE (2STEP) - RHD

1 53550186 PLATFORM WELDMENT - SIDE RHD 1
2 53548572 ANGLE WELDMENT, SIDE STEP SUPPORT 1
3 90804485 CAPSCREW 3/8-16 X 1 1/4 8
4 90017717 NUT CROWNLOCK 3/8-16 UNC GD B 10
6 90804495 CAPSCREW 3/8-16 X 1 1/2 2
7 98415042 LOCKWASHER 3/8 8
9/9/2003 PF1546
PLATFORM INSTALLATION - FRAME
PF1557
PF1557
PLATFORM INSTALLATION. - FRAME

1 53570077 PLATFORM WELD, FRAME 23.88 FLUSH MOUNTED 2
2 53572079 PLATFORM WELD, FRAME 13.88 FLUSH MOUNTED 1
NOT SHOWN
90028722 CAPSCREW 3/8-16 X 1.25 GRADE 8 (TORX) BUTTON HD. 12
90005165 FLATWASHER 3/8 HARD ZINC SAE 12
6/28/2004 PF1557
PF1602
PLATFORM INSTALLATION - REAR CAB

1 53569402 PLATFORM WELDMENT UPPER RHS OPEN GRIP 1
2 NOT USED ---
3 53555228 PLATFORM WELD RR 2STEP 1
4 53549765 LADDER WELD 2 STEP RHD 1
5 90804485 CAPSCREW 3/8-16 X 1-1/4 8
7 90804495 CAPSCREW 3/8-16 X 1-1/2 5
8 90005165 FLATWASHER 3/8 HARD ZINC 28
9 53569407 RUNG, RRH PLATFORM EXTENSION 1
1/26/2007 PF1602
RA1186
REAR AXLE ASSEMBLY - SRDP 12.28 ASA

1 90030943 AXLE SRDP 12.28:1 1 RA1186B-I
2 90023486 BRAKE CHAMBER - 3030 2
3 90032112 SLACK ADJUSTER AUTO 7" LONG 2
-- 90032113 BRACKET KIT , 7" SLACK ADJUSTER 2
12/9/2005 RA1186A
RA1186 - 90030943
REAR AXLE

1 90031308 DIFF. CARRIER ASSY (12.28 W/O DIFF LOCK) 1
2 90023643 SCREW 16
3 90031309 AXLE HOUSING 1
4 90029293 OIL PLUG 1
90023682 SEAL RING FOR PLUG 1
5 90023630 RIVET 4
6 NOT SERV. NAME PLATE 1
9 90023629 BREATHER COVER 1
10 90023628 BREATHER PIPE 1
11 90023659 SPLIT PIN 1
12/9/2005 RA1186B
RA116 - 90030943
REAR AXLE - WHEEL HUB

1 90031310 WHEEL HUB 2
2 90025614 T. ROLLER BEARING 2
4 90031311 SPACER RING 2
5 90031015 SHAFT SEAL 2
6 90031038 PLANETARY GEAR COVER 2
7 90026108 O-RING 2
8 90026110 ALLEN SCREW 16
9 90023682 SEAL RING 4
10 90024172 PLUG 2
11 90029293 OIL PLUG 2
12/9/2005 RA1186C
RA116 - 90030943
REAR AXLE - WHEEL BOLTS

1 90027058 WHEEL NUT M22X1.5 20
2 90023575 WHEEL BOLT 93MM LONG 20
90031037 WHEEL BOLT 103MM LONG 20
12/9/2005 RA1186D
RA1186 - 90030943
REAR AXLE - HUB REDUCTION

1 90023578 PLANETARY GEAR 2
2 90023554 RING GEAR 2
3 90028242 RING GEAR HUB 2
5 90028243 LOCK WASHER 2
6 90028244 LOCK NUT 2
7 90028245 SCREW M8X12 2
8 90028246 SCREW M8X18 2
9 90023551 SUN GEAR 2
11 90023699 RETAINER RING 2
14 90029299 SHIM 0.2mm AR
15 90031313 SHIM 0.3mm AR
16 90029300 SHIM 0.5mm AR
17 90031314 SHIM 1.0mm AR
12/9/2005 RA1186E
RA1186 - 90030943
REAR AXLE - PLANETARY GEAR

