Diesel Generator Set: T 343PL Rev C

Diesel Generator Set
19
20
24
25
SERVICE PARTS LIST

for
69UG15
Generator Set Units:
PID UG1400 Series
PID UG1500 Series
PID UG1600 Series
PID UG1700 Series
PID UG1800 Series
PID UG1900 Series
T−343PL Rev C
SERVICE PARTS LIST
DIESEL DRIVEN GENERATOR SET
MODEL
69UG15
TABLE OF CONTENTS
PARAGRAPH NUMBER Page

INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i
MODEL AND PRODUCT IDENTIFICATION (PID) NUMBERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i
ORDERING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i
GENERAL NOTES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i
PAINTED PARTS COLOR SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ii
MODEL CHART . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iii
1 UG GENSET CONFIGURATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
2 UNIDRIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
3 FUEL SYSTEM ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
4 AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
5 FUEL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
6 EXHAUST SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
7 BATTERY CHARGER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
8 COOLANT SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
9 CONTROL BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
10 VOLTAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
11 LABELS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
12 RECEPTACLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
13 PANELS AND DOORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
14 FRAME ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
15 BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
16 WIRE HARNESS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
17 RETROFIT KITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
PART NUMBER INDEX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Index−1
i T−343PL Rev C
INTRODUCTION
This parts list identifies service replacement parts for the Carrier Transicold Diesel-Driven Generator Set listed in the
model chart below. This parts list does not include detailed replacement parts for the engine listed in the first chart
below. Detailed parts identification for these items may be found in the applicable parts list. The form numbers for the
engine omit revision dash numbers. For example, the latest engine list may have an -01 added to the basic number to
read 62-03459-01. Therefore, when forms are ordered the latest revision will be sent.
MANUAL/ ENGINE EQUIPMENT TYPE OF

FORM NO. PART NUMBER COVERED MANUAL/FORM
62‐11362 * V2203‐DI Workshop
26‐00128‐22
62‐11335 * V2203‐DI Engine Parts List
* When referring to the engine manual, please note that this engine has been assembled using a two piece oil pan.
MODEL AND PRODUCT IDENTIFICATION (PID) NUMBERS

Beginning with early 1995 production, Carrier Transicold began using a parts identification (PID) number in the format
of UG0000 in addition to a model number. In this manual, the PID number is shown in boldface to point out variations
within models.
ORDERING INSTRUCTIONS
All orders and inquiries for parts must include:
SPart Identification Number (PID)
SUnit Serial Number
SPart Number
SDescription of Part
SQuantity Required
Address all correspondence for parts to the following address:
CARRIER TRANSICOLD DIVISION

Replacement Components Group
TR-20, P.O. Box 4805
Syracuse, New York 13221
or
Fax to: (315) 432-3778
GENERAL NOTES
To find replacement parts, consult table of contents, and turn to the appropriate page for the illustrated breakdown of
replacement parts. The following letter designations are used to classify parts throughout this list:
A/R As Required.
NLO No Longer Offered
PID Parts Identification Number − essential to identify unit configuration.
PL Purchase locally.
SST Stainless Steel − 300 Series unless otherwise specified.
SV Suffix SV − added to the part number designates service part replacement part.
i T-343PL Rev C
PAINTED PARTS COLOR SYSTEM
Available paint colors: (Other than Standard Carrier Transicold White or Hull Blue)
PAINT COLOR PART NO.

Sky Blue 36-00048-28
Flame Orange 36‐00048‐27
Citrus Orange 36-00048-29
Raven Black 36‐00048‐04
Red 36‐00048‐57
Overview of the new numbering system:

A typical part number appears as: 79−01741−00 (access door). To order an access door in sky blue, add the last three
digits of the special color paint and then add the specific dash number for the color of that paint.
For example:
Sky blue paint P/N is 36−00048−28.
The last three digits of the blue paint are: 048
The specific dash number is: 28
The painted parts system looks like this:
79-01741-00 Standard P/N for the access door.
048 Last 3 digits of special color paint.
28 Specific dash # for color of paint.
79-01741-0004828 P/N For Special Painted Door
Data Entry Note:
The above is an example of how most parts should be ordered. Certain customers may have character constraints that
will only allow them to input 14 characters into their system; our new painted part numbers are 16 characters long.
Therefore, they should order these parts without the dashes. The entries will look like the following: 79017410004828.
T-343PL Rev C ii
MODEL CHART
NOTE
The numbers shown in the model chart below refer to the section numbers that cover that option.
Please refer to the table of contents for page numbers.
Frame Assembly
Exhaust System
Battery Charger
Coolant System
Panels & Doors

Wiring Diagram
Schematic and
Model Number
Receptacles
Placard Part
PID Number
Control Box
Fuel System
Fuel Tank
Numbers
Unidrive
Harness
Air Filter
Voltage
1400 Series Standard
2.a 13.c
UG1450 62-11411-00 2.b 3 4.b 5.a 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.d
UG1451 62-11411-00 2.b 3 4.b 5.a 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
iii
69UG15-050S-05
2.a 13.c
UG1452 62-11411-00 2.b 3 4.a 5.a 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.c
UG1453 62-11411-00 2.b 3 4.b 5.d 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.c
UG1455 62-11411-00 2.b 3 4.b 5.b 6.a 7 8.a 9.a 10.a 13.f 14.a 16
2.c 12.d
69UG15-050S-06
2.a 13.d
UG1456 62-11411-00 2.b 3 4.b 5.b 6.a 7 8.a 9.a 10.a 12.d 13.f 14.a 16
2.c
T-343PL Rev C
T-343PL Rev C
Frame Assembly
Exhaust System
Battery Charger
Coolant System
Panels & Doors

Wiring Diagram
Schematic and
Model Number
Receptacles
Placard Part
PID Number
Control Box
Fuel System
Fuel Tank
Numbers
Unidrive
Harness
Air Filter
Voltage
2.a 13.e
69UG15-050S-07 UG1457 62-11413-00 2.b 3 4.b 5.a 6.a 7 8.c 9.b 10.b 12.m 13.f 14.a 16
2.c
2.a
69UG15-050S-08 UG1458 62-11414-00 2.b 3 4.a 5.d 6.a 7 8.d 9.d 10.c 12.e 13.h 14.a 16
2.c
2.a 13.c
UG1459 62-11411-00 2.b 3 4.b 5.b 6.a 7 8.a 9.a 10.a 12.d 13.f 14.c 16
2.c
69UG15-050Q-06
2.a 13.d
iv
UG1460 62-11411-00 2.b 3 4.b 5.b 6.a 7 8.a 9.a 10.a 12.d 13.f 14.c 16
2.c
2.a 13.c
UG1461 62-11411-00 2.b 3 4.b 5.e 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.d
69UG15-068S-05 UG1462 62-11411-00 2.b 3 4.b 5.e 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.c
UG1463 62-11411-00 2.b 3 4.a 5.e 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.c
69UG15-068Q-05 UG1464 62-11411-00 2.b 3 4.b 5.e 6.a 7 8.a 9.a 10.a 12.c 13.f 14.c 16
2.c
Frame Assembly
Exhaust System
Battery Charger
Coolant System
Panels & Doors

Wiring Diagram
Schematic and
Model Number
Receptacles
Placard Part
PID Number
Control Box
Fuel System
Fuel Tank
Numbers
Unidrive
Harness
Air Filter
Voltage
2.a 13.c
UG1465 62-11411-00 2.b 3 4.b 5.h 6.a 7 8.a 9.a 10.a 12.c 13.f 14.a 16
2.c
2.a 13.c
69UG15-080Q-05 UG1466 62-11411-00 2.b 3 4.b 5.h 6.a 7 8.a 9.a 10.a 12.c 13.f 14.c 16
2.c
2.a 13.b
UG1467 79-01919-04 2.b 3 4.c 5.f 6.b 7 8.b 9.a 10.a 12.c 13.f 14.c 16
2.c
2.a 8.a 13.d
69UG15-068S-06 UG1468 62-11466-00 2.b 3 4.b 5.e 6.a 7 8.b 9.b 10.b 12.f 13.f 14.a 16
2.c
1500 Series Dual Speed
v
2.a 13.h
69UG15-050S-08 UG1558 62-11441-00 2.b 3.a 4.a 5.c 6.a 7 8.e 9.e 10.b 12.g 13.f 14.a 16
2.c
2.a 13.b
69UG15-068Q-05 UG1564 62-11438-00 2.b 3.a 4.b 5.e 6.a 7 8.b 9.c 10.a 12.h 13.f 14.c 16
2.c
2.a 13.b
69UG15-080S-05 UG1565 62-11438-00 2.b 3.a 4.b 5.f 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
2.c
2.a 13.d
69UG15-050S-05 UG1572 62-11438-00 2.b 3.a 4.b 5.a 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
2.c
2.a 13.b
UG1573 62-11438-00 2.b 3.a 4.b 5.a 6.a 7 8.b 9.c 10.a 12.h 14.a 16
T-343PL Rev C
13.f
2.c
69UG15-068S-05
2.a 13.b
UG1578 62-11438-00 2.b 3.a 4.b 5.a 6.a 7 8.b 9.c 10.a 12.j 13.f 14.a 16
2.c
2.a 13.d
69UG15-050Q-06 UG1575 62-11438-00 2.b 3.a 4.b 5.a 6.a 7 8.b 9.c 10.a 12.i 13.f 14.c 16
2.c
T-343PL Rev C
Frame Assembly
Exhaust System
Coolant System
Battery Charger
Wiring Diagram
Panels & Doors

Model Number
Schematic and
PID Number
Placard Part
Receptacles
Control Box
Fuel System
Fuel Tank
Numbers
Unidrive
Harness
Air Filter
Voltage
1600 Series Dual Speed Provision
2.a 13.b
69UG15-050S-05 UG1653 62-11438-00 2.b 3 4.a 5.c 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
2.c
2.a 8.a 13.d
69UG15-050S-07 UG1657 62-11440-00 2.b 3 4.b 5.a 6.a 7 8.b 9.c 10.b 12.h 13.f 14.a 16
2.c
2.a 13.h
69UG15-050S-08 UG1658 62-11441-00 2.b 3 4.a 5.c 6.a 7 8.e 9.e 10.c 12.g 13.f 14.a 16
2.c
vi
2.a 13.c
69UG15-068Q-05 UG1664 62-11438-00 2.b 3 4.b 5.e 6.a 7 8.b 9.c 10.a 12.f 13.f 14.c 16
2.c
2.a 13.b
69UG15-080S-05 UG1665 62-11438-00 2.b 3 4.b 5.h 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
2.c
2.a 13.d
69UG15-050S-05 UG1669 62-11438-00 2.b 3 4.b 5.c 6.a 7 8.b 9.c 10.a 12.f 13.f 14.a 16
2.c
UG1672 2.a 13.d
69UG15-050S-05 S’sedes 62-11438-00 2.b 3 4.b 5.a 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
1670 2.c
UG1673 2.a 13.b
69UG15-068S-05 S’sedes 62-11438-00 2.b 3 4.b 5.e 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
1671 2.c
UG1674 2.a 13.b
69UG15-050S-05 S’sedes 62-11438-00 2.b 3 4.b 5.a 6.a 7 8.b 9.c 10.a 12.h 13.f 14.a 16
1650 2.c
1 T-343PL Rev C
1 UG GENSET CONFIGURATION
4
5
1
7 8
3 2
12
11 10 9
14 5 1 13
15 − WIRE HARNESS
NOT SHOWN
T-343PL Rev C 2
1 UG GENSET CONFIGURATION (Continued)
Item Section Number Area Description
1 Refer to Section 2 Unidrive
2 Refer to Section 3 Fuel System Assembly
3 Refer to Section 4 Air Filter
4 Refer to Section 5 Fuel Tank
5 Refer to Section 6 Exhaust System
6 Refer to Section 7 Battery Charger
7 Refer to Section 8 Coolant System
8 Refer to Section 9 Control Box
9 Refer to Section 10 Voltage
10 Refer to Section 11 Labels
11 Refer to Section 12 Receptacles
12 Refer to Section 13 Panels and Doors
13 Refer to Section 14 Frame Assembly
14 Refer to Section 15 Battery
15 Refer to Section 16 Wire Harness
3 T-343PL Rev C
2 UNIDRIVE
2.a UNIDRIVE ASSEMBLY
31 32
1 2 3
30
29
4
28
27
26
25
24
23
6
7
22 19
21
20 18 33
17 34
16
15 8
9
11 10
13 35
11
14 12
36
FLYWHEEL
HOUSING
28 37
GENERATOR
38
42 GENERATOR
43 DISC DRIVE 39
40
41
T-343PL Rev C 4
2.a UNIDRIVE ASSEMBLY (Continued)
Item Part Number Description Qty
1 26−00128−04 Engine, 1800 rpm 1
2 10−00158−02 Switch, Safety 1/2 Inch NPT Water Temperature 1
3 12−00098−04 Sending Unit Water Temperature 1
4 50−60330−03 V−Belt, Poly 1
5 34−00945−06 Washer, Lock 4
6 40−00566−00 Elbow, 90 Degree 1
7 CA61JA151 Plug 1/2 Inch MPT 1
8 68−11900−00 Panel, Side 1
9 66CH1−1172−50 Trim, Flexible 0.06 X 2.75 5
10 66CH1−1172−51 Trim, Flexible 0.06 X 1.25 2
11 34−00928−02 Rivet, Blind 12
12 68−12010−00 Baffle 2
13 66CH1−1172−94 Trim, Flexible 21.5 1
14 68−11899−00 Panel, Side 1
15 34−00833−28 Screw, Cap Hex Head 1/2−13 X 3.50 Long 2
16 34−06060−02 Washer, Snubbing 4
17 34−00667−13 Nut, Self Lock 3/8−16 4
18 34−00829−13 Washer, Plain 3/8 8
19 73−00175−01 Shockmount 2
20 34−00807−08 Screw, Cap Hex Head 3/8−16 X 1 4
21 34−00829−15 Washer, Plain 1/2 2
22 34−00667−15 Nut, Self Lock 1/2−13 2
23 34−00804−18 Screw, Cap Hex Head 5/8−18 X 2.25 4
24 66U1−5321−9 Washer, Plain 5/8 8
25 86−04524−01 Plate, Support 1
26 34−00795−17 Nut, Self Lock 5/8−18 4
27 54−00576−03 Generator 1
28 34−00807−12 Screw, Cap Hex Head 3/8−16 X 1.50 12
29 AU11JR241 Washer, Lock 3/8 12
30 68−11901−00 Strap 1
31 66U1−5361−25 Screw, Cap Hex Head 1/4−20 X 0.75 4
32 66U1−5321−3 Washer, Plain 1/4 4
33 40−00067−01 Nipple, Hex 1/8 X 1/8 NPT 1
34 66U1−2823−3 Sender, Oil Pressure 1
35 40−00107−01 Tee 1/8 NPT 1
36 12−00592−00 Switch, Pressure Oil 1
37 66U1−5361−36 Screw, Cap Hex Head 5/8−11 X 4 2
38 66U1−5331−8 Washer, Lock 5/8 2
39 73−00198−01 Shockmount 2
40 34−00890−10 Washer, Flat 2
41 34−06060−01 Washer, Snubbing 4
42 34−01151−08 Washer, Flat 10
43 34−01153−15 Screw, Cap Hex Head 6
5 T-343PL Rev C
2.b UNIDRIVE ASSEMBLY − ISOLATOR
1
2
3
7
6
8
5
9
4 10
UNIDRIVE
FRAME
1 86−04687−00 Truss 1
2 34−00667−13 Locknut, 3/8−16 2
3 68−14809−00 Nutplate 1
4 73−00205−00 Isolator 1
5 68−14812−00 Heat Shield 1
6 34−01146−08 Washer, Lock, M8 Spring 4
7 34−06280−20 Screw, Cap, M8 X 1.25 Socket Head 4
8 34−00807−10 Screw, HXHD 3/8−16 x 1.25 4
9 AU11JR241 Washer, Lock, 3/8 Spring 4
10 66U1−5321−17 Washer, Flat, 3/8 W Type A 4
T-343PL Rev C 6
2.c ALTERNATING CURRENT GENERATOR
4 5 6 7
8
9
2
3 10
1
5
11
2
3
16
MUST BE USED
ON RE−ASSEMBLY
17
18
19
13
15
20 12
21
14

54−00576−03 Generator, 15 KW − Includes: 1
1 22−50206−00 Rectifier Assembly − Includes: 1
2 34−00655−12 Bolt, HXHD, 1/4−20 x 1−1/2 Long− SST 12
3 AU11JR171 Washer, Lock, 1/4−20 − SST 10
4 34−00655−04 Bolt, HXHD, 1/4−20 x 1/2 Long− SST 2
5 54−50082−00 Air Baffle 1
6 42−00348−00 Gasket 1
7 34−00655−06 Bolt, HXHD, 1/4−20 x 3/4 Long− SST 4
8 66U1−5321−3 Washer, Flat 1/4 − SST 4
9 54−50085−00 Terminal Block 1
10 54−50039−00 End Cover 1
11 54−50083−00 Side Cover 1
12 76−50110−00 Bearing Kit − Includes: 1
13 04−50012−00 Bearing 1
14 42−50010−00 O−Ring 1
15 54−50084−00 Fan, One−Piece, Die Cast 1
16 02−00083−00 Anti−Corrosion Coating 1
17 48−00392−00 Hub 1
18 68−14698−01 Disc, Drive 2
19 68−14699−01 Disc, Pilot 2
20 34−00304−08 Bolt, HXHD Socket, 3/8−16 x 1 Long 6
21 34−06278−00 Washer 6
7 T-343PL Rev C
3 FUEL SYSTEM ASSEMBLY
7
15
11 13
14
12
10 3
1 16
7 2 17
8 3 18
9 4 19
5
3
6
7
7 29
27 30
7 28
20
7
21
26
22
14 14
17 17
18 18
25 23
24
ARROW INDICATES
FUEL FLOW DIRECTION
T-343PL Rev C 8
3.a FUEL SYSTEM ASSEMBLY − INTEGRAL TANK (Continued)
1 30−01101−07 Filter Assembly, with Heater − Includes: 1
2 66U1−5321−5 Washer, Plain 3/8 Type A 2
3 44−00045−25 Clamp, Hose 8
4 AU11JR241 Washer, Lock 3/8 Spring 2
5 66U1−5361−7 Screw, Cap Hex Head 3/8−16 X 1 2
6 58−00659−03 Hose, Fuel 3/16 ID X 10.25 Long 1
7 66U1−3882 Wire Tie 9
8 66CH1−163−26 Tube Assembly, 3/8 X 60 Inches Long 1
9 58−01206−12 Hose, Slit 0.62 ID X 30 Long 1
10 58−00065−76 Grommet 0.38 ID X 0.75 OD 1
11 58−00065−46 Grommet 0.25 ID X 0.75 OD X 0.12 1
12 66CH1−163−27 Tube Assembly, 1/4 X 51 Inches Long 1
13 42−01133−00 Seal 2
15 58−00848−02 Tube, Slit 1/2 ID X 9 Inches Long 2
16 44−00102−52 Clamp, Cushioned 0.56 Diameter 2
18 66U1−5321−7 Washer, Plain 1/4 W Type A 3
19 34−00667−11 Nut, Self Lock 1/4−20 1
20 58−00969−00 Wire Tie 1
21 58−04321−16 Tube, Slit 3/8 ID, 12.00 Inches Long 1
22 40−00345−04 Connector, Female 3/8 Tube X 1/4 NPT 1
23 34−00373−58 Clamp, Tube 1
24 30−00373−02 Filter 1/4 MPT, Clear 1
25 44−00102−54 Clamp, Cushioned 2
26 40−00671−00 Fitting 3/8 Tube X 1/4 NPT 1
27 66CH1−163−31 Tube Assembly 3/8 X 8.50 Long 1
28 58−04321−29 Tube, Slit 3/8 ID, 7.00 Inches Long 1
29 34−00928−10 Rivet, Blind 3
30 68−15602−00 Bracket 1
9 T-343PL Rev C
3.b FUEL SYSTEM ASSEMBLY − WITH WARMER
8 9
4 4
7 5 5 9
6 6 4
9 5
11 6 10
12 12
13
1
3 2
2
14
15
16
17