1 90026107 SCREW 5
2 90023685 LOCK BALL 4
3 90026106 LOCK WASHER 1
4 90023502 NEEDLE ROLLER 240
5 90023580 PLANET CARRIER 1
6 90023552 PLANET GEAR 4
7 90023553 PLANET GEAR SHAFT 4
8 90023519 SPACER PLATE 8
10 90023581 THRUST WASHER 1
12/9/2005 RA1186F
RA1186 - 90030943
REAR AXLE - AXLE SHAFTS

1 90031315 AXLE SHAFT - RH, L=1090 1
90031316 AXLE SHAFT - LH, L=1140 1
12/9/2005 RA1186G
RA1186 - 90030943
REAR AXLE - DIFFERENTIAL CARRIER ASSEMBLY

1 90023662 SPLIT PIN 1
2 90023651 NUT 1
3 90023665 WASHER 1
4 90031039 INPUT FLANGE 1
5 90023528 SHIELD 1
6 90031317 SHAFT SEAL 1
7 90023507 BEARING, INNER RACE 1
8 90023512 BEARING, OUTER RACE 1
9 90023630 RIVET 4
10 NOT SERV. NAME PLATE 1
11 90023672 OIL PLUG 1
12 90023682 SEAL RING 1
13 90023584 DIFF. CARRIER ASSY (NO DIFF. LOCK) 1
14 90023542 SPACER RING (L= 53.70mm) AR
15 90023539 SHIM (0.30mm) AR
15 90023540 SHIM (0.40mm) AR
15 90023541 SHIM (0.50mm) AR
16 90023667 SHIM (0.1mm) AR
16 90023668 SHIM (0.2mm) AR
16 90023669 SHIM (0.5mm) AR
16 90023670 SHIM (1.0mm) AR
18 90023517 ADJUSTING NUT 2
19 90023513 BEARING, OUTER RACE 2
20 90023508 BEARING, INNER RACE 2
21 90023654 NUT 12
22 90031319 DIFF. CASE ASSY (NO DIFF. LOCK) 1
23 90031320 HEX SCREW 12
25 90031322 SIDE GEAR 1
26 90031323 SPIDER 1
27 90031324 PINION GEAR 4
29 90031326 SIDE GEAR 1
31 90031328 RING AND PINION GEAR SET (12.28:1) 1
32 90026495 PIN 4
33 NOT SERV. PART OF ITEM 13 -
34 90023588 LOCK PLATE 2
35 90023638 SCREW 4
36 90023636 SCREW 4
37-53 NOT USED USED ON AXLES WITH DIFF LOCK -
12/9/2005 RA1186H
RA11863 - 90030943
REAR AXLE BRAKES

2 90023663 WASHER 2
3 90023700 SUPPORT RING 2
4 90025763 SHAFT SEAL 6
5 90026501 BRACKET - RH 1
5 90024159 BRACKET - LH 1
6 90029304 BEARING BUSH 4
7 90023679 SHAFT SEAL 2
9 90023687 GREASE NIPPLE 2
10 90023689 SHIELD HAT 2
11 90026116 SCREW 4
12 90023599 DUST SHIELD 2
13 90023532 SHIELD PLUG 4
14 90023637 SCREW 14
15 90023634 SCREW 4
16 90023632 SCREW 24
17 90023653 NUT 28
19 90023689 SHIELD HAT 2
20 90023598 BRAKE BRACKET 2
21 90023689 SHIELD HAT 4
23 90026502 ANCHOR BOLT 4
24 90023676 O-RING 8
25 90029305 BEARING BUSH 8
26 90023692 RIVET 96
29 90023612 BRAKE SHOE 4
30 90023610 ANCHOR SUPPORT 2
31 90023640 SCREW 4
32 90023602 S-CAM SHAFT (RIGHT) 1
32 90023603 S-CAM SHAFT (LEFT) 1
33 90026507 PIN 4
35 90023657 SPRING COTTER 4
36 90025780 PROLLER 4
37 90026509 BUSH 6
39 90023702 RETURN SPRING 4
40 90023664 WASHER 6
41 90023641 SCREW 6
42 90031329 BRAKE DRUM 2
43 REFERENCE LOCTITE -
46 90031013 BRAKE SHOE ASSEMBLY 4
47 90031330 BRAKE LINING SET (FOR ONE WHEEL) -
12/9/2005 RA1186 I
RS1033
REAR SUSPENSION - SOLID MOUNT