1 44−00045−25 Clamp, Hose Worm Type 10
2 58−00079−02 Strap, Cable 19
3 44−00317−00 Clip, 1/2 To 5/8 Tee 1
4 66U1−5361−25 Screw, Cap Hex Head, 1/4−20 x 0.75 Inch 7
5 66U1−5321−7 Washer, Plain, 1/4 Type A 7
6 AU11JR171 Washer, Lock, 1/4 Spring 8
7 30−00344−04 Fuel Warmer, Diesel 1
8 44−00459−00 Clamp, Tube, 1.69 Diameter Cushion 1
9 34−00373−60 Clamp, Tube, 0.81 Diameter Cushion 3
10 58−04838−00 Hose, Formed, Fuel Warmer 1
11 58−04837−00 Hose, Formed, Fuel Warmer 1
12 44−00045−02 Clamp, Hose Worm Type 4
13 58−00658−15 Hose, Fuel, 5/16 ID x 11 Inches Long 1
14 68−15848−00 Bracket, 69UG Fuel Warmer 1
15 34−01153−15 Screw, Cap Hex Head, 8mm x 15mm 2
16 34−01146−08 Washer, Lock, M8 Spring 2
17 34−01151−08 Washer, Flat, M8 2
T-343PL Rev C 10
4 AIR FILTER
4.a OIL BATH AIR FILTER
7
8
9
4
5
6
3 1
OIL BATH AIR FILTER (4.a)

1 30−00473−04 Air Cleaner, Oil Bath − Includes: 1
2 30−00473−20 Gasket, Oil Bath 1
3 44−00447−00 Bracket 1
4 66U1−5321−3 Washer, Plain 1/4 2
5 66U1−5371−8 Screw, Mach Hex Head 1/4−20 X 1 2
6 34−00667−11 Nut, Self Lock 1/4−20 2
7 30−00356−00 Hood Air Inlet 1
8 58−04780−01 Hose 1
9 KA69JM840 Clamp, Hose 2
11 T-343PL Rev C
4 AIR FILTER (Continued)
13
14
1 11 15
12
9
10
3
4
5
6 8
9
2 7
DRY ELEMENT AIR FILTERS (4.b AND 4.c) D.E. AIR FILTER WITH
PRE−CLEANER ONLY (4.c )
4.b DRY ELEMENT AIR FILTER
1 30−00426−05 Air Cleaner, Dry Element − Includes: 1
2 30−00426−25 Filter, Dry Element 1
3 66U1−5321−3 Washer, Plain 1/4 2
5 34−00667−11 Nut, Self Lock 1/4−20 2
6 44−00454−00 Bracket 1
7 30−00406−01 Indicator, Air Filter 1
8 66U1−9132 Washer, Plain 2
9 34−00928−10 Rivet, Blind 4
10 68−15491−00 Plate 1
11 40−00506−00 Fitting 1/8 NPT 1
12 58−04102−03 Hose 1
13 58−04780−00 Hose 1
14 KA69JM840 Clamp, Hose Worm 2
4.c DRY ELEMENT AIR FILTER WITH PRE−CLEANER (ALL OF 4.b AND ITEM BELOW)
15 30−00446−00 Pre−Cleaner, Air Filter 1
T-343PL Rev C 12
5 FUEL TANK
5.a, 5.b INTEGRAL 50 GALLON FUEL TANK AND MOUNTING ASSEMBLY
10
6
7
4
5 11
6
12 7
3
8
2
20 16
1 9 14 13 17 21
15 17 19 18
COMMON PARTS FOR 5.a, 5.b
1 68−11903−07 Strap Assembly, Fuel Tank Mounting − See Note 2
2 58−01183−11 Pad, Rubber 2
3 58−01183−10 Pad, Rubber 2
4 68−11876−00 Spacer − See Note 2
5 34−00928−14 Rivet, Blind, 3/16 Diameter, Grip Range − 1/4−3/8 − SST 12
6 34−00667−15 Locknut, 1/2−13 − SST 4
7 34−00662−15 Washer, Flat 1/2 − SST 4
8 62−10573−00 Label, Genset 1
9 58−04015−01 Pad, Rubber 2
10 62−02718−02 Decal, Forward 1
11 62−03882−07 Decal, Carrier Transicold 1
12 66U1−3882 Wire Tie, 1/16−1 3/4, Self locking 1
13 58−00412−01 Hose, 1/4 ID 1
14 40−00342−01 Elbow, 1/4 NPT X 1/4 Tube 1
15 12−01098−04 Gauge, Fuel 1
5.a INTEGRAL 50 GALLON FUEL TANK
16 65−00178−51 Fuel Tank, 50 Gallon − Includes: − See Note 1
17 65−00164−01 Tube, Pickup 2
18 40−00342−03 Elbow, 1/4 NPT X 3/8 Tube 1
19 65−00131−02 Vent, Fuel 1
20 62−02181−01 Decal, Diesel Fuel Only 1
5.b INTEGRAL 50 GALLON FUEL TANK, CUSTOMER SPECIFIC
17 65−00164−01 Tube, Pickup 2
18 40−00342−03 Elbow, 1/4 NPT X 3/8 Tube 1
19 65−00131−02 Vent, Fuel 1
NOTE: See page ii for painted parts color system.
13 T-343PL Rev C
5.c, 5.d INTEGRAL 50 GALLON FUEL TANK AND MOUNTING ASSEMBLY 7
9
14
12 15
13
11
16
10
17
18
5 8 2 4 2 1
7 6 3
21
22
19
OR
21
23
20
14
15
COMMON PARTS FOR 5.c, 5.d
2 65−00164−01 Tube, Pickup 2
3 40−00342−03 Elbow, 1/4 NPT X 3/8 Tube 1
4 65−00131−02 Vent, Fuel 1
6 58−00412−01 Hose, 1/4 ID 1
7 40−00342−01 Elbow, 1/4 NPT X 1/4 Tube 1
8 12−01098−04 Gauge, Fuel 1
10 58−01183−11 Pad, Rubber 2
11 58−01183−10 Pad, Rubber 2
12 68−11876−00 Spacer − See Note 2
14 34−00667−15 Locknut, 1/2−13 − SST 4
15 34−00662−15 Washer, Flat 1/2 − SST 4
16 62−10573−00 Label, Genset 1
17 58−04015−01 Pad, Rubber 2
19 62−02718−02 Decal, Forward 1
21 AU51YA012 Washer, Gasket 3/4 1
5.c INTEGRAL 50 GALLON FUEL TANK, WITH ALUMINUM PLUG
22 48−00405−00 Plug, HXHD 1
5.d INTEGRAL 50 GALLON FUEL TANK, WITH ALUMINUM DIPSTICK
23 44−00431−00 Dipstick, Fuel Tank 1
T-343PL Rev C 14
5.e INTEGRAL 65 GALLON FUEL TANK AND MOUNTING ASSEMBLY
9
10
11
17
18
16
1
5 8 2 4 2
7 6 3
15
12
19
13
14
20
10
11
2 65−00164−01 Tube, Pickup 2
3 40−00342−03 Elbow, 1/4 NPT X 3/8 Tube 1
4 65−00131−02 Vent, Fuel 1
6 58−00412−01 Hose, 1/4 ID 1
7 40−00342−01 Elbow, 1/4 NPT X 1/4 Tube 1
8 12−01098−04 Gauge, Fuel 1
10 34−00667−15 Locknut, 1/2−13 − SST 4
11 34−00662−15 Washer, Flat 1/2 − SST 4
12 62−10573−00 Label, Genset 1
13 58−04015−01 Pad, Rubber 2
15 58−01183−11 Pad, Rubber 2
16 58−01183−10 Pad, Rubber 2
17 68−11876−00 Spacer − See Note 2
19 62−02718−02 Decal, Forward 1
15 T-343PL Rev C
5.f, 5.g INTEGRAL 80 GALLON FUEL TANK AND MOUNTING ASSEMBLY
9 3
17 10 5
18 11
16
1
15
4 8 3 2 20 OR 20
7 6 21 23
19
22
12
14 13
10 19
11
COMMON PARTS FOR 5.f, 5.g
2 65−00131−02 Vent, Fuel 1
3 65−00164−01 Tube, Pickup 2
5 40−00342−03 Elbow, 1/4 NPT X 3/8 Tube 1
6 58−00412−37 Hose, 1/4 ID X 1/2 OD 1
7 40−00342−01 Elbow, 1/4 NPT X 1/4 Tube − NPT 1
8 12−01098−04 Gauge, Fuel 1
10 34−00667−15 Locknut, 1/2−13 − SST 4
11 34−00662−15 Washer, Flat 1/2 − SST 4
12 62−10573−00 Label, Genset 1
13 58−04015−04 Pad, Rubber 2
15 58−01183−13 Pad, Rubber 2
16 58−01183−10 Pad, Rubber 2
17 68−14871−00 Spacer − See Note 2
20 AU51YA−012 Washer, Gasket 3/4 1
5.f INTEGRAL 80 GALLON FUEL TANK, WITH DIPSTICK
21 44−00431−00 Dipstick, Fuel Tank 1
5.g INTEGRAL 80 GALLON FUEL TANK, WITH ALUMINUM PLUG
22 62−02718−02 Label, Forward 1
23 48−00405−00 Plug, HXHD, Aluminum 3/4−16−2A 1
T-343PL Rev C 16
5.h INTEGRAL 80 GALLON FUEL TANK AND MOUNTING ASSEMBLY
9 3
17 5 1
10
18 11
16
15
4 8 3 2
7 6
19
20
12
14 13
10 19
11
2 65−00131−02 Vent, Fuel 1
4 65−00164−01 Tube, Pickup 2
5 40−00342−03 Elbow, 1/4 NPT X 3/8 Tube 1
6 58−00412−37 Hose, 1/4 ID X 1/2 OD 1
7 40−00342−09 Elbow, 1/2 NPT X 1/4 Tube − Brass 1
8 12−01098−04 Gauge, Fuel 1
10 34−00667−15 Locknut, 1/2−13 − SST 4
11 34−00662−15 Washer, Flat 1/2 − SST 4
12 62−10573−00 Label, Genset 1
13 58−04015−04 Pad, Rubber 4
15 58−01183−13 Pad, Rubber 4
16 58−01183−12 Pad, Rubber 2
17 68−11876−00 Spacer − See Note 2
20 62−02718−02 Label, Forward 1
17 T-343PL Rev C
6 EXHAUST SYSTEM
6.a, 6.b EXHAUST SYSTEM WITH EXTENDED TAILPIPE, WITH EXT. TAILPIPE AND BAFFLES
4
1 5
2 6
3
10
11
12
13
14
8
9
6.b ONLY 6.b ONLY