1 53526784 PAD, REAR AXLE U-280 1
2 53526784 PAD, REAR AXLE U-280 1
3 53502218 CLAMP PLATE WELDMENT, AXLE 1
4 53502218 CLAMP PLATE WELDMENT, AXLE 1
6 90005161 WASHER, FLAT 1" HARDENED 24
7 90014216 CAPSCREW 1-8 X 12 (GRADE 8) 8
8 53504884 TORQUE LINK 1.02 DIA X 7.00 CTR 4
9 90804433 CAPSCREW 1-8 X 3 1/2 4
7/23/2007 RS1033
SL1002
AMBER STROBE LIGHT

1 90028347 LIGHT, AMBER STROBE 1
SERVICE PARTS
90028834 LENSE, STROBE LIGHT -
90028835 FLASH TUBE -
12/26/2002 SL1002
SPEEDOMETER - 24 VOLT
S I
SP1025
SP1025
SPEEDOMETER - 24 VOLT

1 90029116 SPEEDOMETER HDI NO 2 (24 VOLT KPH) 1
1/30/2004 SP1025
BACK-UP ALARM INSTALLATION (MD TRANSMISSION)
SS1570
SS1570
BACK-UP ALARM INSTALLATION (MD TRANSMISSION)

1 90005361 CAPSCREW M10-1.5 X 20MM 2
2 90007549 LOCKWASHER M10 2
3 53563562 BACK-UP ALARM 1
4 90804016 CAPSCREW 1/4-20 X 3/4 2
5 90013919 LOCKNUT ESNA 1/4-20 2
6 98421150 FLATWASHER 1/4 2
7 53563758 BRACKET, BACK-UP ALARM MOUNTING 1
ITEMS NOT SHOWN

10/9/2008 SS1570
SS1789
DECALS - SAFETY SYSTEM

1 53571724 LOGO PLATE, MODEL DESIGNATION 1
2 53574744 DECAL, MODEL DESIGNATION "OTTAWA" 1
3 53571789 DECAL, WARNING - FALL HAZARD 2
4 53571726 DECAL, KALMAR CAB - RED 1
5 90025945 DECAL, USE DEXRON III ONLY 1
6 90027214 DECAL, CAUTION BATTERY COMPARTMENT 1
7 90008555 DECAL, USE DIESEL FUEL 1
8 90005374 DECAL, "DO NOT STEP" 2
9 90029702 DECAL, OPERATING INSTRUCTIONS 1
10 53571090 DECAL, OFF-HIGHWAY KALMAR 1
11 90029336 DECAL, CAUTION KEEP CLEAR OF CAB 4
12 NOT USED -- --
13 53545038 DECAL, CAUTION JAWLOCK 1
14 90018676 DECAL, EMERGENCY EXIT (KICK OUT WINDSHIELD) 1
NOT SHOWN
-- 90014274 DECAL, WARNING ROTATING SHAFT 1
INSTALLATIONS - SEE SEPARATE PAGE

-- 53546434 DECAL INSTALLATION, CAB TILT CAUTION 1 SSX53546434
-- 53549725 DECAL INSTALLATION, NO RIDERS 1 SSX53549725
12/29/2009 SS1789
53546434
DECAL INSTALLATION
CAB TILT CAUTION

1 90022258 DECAL, "CAUTION" CAB TILT 1
2 90022259 DECAL, CAB TILT "UP - DOWN" 1
12/26/2002 SSX53546434
53549725
DECAL INSTALLATION
NO RIDERS