6.a EXHAUST SYSTEM WITH EXTENDED TAILPIPE
1 34−01146−12 Washer, Lock 2
2 34−01151−12 Washer, Flat 2
3 34−01155−25 Screw, Cap Hex Head 2
4 34−00964−00 Stud 2
5 34−00932−13 Nut, Jam 3/8−24 4
6 66U1−5321−5 Washer, Plain 3/8 2
7 30−00472−00 Muffler 1
6.b EXHAUST SYSTEM WITH EXTENDED TAILPIPE AND BAFFLES
8 68−15037−00 Baffle 1
9 66CH1−1172−102 Trim, Flexible 1
12 66U1−5321−3 Washer, Plain 1/4 2
13 68−15038−00 Baffle, Exhaust 1
14 42−00174−51 Gasket 1
T-343PL Rev C 18
7 BATTERY CHARGER
2
3
4

1 30−00460−04 Battery Charger, Solid State 1
2 34−06014−12 Screw, Cap 1/4−20 X 0.75 4
4 66U1−5321−3 Washer, Plain1/4 4
19 T-343PL Rev C
8 COOLANT SYSTEM
8.a, 8.b, 8.c, 8.d, 8.e COOLANT SYSTEMS
1
2 3
21
4
5
6
14
2 15
7
4
5
8
16
17
18
4
9
10
11 20
12
11 13
19
4
5 20
6
23
22
21
8.c ONLY 8.d AND 8.e ONLY
T-343PL Rev C 20
8.a, 8.b, 8.c, 8.d, 8.e COOLANT SYSTEMS (Continued)
COMMON PARTS FOR 8.a THROUGH 8.e
1 58−04215−00 Hose, Formed 1
2 KA69JM824 Clamp, Hose − Range − 1−1/16 − 2.00 OD 4
3 30−00397−00 Cap, Radiator 1
4 66U1−5361−25 Screw, HXHD, 1/4−20 x 3/4 Long− SST 16
5 66U1−5321−7 Washer, Flat, 1/4 W Type A − SST 8
6 68−14126−00 Bracket 1
7 58−04784−00 Hose, Formed 1
9 69NT35−2692−1 Washer, Fender, 1/16 Thick − SST 8
10 58−04585−00 Venturi Assembly 1
11 58−00969−00 Wire Tie 2.80 Diameter Double Loop 2
12 44−00388−00 Clamp, Hose − 0.50 Diameter Flat Band 2
13 58−04184−01 Tube, Fuel − 1/4 ID x 29.00 Long 1
14 68−12513−00 Bracket 0.125 Thick Aluminum 1
15 66CH1−1172−26 Trim, Flexible 1
OPTION 8.a − SYSTEM WITH STANDARD COOLANT
16 81−01379−01 Radiator Assembly − Includes: 1
17 40−00081−00 Vent, Air − Brass 1
18 40−00117−01 Drain, Cock, 1/4 NPT − Brass 1
19 58−00848−20 Tube, Slit 1/2 ID X 20 Long Corr 1
20 69GS4−1702 Label, Anti−Freeze 1
OPTION 8.b − SYSTEM WITH EXTENDED LIFE COOLANT
17 40−00081−00 Vent, Air − Brass 1
21 62−10903−00 Label, Warning, Coolant Mixture 1
OPTION 8.c − SYSTEM WITH LOW COOLANT SENSOR
17 40−00081−00 Vent, Air − Brass 1
22 12−00641−00 Sensor, Low Coolant 1
OPTION 8.d − SYSTEM WITH EXTENDED LIFE COOLANT AND SERVICE ACCESS
17 40−00081−00 Vent, Air − Brass 1
21 62−10903−00 Label, Warning Cool Mix 1
23 62−10903−00 Nut, Self Lock 1/4−20 2
OPTION 8.e − SYSTEM WITH STANDARD COOLANT AND SERVICE ACCESS
17 40−00081−00 Vent, Air − Brass 1
23 62−10903−00 Nut, Self Lock 1/4−20 2
21 T-343PL Rev C
9 CONTROL BOX
9.a STANDARD CONTROL BOXES
1
CONTROL PANEL CONTROL BOX

2 PANEL AND COMPONENTS REMOVED
3
4 28
5 10
6 18
7 40
8 29
9 10
10 30
19 31 7
VIEW A 32 41
33 42
20
21
30
11 20 31
12 22 32
13 34
14
35
23
36
15
16 8
30 B
31
24 32
25 37
17 26 38
8
27 30
31
32 B
38
39
50 47 44
51 48 43
52 49
G 45
S I 43
43
53
46
VIEW A VIEW B−B
1 91−00400−00 Box, Control − Includes: − See Note 1
2 86−04706−00 Box, Control − See Note 1
3 68−11928−07 Panel, Control − See Note 1
4 42−00269−06 Gasket 2
5 42−00309−00 Gasket 2
6 66U1−5371−6 Screw, Machine Head, #10−24 x 0.75 Long− SST 8
7 66U1−5321−8 Washer, Flat, #10 − SST 9
8 66U1−5331−3 Washer, Lock, #10 − SST 12
9 12−00097−03 Gauge, Water Temperature 1
T-343PL Rev C 22
9.a STANDARD CONTROL BOX (Continued)
10 KK71EW223 O−Ring 3
11 10−00448−00 Meter, Hour 1
12 69GS4−1582−1 Gasket, Hour Meter 1
13 66U1−6651−15 Screw, Machine Pan Head, #4−40 X 0.75 Long− SST 3
14 34−00667−05 Nut, Self Lock, #4−40 − SST 3
15 68−13441−00 Shield 1
16 42−01096−01 Seal 6.00 Inches Long 1
17 62−03957−04 Decal, (Warning, High Voltage) 1
18 66U1−2823 Gauge, Oil Pressure 1
19 22−00538−01SV Ammeter 1
20 66U1−9752 Seal 2
21 10−01129−19 Switch, Toggle (IH) 1
22 10−01129−13 Switch, Toggle (IGN) 1
23 62−02669−01 Label, Intake Air Heater & Ignition Switches 1
24 KK71GW007 O−Ring 1
25 10−00365−10 Boot, Circuit Breaker 1
26 10−00365−00 Circuit Breaker 3 Amp 1
27 69GC15−3812 Label, Battery Charger C.B. 1
28 66CH1−1002−132 Label, (S) 1
29 66CH1−1002−38 Label (HR) 1
30 66U1−5321−2 Washer, Flat, #8 − SST 4
31 66U1−5331−4 Washer, Lock #8 − SST 4
32 34−00666−08 Nut, Hex, #8−32 − SST 4
33 10−00286−03 Relay, 30 Amp 1
34 10−00328−00 Relay 70 Amp 1
35 66CH1−1002−5 Label, (CB3) 1
36 66U1−3662−21 Label, (CB2) 1
37 10−00171−12 Circuit Breaker, 30 Amp 1
38 AT39QA132 Nut, Hex, #10−32 4
40 62−10530−25 Label, IHT 1
41 10−00469−00 Time Delay, 12 VDC, 50−60 Hertz 1
42 34−00795−09 Nut, Self Lock 10−32 1
43 34−00667−11 Nut, Self Lock, 1/4−20 − SST 9
44 66U1−9592−13 Standoff, 1/4−20 X 0.375 Long 2
45 69NT41−982−2 Strap Assembly, Ground 1
46 66U1−5321−3 Washer, Flat, 1/4 − SST 2
47 22−01030−54 Diode Assembly 6 Amp 1
48 22−02200−06 Washer, Plain #6 2
49 34−00667−07 Nut, Self Lock 6−32 2
50 34−01159−02 Receptacle #12 Scr Flat Rivet 2
51 34−00928−01 Rivet, Blind 0.125 Diameter 0.063−0.125 4
52 58−04026−32 Protector 0.75 X 1.06 Mylar 2
53 34−00372−41 Washer, Lock 1/4 Ext Tooth 5
NS 66U1−3882 Wire Tie 1/16−1−3/4 Self locking 30
23 T-343PL Rev C
9.b CONTROL BOX − AUTO RESTART
1
CONTROL PANEL CONTROL BOX
PANEL AND COMPONENTS REMOVED
2
18
3
4 32
5
6 41
7 33
8 10
19 34 42
9 35
10 20 36 34
37 35
36
VIEW A 43
11 38
10
12 21 44
13
14
22 8
23 34 8
24 35 34
15 36 35
16 25 39 36
26 40 B 40
45
27
28
17
29
30
31
B
53
46 2
47 49
48 50 52
51
52 54
G 57
I 52 58
S
55
56
VIEW A VIEW B−B
REAR VIEW
4 42−00269−06 Gasket 2
5 42−00309−00 Gasket 2
7 66U1−5321−8 Washer, Flat, #10 − SST 9
8 66U1−5331−3 Washer, Lock, #10 − SST 12
T-343PL Rev C 24
9.b CONTROL BOX − AUTO RESTART (Continued)
11 10−00448−00 Meter, Hour 1
14 34−00667−05 Nut, Self Lock, #4−40 − SST 3
15 68−13441−00 Shield 1
16 42−01096−01 Seal 6.00 Inches Long 1
18 62−10387−01 Label, Lights 1
20 10−00375−01 Buzzer, Warning 1
21 22−00538−01SV Ammeter 1
22 22−00049−00 Lamp 1
23 22−00518−01 Base 1
24 22−00519−01 Jewel Assembly, Pilot Light, Red 1
25 66U1−9752 Seal 2
27 62−02973−04 Label, Engine Start, Ignition, Operation 1
32 62−10530−02 Label, 0.75 X 0.50 SR 1
33 66HC1−1002−18 Label, (LR) 1
34 66U1−5321−2 Washer, Flat, #8 − SST 8
35 66U1−5331−4 Washer, Lock #8 − SST 8
36 34−00666−08 Nut, Hex, #8−32 − SST 8
37 10−00286−02 Relay 3
38 66U1−3662−21 Label, (CB2) 1
40 AT39QA132 Nut, Hex, #10−32 4
41 66CH1−1002−132 Label, (S) 1
42 66CH1−1002−38 Label, (HR) 1
43 10−00328−00 Relay 70 Amp 1
44 66CH1−1002−5 Label, (CB3) 1
46 34−01159−02 Receptacle #12 Scr Flat Rivet 2
48 58−04026−32 Protector 0.75 X 1.06 Mylar 2
50 22−02200−06 Washer, Plain #6 2
51 34−00667−07 Nut, Self Lock 6−32 2
52 34−00667−11 Nut, Self Lock, 1/4−20 − SST 9
53 66U1−9592−13 Standoff, 1/4−20 X 0.375 Long 2
56 66U1−5321−3 Washer, Flat, 1/4 − SST 2
57 12−00477−02 Module, Auto−Restart 1
58 42−00481−00 Gasket 1
25 T-343PL Rev C
9.c CONTROL BOX − AUTO RESTART − 2 SPEED
1
2
55
3 54
4 7
5 VIEW A
45
6 46
7 23
8 47 7
22 35 8
14 19 44
14
20
21
9 26 19
10 13 20
11 14 25 21
12 24 31
40
19
41 16 20 19
17 21
15 20
17 27 21
56 8
18 17 B 28
34 8
49 34
50
36 51
48 B
42 30
39 37
38 52 33
53 29
43
G
I 29
S 43
29
43 32
VIEW A VIEW B−B

4 42−00269−06 Gasket 2
5 42−00309−00 Gasket 2
7 66U1−5321−8 Washer, Flat, #10 − SST 9
8 66U1−5331−3 Washer, Lock, #10 − SST 12
9 10−00448−00 Meter, Hour 1
T-343PL Rev C 26
9.c STANDARD CONTROL BOX − 2 SPEED (Continued)
12 34−00667−05 Nut, Self Lock, #4−40 − SST 3
13 22−00538−01 Ammeter 1
15 10−01129−19 Switch, Toggle 4−Pole 1
16 10−01129−14 Switch, Toggle On/On/On Momentary 1
17 66U1−9752 Seal 2
18 62−02669−02 Label, lh/Ign/2Spd Switch 1
19 66U1−5321−2 Washer, Flat, #8 − SST 4
20 66U1−5331−4 Washer, Lock #8 − SST 4
21 34−00666−08 Nut, Hex, #8−32 − SST 4
22 12−00097−03 Gauge, Dual Water Temp 1
23 66CH1−1002−132 Label, S 1
24 66U1−3662−21 Label Cb2 1
25 66CH1−1002−5 Label Cb3 1
26 10−00286−03 Relay 1
29 34−00667−11 Nut,Self Lock 1/4−20 9
30 66U1−9592−13 Standoff 1/4−20 X 0.375 2
31 10−00328−00 Relay, 70 Amp 1
33 69NT41−982−2 Strap Assembly Ground 1
34 AT39QA132 Nut,Hex #10−32 4
36 62−03957−04 Decal, Warning High Voltage 1
37 22−01030−54 Diode Assembly, 6 Amp 1
38 34−01159−02 Receptacle 2
39 34−00928−01 Rivet, Blind 4
40 68−13441−00 Shield 1
41 42−01096−01 Seal 1
42 58−04026−32 Protector 2
43 34−00372−41 Washer,Lock 1/4 Ext Tooth 5
44 10−00469−00 Time Delay, 12Vdc, 50−60 Hertz 1
45 34−00795−09 Nut, Self Lock 10−32 1
46 62−10530−25 Label, Iht 1
47 66CH1−1002−38 Label Hr 1
52 22−02200−06 Washer, Plain #6 2
53 34−00667−07 Nut, Self Lock 6−32 2
54 10−00475−00 Timer, Time Delay, 2 Hour 1
55 66CH1−1002−89 Label 1
56 10−01129−15 Switch, Toggle 1 Pole 0ff/On 1
27 T-343PL Rev C
9.d CONTROL BOX, CUSTOMER SPECIFIC
1
CONTROL BOX
2 CONTROL PANEL
PANEL AND COMPONENTS REMOVED
3
4
5 26
6 10 35
7 20
8
27
9 28 7
10 29 36
30
37
11 31
12 10 38
13 21
14
27
22 28
15 30
16 32 39
23
A A
15
24
8 8
17 27 27
28 28
25 30 30
33 34
34 40
18
19
45
44
41
42 44
43 46
44
47
48
VIEW A−A