1 90023039 DECAL, NO RIDERS 1
12/26/2002 SSX53549725
53567648
DECAL INSTALLATION
SAFETY WALK - RH DECK / 2001

1 99600282 TAPE, SAFETYWALK 4" WIDE 21 IN.
12/26/2002 SSX53567648
ST1510
STEERING GROUP
CHASSIS - RHD

1 90022655 STEERING GEAR 1 STX90022655
2 90023006 CAPSCREW 7/8-9 X 3 1/2 GRD 8 2
6 90024133 PITMAN ARM 11" DOUBLE BEND 1
7 90009575 CAPSCREW 3/4-16 X 4 GRADE 8 1
9 90021195 DRAGLINK ASSEMBLY - RHD 1 STX90021195
10 90831077 COTTERPIN 5/32 X 2 2
11 REFERENCE DRIVELINE ASSEMBLY - STEERING -
12 90007015 CAPSCREW 7/16-14 X 2 GRADE 8 1
14 92408065 ZERK, GREASE 1/4-28 90 DEG 1
15 90019912 CAPSCREW 7/8-9 X 5 GRADE 8 1
16 53556995 SPACER, STEERING GEAR MOUNTING 4
8/16/2003 ST1510
ST1511
STEERING GROUP
CAB

1 90025071 HORN BUTTON W/EMBLEM 1
2 99207100 NUT, STEERING WHEEL 1
3 90025685 STEERING WHEEL, PADDED 1
4 90008163 GASKET, STEERING COLUMN HORN 1
5 90008164 TERMINAL, STEERING COLUMN HORN 1
6 90024912 SCREW TAPTITE 8-32 X 5/16 PAN HD 2
7 90027783 STEER COLUMN, WITHOUT TURN SIGNAL 1
8 90030166 FITTING, GREASE 1/4-28 X 45 DEG 2
9 90030160 FITTING, GREASE 1/4-28 STRAIGHT 1
10 53570399 WELD PLATE, STEERING COLUMN OFFSET 1
11 90021880 STEERING COLUMN MOUNTING KIT 1
12 90021841 GROMMET, STEERING COLUMN BOOT 1
13 90021839 BOOT, STEERING COLUMN 1
14 90020330 STEERING JOINT ASSEMBLY 1
15 90007015 CAPSCREW 7/16 - 14 X 2 (GRADE 8) 1
16 90017718 NUT CROWNLOCK 7/16 - 14 UNC (GRADE B) 1
17 90012240 CAPSCREW 3/8 - 16 X 2 (GRADE 8) 1
18 90017717 NUT CROWNLOCK 3/8 - 16 UNC (GRADE B) 1
19 90804051 CAPSCREW 1/4 - 20 X 3-1/2 2
20 NOT USED ---
21 90804018 CAPSCREW 1/4-20 X 1 2
22 90803038 CAPSCREW 1/4-20 x 3 2
23 90026094 STEERING JOINT SUB-ASSEMBLY 1
24 90026095 STEERING JOINT SUB-ASSEMBLY 1
25 90026096 END YOKE 1
26 90026097 JOURNAL BEARING KIT 2
27 90026098 YOKE & SLEEVE 1
28 90026099 YOKE & SHAFT 1
29 90026100 END YOKE 1
6/28/2007 ST1511
90021195
DRAGLINK ASSEMBLY

1 90008212 ROD END, RH THREAD 1
2 90008213 ROD END, LH THREAD 1
3 90021194 TUBE, FORMED DRAGLINK 1
4 90011579 CLAMP ASSEMBLY 2
5 90009767 COVER, ROD END DUST 2
8/16/2003 STX90021195
90022655
STEERING GEAR