4 42−00269−08 Gasket 2
5 42−00269−09 Gasket 2
7 66U1−5321−8 Washer, Flat, #10 − SST 9
T-343PL Rev C 28
9.d CONTROL BOX, CUSTOMER SPECIFIC (Continued)
8 66U1−5331−3 Washer, Lock, #10 − SST 12
11 10−00448−00 Meter, Hour 1
14 34−00667−05 Nut, Self Lock, #4−40 − SST 3
15 66U1−9752 Seal 2
16 10−01129−19 Switch, Toggle (IH) 1
17 69GC15−3812 Label (Battery Charger) 1
18 10−00365−10 Boot Circuit Breaker 1
21 22−00538−01SV Ammeter 1
22 68−12973−00 Bracket 1
23 62−02669−01 Label, Intake Air Heater & Ignition Switches 1
26 66CH1−1002−38 Label (HR) 1
27 66U1−5321−2 Washer, Flat, #8 − SST 4
28 66U1−5331−4 Washer, Lock #8 − SST 4
29 10−00328−00 Relay, 70 Amp 1
30 34−00666−08 Nut, Hex, #8−32 − SST 4
31 66CH1−1002−132 Label, (S) 1
32 10−00286−03 Relay, 30 Amp 1
34 AT39QA132 Nut, Hex, #10−32 4
35 62−10530−25 Label (IHT) 1
36 10−00469−00 Time Delay, 12 VDC, 50−60 Hz 1
37 34−00795−09 Nut, Self Lock, 10−32 1
38 66U1−3662−21 Label, (CB2) 1
39 66CH1−1002−5 Label, (CB3) 1
42 22−02200−06 Washer, Plain #6 2
43 34−00667−07 Nut, Self Lock, 6−32 2
44 34−00667−11 Nut, Self Lock, 1/4−20 − SST 9
45 66U1−9592−13 Standoff, 1/4−20 X 0.375 Long 2
48 66U1−5321−3 Washer, Flat, 1/4 − SST 2
29 T-343PL Rev C
9.e CONTROL BOX, CUSTOMER SPECIFIC − 2 SPEED
1
CONTROL PANEL 3 CONTROL BOX

4 PANEL AND COMPONENTS REMOVED
2 5
53
6
7
14
22 8 52
14
35 7
8
9 46 45
10 13
14 31
11 44
19
12 47
20
21 7
24
42 50
23 25
15 51 28
17 17 19
A A
18 37 20
38 21
39 27 8
36 26 19 34
19 20
40
20 21
21 8
34
30
16
17
29
41
48
29
49 33
29
43
32
VIEW A−A

1 91−00387−02 Control Box Assembly Includes: 1
2 86−04679−02 Box, Welded T4I, 2 Speed 1
3 68−15467−01 Panel, Control 1
4 42−00269−08 Gasket 2
5 42−00269−09 Gasket 2
6 66U1−5371−6 Screw, Machine Hex Head #10−24 X 0.750 8
7 66U1−5321−8 Washer, Plain #10 Type A 10
8 66U1−5331−3 Washer, Lock #10 Spring 12
T-343PL Rev C 30
9.e CONTROL BOX, CUSTOMER SPECIFIC − 2 SPEED (Continued)
9 10−00448−00 Meter, Hour 1
10 69GS4−1582−1 Gasket 1
11 66U1−6651−15 Screw, Machine Pan Head #4−40 X 3/4 Inch Long 3
12 34−00667−05 Nut, Self Lock 3
13 22−00538−01 Ammeter, +60 /−60 Amps 1
14 KK71EW−223 O−Ring 3
15 10−01129−19 Switch, Toggle 4−Pole 1
16 10−01129−14 Switch,Toggle On/On/On 1
17 66U1−9752 Seal 3
18 62−02669−02 Label, Ih/Ign/2Spd Switch 1
19 66U1−5321−2 Washer, Plain #8 Type A 4
21 34−00666−08 Nut, Hex #8−32 4
22 12−00097−03 Gauge, Dual Water Temperature 1
23 66CH1−1002−132 Label, ”S” 1
24 66U1−3662−21 Label, ”Cb2” 1
25 66CH1−1002−5 Label ”Cb3” 1
26 10−00286−03 Relay 1
29 34−00667−11 Nut, Self Lock 1/4−20 9
30 66U1−9592−13 Standoff, 1/4−20 X 0.375 Inch Long 2
31 10−00328−00 Relay, 70 Amp 1
32 66U1−5321−3 Washer, Plain 1/4 N Type A 2
34 AT39QA132 Nut,Hex #10−32 4
36 69GC−15−3812 Label, Battery Charger 1
40 62−03957−04 Decal, Warning, High Voltage 1
41 22−01030−54 Diode Assembly, 6 Amp 1
42 68−12973−00 Bracket 1
43 34−00372−41 Washer, Lock 1/4 5
44 10−00469−00 Time Delay 1
45 62−10530−25 Label ”Iht” 1
46 66CH1−1002−38 Label ”Hr” 1
47 34−00795−09 Nut, Self Lock 10−32 2
48 22−02200−06 Washer, Plain #6 2
49 34−00667−07 Nut, Self Lock 6−32 2
50 69GC15−3542 Bracket 1
51 10−01129−15 Switch, Toggle 1 Pole 0Ff/On 1
52 10−00475−00 Timer, Time Delay, 2 Hour 1
53 66CH1−1002−89 Label 1
31 T-343PL Rev C
10 VOLTAGE
10.a, 10.b, 10.c VOLTAGE
1
2 DETAIL A−A
3 8
9
10
11
12
21
22
23
DETAIL
A−A 13
4
5
6 14
7
14
13
14
15
16
17
2 2
18 3
26
19
2
18
26 10.c ONLY
SEE ENGINE
MANUAL FOR
ENGINE SPEED
CONTROL
24 27
20 25 28 2
29 18
10.c ONLY 10.a AND 10.b ONLY
T-343PL Rev C 32
10.a, 10.b, 10.c VOLTAGE (Continued)
COMMON PARTS FOR 10.a THROUGH 10.c
1 34−00655−08 Screw, Cap HXHD 1/4−20 X 1.00 6
2 66U1−5321−3 Washer, Plain 1/4 10
3 AU11JR−171 Washer, Lock 1/4 Spring 6
5 34−01155−20 Screw, Cap HXHD M12 X 20 MM 1
6 34−01151−12 Washer, Flat M12 1
7 34−01146−12 Washer, Lock M12 Spring 1
8 66U1−8772 Diode 6 Amp, 0.250 Q.C. 1
9 34−01145−06 Nut, Hex 1
12 34−01151−08 Washer, Flat M8 1
13 58−04246−02 Ty−Rap Base Mounting Tab 1
14 66U1−3882 Wire Tie 1/16−1−3/4 Self locking 8
15 66U2−1132 Connector, Electric 12−10 Gage, Non−Insulated 3
16 66U1−2583−45 Tube, Heat Shrink 3/8 ID X 2.25 Blk 3
17 66U1−3803−1 Tube, Heat Shrink 1/2 X 2−3/4 Blk 3
18 34−00667−11 Nut, Self Lock 1/4−20 4
19 42−00348−00 Gasket 0.125 Thick Neoprene 1
20 22−02302−04 Connector, 1 Inch Straight 1
10.a 460 VOLT VOLTAGE KIT (CE)
21 66U1−5371−6 Screw, Mach HXHD #10−24 X 0.750 Slotted 6
22 66U1−5321−8 Washer, Plain #10 6
10.b 460 VOLT VOLTAGE KIT WITH LOW COOLANT SENSOR AND AUTO RESTART
21 66U1−5371−6 Screw, Mach HXHD #10−24 X 0.750 Slotted 6
22 66U1−5321−8 Washer, Plain #10 6
25 66U1−5371−14 Screw, Mach HXHD 1/4−20 X 3/4Long Slotted 1
10.c 460 VOLT VOLTAGE KIT WITH RECEPTACLE AND EXTERNAL MOUNTED CONTROL BOX (CE)
24 34−00372−41 Washer, Lock 1/4 1
25 66U1−5371−14 Screw, Mach Hex Head 1/4−20 X 3/4 1
27 34−00667−12 Nut, Self Lock 5/16−18 1
33 T-343PL Rev C
11 LABELS
2
1 3
4
5
8 9
10 11 12
T-343PL Rev C 34
11 LABELS (Continued)
1 62−10925−00 Label, Attention A/R
2 62−10572−01 Label, Genset A/R
3 62−10391−01 Label, Protective A/R
4 62−11417−00 Label, Carrier Start/Stop A/R
5 62−11138−00 Label, Forward/Attention A/R
6 62−03957−04 Decal, Warning, High Voltage A/R
7 62−02146−00 Decal, Warning, Auto Start A/R
8 62−11006−00 Label, Fork Stop A/R
9 62−10395−01 Label, Powerline A/R
10 62−02895−00 Label, Fan Warning A/R
11 62−02785−00 Label, CE (European Comm) A/R
12 62−02972−00 Label, Hot Surface A/R
11.a RETROFIT LABELS
4 1
4 5
3 6

1 79−01909−06 Plate Assembly Includes 1
2 62−11439−00 Schematic 1
3 58−01097−00 Cord, Nylon 1
4 22−02205−00 Connector 2
5 62−11447−01 Label, T4I Start/Stop, 2 Speed 1
6 62−11302−00 Decal, Warning (Ether) 2
NS 66U1−9042 Sealer, Edge (Clear) 0
35 T-343PL Rev C
12 RECEPTACLES
12.a, 12.b RECEPTACLE BOX
8
1
9 1
10
2 11
12
3
4
5
6
10
11
14
13 15
16
T-343PL Rev C 36
12.a, 12.b RECEPTACLE BOX − Continued
COMMON PARTS FOR OPTION 12.a AND 12.b
− 91−00320−XX Receptacle Box Assembly − 460 Volt − Includes: See Note 1
1 86−04152−02 Box, Receptacle − 460 Volt − See Note 1
2 66U1−7842−11 Circuit Breaker, 26 Amp − 480 Volt 1
3 66U2−1391−1 Boot, Receptacle − Includes: 1
4 66CH1−1092−4 Frame, Boot 1
5 66U1−7842−7 Washer, Flat, #10−32 − Nickel 12
6 66U1−7842−6 Nut, Hex, #10−32 6
7 62−02948−00 Label, Danger, High Voltage 1
8 42−00324−00 Gasket, Back Panel 1
9 68−14266−00 Panel, Back − See Note 1
10 66U1−5331−3 Washer, Lock, #10 − SST 6
11 66U1−5321−8 Washer, Flat, #10 − SST 6
12 34−00665−09 Nut, Hex, #10−32 − SST 2
14 66U1−5371−6 Screw, Machined HXHD, #10−24 X 0.75 Long− SST 4
12.a RECEPTACLE BOX
− 91−00320−00 Receptacle Box Assembly − 460 Volt − Includes: See Note 1
15 22−01679−00 Receptacle, 480 Volt, 32 Amp − Includes: 1
16 NSS Gasket 1
12.b RECEPTACLE BOX, CE
16 NSS Gasket 1
37 T-343PL Rev C
12.c, 12.d, 12.e RECEPTACLE BOX
14 1
8
1
8
2 9
3 10
4 11
5 15
6 16
17
18
7 19
9
10
13
12 20
21

COMMON PARTS FOR OPTION 12.c, 12.d and 12.e
− 91−00320−XX Receptacle Box Assembly − 460 Volt − Includes: See Note 1
1 86−04152−02 Box, Receptacle − 460 Volt − See Note 1
2 66U1−7842−11 Circuit Breaker, 26 Amp − 480 Volt 1
3 66U2−1391−1 Boot, Receptacle − Includes: 1
4 66CH1−1092−4 Frame, Boot 1
5 66U1−7842−6 Nut, Hex, 10−32 6
6 66U1−7842−7 Washer, Flat, #10−32 − Nickel 12
7 62−02948−00 Label, Danger, High Voltage 1
9 66U1−5331−3 Washer, Lock, #10 − SST 6
10 66U1−5321−8 Washer, Flat, #10 − SST 6
11 34−00665−09 Nut, Hex, #10−32 − SST 2
13 66U1−5371−6 Screw, Machined HXHD, #10−24 X 0.75 Long− SST 4
14 42−00324−00 Gasket, Back Panel 1
15 66U1−5321−7 Washer, Plain, 1/4 5
16 34−00667−11 Nut, Self Lock, 1/4−20 − SST 7
17 34−00372−41 Washer, Lock, 1/4 − SST 2
T-343PL Rev C 38
12.c − 12.j RECEPTACLE BOX (Continued)
12.c RECEPTACLE BOX
19 22−01986−00 Harness, Grounding 2
21 NSS Gasket 1
12.d RECEPTACLE BOX, CE
21 NSS Gasket 1
12.e RECEPTACLE BOX, CE
21 NSS Gasket 1
12.f RECEPTACLE BOX, CE
21 NSS Gasket 1
12.g RECEPTACLE BOX, CE
21 NSS Gasket 1
12.h RECEPTACLE BOX, CE
21 NSS Gasket 1
12.i RECEPTACLE BOX, CE
21 NSS Gasket 1
12.j RECEPTACLE BOX, TD
1 86−04152−05 Box, Receptacle − 460 Volt with TD − See Note 1
21 NSS Gasket 1
39 T-343PL Rev C
12.k RECEPTACLE BOX
1 8 1
2 9
3 10
4 11
5 12
6
13
7
14
17
18
15 19
20
16
10
11
21
22
23

91−00320−01 Receptacle Box Assembly − 230 Volt − Includes:
1 86−04152−03 Box Assembly, 230 Volts 1
2 66U1−7842−8 Circuit Breaker, 48 Amp, 240 Volts 1
3 66U2−1391−1 Boot, Includes 1
4 66CH1−1092−4 Boot Frame 1
5 66U1−7842−6 Nut, Hex, 10−32, Circuit Breaker 12
6 66U1−7842−7 Washer, Flat #10−32 12
7 62−02670−01 Label, Off 1
8 42−00324−00 Gasket 1
9 68−14266−01 Panel, Back 1
10 66U1−5331−3 Washer, Lock 6
11 66U1−5321−8 Washer Plain 6
12 34−00665−09 Nut, Hex, #10−32 2
13 62−02670−00 Label, On 1
14 62−02700−03 Label, Cb4, 230 Volt 1
15 66CH1−1022−5 Label, Danger, High Voltage 1
16 22−02302−04 Connector, Straight, 1 Inch 1
17 66U1−3863−1 Receptacle Assembly, Female, 250V/60 Amps 1
18 66U1−5361−25 Screw, Cap, HXHD, 1/4−20 X 0.750 4
19 AU11JR171 Washer, Lock 4
20 66U1−5321−3 Washer, Plain 1/4 Inch 4
21 22−01286−00 Receptacle − Includes: 1
22 NSS Gasket 1
23 66U1−5371−6 Screw, Machine, HXHD, #10−24 X 0.750 4
T-343PL Rev C 40
12.l RECEPTACLE BOX
1 7
1
8
2 9
3 10
11 14
4 15
5
6 16
17
12
18
13
19
20
21