1 90009228 BOLTS, VALVE HOUSING 4
2 90017189 DIRT & WATER SEAL (INPUT) 1
3&4 ------ IN KIT -
6 90009227 SEAL RING (VALVE HOUSING) 1
7 90017993 SEAL RING (VALVE HOUSING) 1
8 90024699 SEAL RING 2
9 90017994 O-RING 2
10 90017995 SEAL RING 1
11 90017996 O-RING (VALVE HOUSING) 1
12 90017979 THRUST WASHER (THICK) 1
13 90024700 INPUT SHAFT, VALVE, WORM ASSEMBLY 1
15 90017999 ROLLER THRUST BEARING 2
16 90018116 THRUST WASHER (THIN) 1
17 90018153 BEARING ADJUSTER 1
18 90018154 ADJUSTER LOCKNUT 1
19 90024701 RACK PISTON 1
20 90018155 SEAL RING (RACK PISTON) 1
21 90018156 TEFLON SEAL RING 1
22 90018157 POPPET ADJUSTER SEAT & SLEEVE ASSY 2
23 90018158 POPPET 2
24 90018159 POPPET SPRING 1
25 90018160 SPACER ROD 1
26 90018161 PUSH TUBE 1
27 90024702 BALL SERVICE KIT 1
28 90024703 BALL RETURN GUIDE RH 1
90018162 BALL RETURN GUIDE LH 1
29 90018163 SEAL (BALL RETURN GUIDE CAP) 1
30 90018164 BALL RETURN GUIDE CAP 1
31 90018165 TORX SCREWS (CAP) 2
36 90018167 RETAINING RING 1
37 90018168 ROLLER BEARING 1
38 90018169 DIRT SEAL 1
39 90018170 DIRT AND WATER SEAL (TRUNNION) 1
40 90018171 WASHER (SPACER) 1
41 90018173 SEAL (2-OUTPUT) 1
42 90012904 SECTOR SHAFT 1
43 90009238 ADJUSTING SCREW (SECTOR SHAFT) 1
44 90009239 RETAINER (ADJUSTING SCREW) 1
45 90009143 GASKET (SIDE COVER) 1
46 90024705 SIDE COVER ASSEMBLY 1
47 90009245 JAM NUT 1
48 90009244 SPECIAL BOLTS 6
49 90009247 VENT PLUG (SIDE COVER) 1
51 90018174 PLUG (AUTO BLEED) 1
52A 90024706 FIXED STOP SCREWS 1
54 90024707 AUXILIARY PORT PLUG 2
55 90024708 O-RING (2-AUX. PORT PLUG) 2
-- 90018178 MASTER SEAL KIT -
3/23/2005 STX90022655
SV1005
SUN VISOR GROUP

1 53576634 ANGLE BRACKET 1
2 90005168 FLATWASHER #10 HARDENED 4
3 90020773 SCREW, #10-24 X 3/4 SELF TAP 4
12/22/2008 SV1005
HITCH PIN, 1.50 INCH DIAMETER X 8.50 INCHES LONG - HEAT TREATED
TP1021
TP1021
HITCHPIN 1.5 INCH DIAMETER X 8.5 INCHES LONG
- HEAT TREATED W/ COTTER PIN

1 90016347 HITCHPIN WITH COTTER PIN - HEAT TREATED 1
3/11/2004 TP1021
TR1585
TRANSMISSION TAIL SUPPORT INSTALLATION - MD

1 90027447 COUPLING NUT 1/2-13 2
2 90027448 SPRING COMPRESSION 560 LB/IN 2
3 53560411 MOUNT TRANSMISSION MD3060 1
4 53560447 ANGLE TRANSMISSION MOUNT 2
5 90804249 CAPSCREW 1/2-13 X 1 1/4 2
6 98415050 LOCKWASHER 1/2 2
7 90804267 CAPSCREW 1/2-13 X 1 1/2 4
12/26/2002 TR1585
TR1597
DIPSTICK INSTALLATION - MD TRANSMISSION

1 53569175 DIPSTICK & TUBE ASSY, SHORT MD TRANS 1
2
3 53553110 BRACKET, STANDOFF 1
4 90804035 CAPSCREW 5/16-18 X 1 1
5 98421145 FLATWASHER 5/16 1
6 95210420 LOCKNUT ESNA 5/16-18 NC 1
7 53101500 CLAMP, RUBBER COATED 1" ID 2
8 90027092 SCREW TAPTITE 5/16-18 X 3/4 HEX WASHER HD 1
12/26/2002 TR1597
TR1762
TRANSMISSION INSTALLATION - SHIFTER PANEL

1 53574897 PANEL, WELDMENT 1
2 53570069 INSULATION, SHIFTER 1
1/22/2007 TR1762
TR1763
TRANSMISSION ADAPTATION KIT

1 90032519 ADAPTATION KIT TRANS "B" ENGINE 6-BOLT 1
ITEMS NOT SHOWN

--- 90027205 CAPSCREW, FLEX PLATE MD M10-1.5 X 30 MM 6
--- 90030810 CAPSCREW HEX HD. M10-1.5 X 35MM 12
--- 90019771 STARWASHER EXTERNAL 3/8 12
2/16/2007 TR1763
TR1828
TRANSMISSION INSTALLATION

1 90033001 TRANSMISSION, AUTOMATIC 1
2 90022390 BEARING STRAP, 1/2 ROUND YOKE 1710 SERIES 2
3 90022391 CAPSCREW 12PT FLANGE HD 1/2-20UNF X 1 (GRADE 8) 4
4 90011043 CAPSCREW 1/2-13 X 1-3/4 (GRADE 8) 2
7 90818006 CLAMP, RUBBER COATED 1 1/2 ID 1
9 53576267 HARNESS , DECK TO TRANSMISSION 1
5/16/2008 TR1828
TR1848
SHIFTER GROUP

1 90017743 SCREW, MN BUT HD 1/4-20 X 5/8 SS 5
2 90013919 LOCKNUT ESNA 1/4-20 NC 5
3 90033028 GEAR SELECTOR LEVER 4 SPEED 1
4 NOT USED ---
5 53576266 HARNESS, FLOOR TO DECK SHIFTER 1
ITEMS NOT SHOWN

53101500 CLAMP, RUBBER COATED 1 ID 1
90812042 CLAMP, RUBBER COATED 3/4 ID 3
98421145 FLATWASHER 5/16 1
90017716 NUT CROWNLOCK 5/16-18UNC (GRADE B) 1
90005165 FLATWASHER 3/8 HARD ZINC 4
90002993 CAPSCREW 3/8-16 X 1 1/4 (GRADE 8) 2
90017717 NUT CROWNLOCK 3/8-16UNC (GRADE B) 2
7/15/2008 TR1848
TR1852
TRANSMISSION COOLING COMPONENTS

1 90032354 ADAPTER, #16 X 3/4 NPTM O-RING 1
2 H50216169162000 HOSE, ASSY, H502 OAL 2000MM, 90 1
3 H50216164161550 HOSE, ASSY, H502 OAL 1550MM, 45 1
4 96052329 ADAPTER 45 #16S X #12 O-RING 2
5 NOT USED ---
7 53109268 CLAMP,RUBBER COATED 1-1/4 ID 6
8 90804485 CAPSCREW 3/8-16 X 1-1/4 3
10 90032355 ADAPTER, 45 #16 X 3/4 NPTM O-RING 1
11 90009768 CAPSCREW M12-1.75 X 30MM 1
12/11/2009 TR1852
TR1853
TRANSMISSION OIL TEMPERATURE GAUGE INSTALLATION

1 90018285 SENSOR, TEMP 100-280 1
2 90033118 ADAPTER,RUN TEE #12 M O-R X 1/2 F FO-R X #12 F O-R 1
3 90029099 GAUGE HDI OIL TEMPERATURE 140-320F 24V 1
4 REF. AIR GAUGE PANEL ASSEMBLY ---
5 53575439 WIRING HARNESS, MD TRANS TEMP GAUGE-DASH 1
6 53569733 WIRE ASSY, TRANSMISSION TEMP GAUGE - FIREWALL 1
7 53569734 WIRE ASSY, TRANSMISSION TEMP GAUGE - ENGINE/TRANS1
8 53575438 WIRING HARNESS, MD TRANS TEMP GAUGE-GAUGE 1
ITEMS NOT SHOWN

--- 90033119 ADAPTER, #12 M O-RING X 1/2 F NPT 1
6/12/2008 TR1853
TR1887
TRANSMISSION E.C.U. INSTALLATION - 3000RDS
ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGES

1 90033444 ECU, TRANSMISSION 3000 RDS 1
2 53577277 WIRING HARNESS, E6 GEN-4 1
3 90029890 SCREW #8 X 1/2 HEX WASH SELF TAP ZINC PLATED 4
4 53568940 ECU COVER REAR WALL 1
5 53572956 COVER, TRANSMISSION ELEC BULKHEADS 1
7 90804035 CAPSCREW 5/16-18 X 1 2
8 98415035 LOCKWASHER 5/16 2
9 53568563 BRACKET, TRANSMISSION ABS ECU MOUNTING 1
10 90804018 CAPSCREW 1/4-20 X 1 7
11 90013919 LOCKNUT ESNA 1/4-20 NC 3
12 98415020 LOCKWASHER 1/4 4
14 90020773 SCREW #10-24 X 3/4 SELF TAP BLACK 4
ITEMS NOT SHOWN - USED TO ATTACH WIRING HARNESSES

-- 90016921 CLAMP, RUBBER COATED 9/16 ID 3
-- 90013919 LOCKNUT ESNA 1/4-20 NC 3
TRANSMISSION SCHEMATIC
-- SK8343 ELECTRIC DIAGRAM, E6 GEN-4 3000 TRANS 1 SK8343A-D
1/14/2010 TR1887
WP1069
WIPER GROUP - 24 VOLT

1 90033100 MOTOR, WINDSHIELD WIPER, 24V 1 WPX90033100
2 NOT USED ---
3 90025689 WIPER BLADE 28" 1
4 NOT USED ---
5 90025940 WIPER ARM 22" 1
6 NOT USED ---
7 53568711 HARNESS, CP WIPER SWITCH 1
8 90012853 SWITCH,ROTARY WIPER 3 POS 1
9 NOT USED ---
10 NOT USED ---
11 NOT USED ---
12 53545184 SPACER ELECTRIC WIPER MOTOR 1
13 90013204 FLATWASHER 1/4 SS 3
14 90021624 SCREW 1/4-28X1-1/4SS FILLHD SS 3
ITEMS NOT SHOWN

--- 90028731 PLUG, NYLON 3/4 DIA HOLE 1
9/23/2009 WP1069
90033100
WINDSHIELD WIPER MOTOR
24 VOLT (LHD)

1 90034905 24 VOLT WIPER MOTOR 1
2 90034885 CRANK ASSEMBLY 1
3 90034886 M8X1.25 FLANGED HEX NUT 1
4 90034063 BRACKET 1
5 90034888 M6 BUTTON HD. SCREW 3
6 90034889 LINK, 86 MM 1
7 90034890 PIVOT ASSEMBLY 1
8 90034891 DOME NUT 3/8-24 1
9 90034892 TOOTHED LOCK WASHER 3/8 IN. 1
10 90034893 KNURLED DRIVER 1
11 90034894 CAP 1
12 90034895 HEX NUT 11/16-24 1
13 90034896 FLAT WASHER 1
14 90034897 RUBBER WASHER 1
15 90034898 SCREW #10-32 UNF 2
16 90034899 SPRING CLIP 2
17 90034900 FLAT WASHER 2
4/23/2010 WPX90033100
WT1415
WHEELS AND TIRES

1 90030187 TIRE 280/75R22.5 2
2 90032429 WHEEL 22.5 X 8.25 X 6.5 335MM 2
3 90019517 NUT FLANGE 2 PIECE 20
4 90029315 VALVE STEM 27 DEG 2
90025743 VALVE STEM EXTENSION METAL 1" 2
5 90030187 TIRE 280/75R22.5 4
6 90032429 WHEEL 22.5 X 8.25 X 6.5 335MM 4
7 90019517 NUT FLANGE 2 PIECE 20
8 90029315 VALVE STEM 27 DEG 4
90014985 VALVE STEM EXTENSION 6" 2
7/23/2007 WT1415
SK8080 - BATTERY BOX CABLE ROUTING
SK8080

Part Manual S02001059 10xTT Pelindo IV, Makassar

Uploaded by

Copyright:

Available Formats

Part Manual S02001059 10xTT Pelindo IV, Makassar

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Part Manual S02001059 10xTT Pelindo IV, Makassar

Uploaded by

Copyright:

Available Formats

DEALER: Cargotec Asia Limited

TABLE OF CONTENTS SHIPPED:

Item # S02001059 OT4X2,RHD 24V OFF-HWY QSB6.7-1

Part Number ID Part Description ID Page Number ID

AI1178 AIR INTAKE GROUP

CG1050 CAB GLASS GROUP

EG1472 ENGINE GROUP

FW1290 FIFTH WHEEL GROUP

SL1002 STROBE LIGHT GROUP

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEMS NOT SHOWN

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEMS NOT SHOWN

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

- 90024231 GROMMET, 7/16 ID X 3/32 G X 5/8 GD 1

- 90803051 CAPSCREW 5/16-18 X 5/8 3

ADDED 12/12/08 (NOT SHOWN)

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEMS NOT SHOWN

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEMS NOT SHOWN

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

2 90017053 WINDOW, LH FIXED TINTED 1

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

3 90026524 FELT, CHANNEL 1

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE

ITEM NO. PART NO. DESCRIPTION QTY. ALSO SEE PAGE