91−00320−04 Receptacle Box Assembly − 460 Volt − Includes:
1 86−04136−03 Box Assembly, 460 Volt 1
2 66U1−7842−11 Circuit Breaker, 480 Volt 1
3 66U2−1391−1 Boot, Includes 1
4 66CH1−1092−4 Boot Frame 1
5 66U1−7842−6 Nut, Hex, 10−32, CIrcuit Breaker 6
6 66U1−7842−7 Washer, Flat #10−32 12
7 42−00324−00 Gasket 1
8 68−14266−01 Panel, Back 1
9 66U1−5331−3 Washer, Lock 2
10 66U1−5321−8 Washer Plain 2
11 34−00665−09 Nut, Hex, #10−32 2
12 62−02948−00 Label, CB, On−Off, Danger, Hv 1
13 22−02302−04 Connector, Straight, 1 Inch 1
14 44−00102−54 Clamp, Cushioned, 0.750 Diameter 1
15 34−00655−04 Screw, Cap, HXHD, 1/4−20 X 0.50 1
16 AU11JR171 Washer, Lock 1
18 66CH1−153−86 Cable Assembly − Includes: 1
NS 22−01839−00 Receptacle 1
19 66U1−8472−3 Connector, 90 Degree, 3/4 Hub 1
20 66U1−1251−2 O−Ring, 3/4 Hub Sealing 1
21 34−06136−01 Nut, Lock, 3/4 Inch NPT 1
41 T-343PL Rev C
12.m RECEPTACLE BOX
12
1
2
3
4
5
3
4
6 Unit Frame
7
8
2
3
4 7
11 10
T-343PL Rev C 42
12.m RECEPTACLE BOX (Continued)
91−00334−01 Receptacle Box Assembly, 460 Volt − Includes:
1 68−13794−01 Cover 1
2 34−00655−06 Screw, Cap, HXHD, 1/4−20 X 0.75 10
3 34−00663−11 Washer, Lock, 1/4 12
4 34−06212−12 Washer, Plain 12
5 42−00509−01 Gasket 1
6 86−04430−01 Box Assembly 1
7 34−00655−08 Screw, Cap, HXHD, 1/4−20 X 1.00 8
8 42−00508−00 Gasket Receptacle Box 1
9 66CH1−1022−5 Label, Danger, High Voltage 3
10 22−01942−01 Receptacle, 460 Volt 1
11 68−13791−00 Plate, Blank−Off 1
12 22−01946−00 Connector 1
43 T-343PL Rev C
13 PANELS AND DOORS
13.a, 13.b PANEL AND DOOR ASSEMBLIES
2 2
2 3 5
5 4 7
7 27
12
26
19 2
22 5
23 7
8
9 28
10
11
13
35 14
34 20
32 21
16 15
17
18 SEE SECTION 13.f
FOR PARTS
17
33 20 30
35 31
36
1
6
15
25
17 2
5
29 7
OPTION 13.b ONLY 24
T-343PL Rev C 44
13.a, 13.b PANEL AND DOOR ASSEMBLIES (Continued)
COMMON PARTS for 13.a, 13.b
1 42−00174−42 Gasket 2
3 34−06003−08 Screw, Cap HXHD 1/4−20 X 10.00 8
5 66U1−5361−25 Screw, Cap HXHD 1/4−20 X 0.75 5
6 42−00174−43 Gasket 2
8 66U1−2552 Gasket 0.12 Thick X 0.50 X 17.63 1
9 34−00807−10 Screw, Cap HXHD 3/8−16 X 1.25 4
12 68−15522−00 Panel, Top 1
13 86−04119−01 Channel, Support Frame, Mounting Kit 1
14 68−14709−00 Spacer 16 Gage Min Steel 2
− 76−00663−12 Door Assembly − Includes: 1
15 44−00401−00 Latch, Door Spring Loaded 1
16 68−15492−02 Door, Access, Service Side 1
18 66U1−2552−173 Gasket 14.75 X 0.5 X 0.12 2
19 34−06107−00 Rivet, Blind 0.125, Diameter 0.188−0.250 3
20 44−00352−00 Hinge 2
22 58−04389−00 Pocket, Placard 1
23 AU53VA061 Washer, Gasket (0.125 Diameter Rivet) 3
24 68−15029−00 Panel, Back 1
25 68−12814−02 Door, Access 1
26 66U1−3882 Wire Tie 1
− 79−01795−00 Door Assembly − SEE Section 13.f FOR SPECIFIC PARTS 1
13.a PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
27 68−14535−00 Cover 1
28 68−12082−02 Door 1
13.b PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
27 68−14535−02 Cover 1
28 68−12082−01 Door 1
29 86−04597−00 Weld Assembly 1
30 44−00352−00 Hinge 1
31 34−00928−13 Rivet, Blind 6
32 66U1−6811−12 Screw, Retaining 1
33 34−01226−00 Washer, Retaining 1
34 34−06053−03 Washer 1
35 68−15034−00 Door, Access 1
36 42−00174−45 Gasket 2
45 T-343PL Rev C
13.c PANEL AND DOOR ASSEMBLIES
2 2
3 5
2 4 7
5 23
7
12
2
5
7
8
24
9
10
11
13
14 SEE SECTION 13.f
FOR PARTS
19
20 16
17 15
18
17
19
1
6
15
22
2
5
7
21
T-343PL Rev C 46
13.c PANEL AND DOOR ASSEMBLIES (Continued)
13.c PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
1 42−00174−42 Gasket 2
3 34−06003−08 Screw, Cap HXHD 1/4−20 X 10.00 8
5 66U1−5361−25 Screw, Cap HXHD 1/4−20 X 0.75 5
6 42−00174−43 Gasket 2
8 66U1−2552 Gasket, 0.12 Thick X 0.50 X 17.63 1
9 34−00807−10 Screw, Cap HXHD 3/8−16 X 1.25 4
12 68−15522−00 Panel, Top 1
14 68−14709−00 Spacer, 16 Gage Min Steel 2
16 68−15492−00 Door, Access, Service Side 1
17 34−00928−13 Rivet, Blind 0.187 Diameter 0.126 − 0.250 6
18 66U1−2552−173 Gasket 14.75 X 0.5 X 0.12 2
19 44−00352−00 Hinge 2
21 68−15029−00 Panel, Back 1
22 68−12814−02 Door, Access 1
23 68−14535−00 Cover 1
24 68−12082−02 Door 1
47 T-343PL Rev C
13.d PANEL AND DOOR ASSEMBLIES
2
2 5
3 7
2 4 23
5 25
7
12
2
5
7
9 22
10
11
13
14
SEE SECTION 13.f
FOR PARTS
17
18
29
16
15 27
19 30
26
16
21
27 15
29 17
30 28
20
31
32
1
2
6
5
7 24
20
T-343PL Rev C 48
13.d PANEL AND DOOR ASSEMBLIES (Continued)
13.d PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
1 42−00174−42 Gasket 2
3 34−06003−08 Screw, Cap HXHD 1/4−20 X 10.00 8
5 66U1−5361−25 Screw, Cap HXHD 1/4−20 X 0.75 5
6 42−00174−43 Gasket 2
8 66U1−2552 Gasket 0.12Thick X 0.50 X 17.63 1
9 34−00807−10 Screw, Cap HXHD 3/8−16 X 1.25 4
12 68−15522−00 Panel, Top 1
15 34−00928−13 Rivet, Blind, 0.187 Diameter 0.126−0.250 6
16 66U1−5321−3 Washer, Plain 1/4 2
17 44−00352−00 Hinge 2
18 34−00928−14 Rivet, Blind, 0.187 Diameter 0.251−0.375 6
19 68−15492−01 Door, Access 1
20 68−15029−01 Panel, Back 1
21 68−12814−01 Door, Access 1
22 68−12082−02 Door 1
23 68−14252−00 Access Panel 1
24 34−00928−01 Rivet, Blind 2
25 68−14535−01 Rivet, Blind 2
26 66U1−2552−173 Gasket, 14.75 X 0.5 X 0.12 2
27 66U1−6811−12 Screw, Retaining, 0.300−0.625 Phillips 3
28 68−15575−00 Bracket, Guard, 0.125 Thick Aluminum 1
29 34−01226−00 Washer, Retaining, 0.18 ID X 0.61 OD 3
30 34−06053−03 Washer, 0.250 ID X 1.000 OD 3
31 34−01142−01 Receptacle, #12 Saddle Type 3
32 34−00928−02 Rivet, Blind 0.125 Diameter 6
49 T-343PL Rev C
13.e PANEL AND DOOR ASSEMBLIES
2 2
3 5
4 7
2 25
5
7
12
2
5
7
8
26
9
10
11
13
14 SEE SECTION 13.f
FOR PARTS
15 19
16 21 20
22
18
17
19
1
6
15
24
2
5
7
23
T-343PL Rev C 50
13.e PANEL AND DOOR ASSEMBLIES (Continued)
13.e PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
1 42−00174−42 Gasket 2
3 34−06003−08 Screw, Cap HXHD 1/4−20 X 10.00 8
5 66U1−5361−25 Screw, Cap HXHD 1/4−20 X 0.75 11
6 42−00174−43 Gasket 2
8 66U1−2552 Gasket 0.12Thick X 0.50 X 17.63 1
9 34−00807−10 Screw, Cap HXHD 3/8−16 X 1.25 4
12 68−15522−00 Panel, Top 1
16 68−15492−03 Door, Access 1
18 66U1−2552−173 Gasket 14.75 X 0.5 X 0.12 2
19 44−00352−00 Hinge 2
21 34−00795−09 Nut, Self locking 2
22 66U1−5321−8 Washer, Plain 2
23 68−15029−00 Panel, Back 1
24 68−12814−02 Door, Access 1
25 68−14535−00 Cover 1
26 68−12082−03 Door 1
51 T-343PL Rev C
13.f PANEL AND DOOR ASSEMBLIES
3
11
2 12
9
10
7
4
5
1
8 6
T-343PL Rev C 52
13.f, 13.g PANEL AND DOOR ASSEMBLIES (Continued)
13.f PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
1 68−13439−00 Door 1
2 44−00399−00 Hinge 2
3 58−04428−00 Panel 1
4 42−00483−00 Gasket 1
5 42−00484−00 Gasket 1
9 34−00928−13 Rivet, Blind 4
10 66U1−5371−9 Screw, Mach Hex Head 4
11 34−00928−05 Rivet, Blind 6
12 AU53VA061 Washer, Gasket 6
13.g PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − PID’s UG1500 And Up
1 68−13439−02 Door 1
2 44−00399−00 Hinge 2
3 58−04428−00 Panel 1
4 42−00483−00 Gasket 1
5 42−00484−00 Gasket 1
9 34−00928−13 Rivet, Blind 4
10 66U1−5371−9 Screw, Mach Hex Head 4
11 34−00928−05 Rivet, Blind 6
12 AU53VA061 Washer, Gasket 6
53 T-343PL Rev C
13.h PANEL AND DOOR ASSEMBLIES
1
18
19
6 5 4
8 7 10
8 11
9 12
14
20
13
15
21 17
16
T-343PL Rev C 54
13.h PANEL AND DOOR ASSEMBLIES (Continued)
13.h PANEL AND DOOR ASSEMBLIES − SPECIFIC PARTS − REFER TO MODEL CHART
1 68−14535−00 Cover 1
2 68−12082−03 Door 1
3 68−15029−03 Panel, Back 1
4 68−12814−02 Door, Access 1
5 68−15492−00 Door, Access 1
6 44−00352−00 Hinge 2
7 34−00928−14 Rivet, Blind 6
8 34−00928−13 Rivet, Blind 6
9 66U1−2552−173 Gasket 2
10 44−00401−00 Latch, Door 1
11 42−00174−42 Gasket 2
12 42−00174−43 Gasket 2
13 68−15486−00 Door 1
14 44−00352−00 Hinge 2
15 42−00269−10 Gasket 2
18 34−01142−01 Receptacle 2
19 34−00928−02 Rivet, Blind 4
20 34−00928−14 Rivet, Blind 6
21 34−00928−13 Rivet, Blind 6
55 T-343PL Rev C
14 FRAME ASSEMBLY
14.a, 14.b, 14.cSTANDARD MOUNT FRAME ASSEMBLY
5 10
7 2
5 8 9
4
1
3 4
3
6 1
2
OPTION 14.a AND 14.b OPTION 14.c
11 11
12

COMMON PARTS FOR OPTION 14.a THROUGH 14.c
1 68−11862−01 Plate, Mounting − See Note 4
2 34−06026−02 Roll Pin, 0.187 Diameter x 1.00 Long − Zinc Plated Carbon Steel 4
3 34−06158−21 Washer, Spherical, Female, 1.06 ID x 2 OD x 0.29 Thick 4
4 34−06158−00 Washer, Spherical, Male, 0.94 ID x 1.75 OD x 0.24 Thick 4
5 34−06159−50 Washer, Special, Belleville, 0.790/0.810 ID x 1.50 OD − SST 4
14.a STANDARD MOUNT FRAME ASSEMBLY
6 34−06157−00 Nut, Tee, 3/4−10 4
7 34−06151−01 Bolt, 3/4−10 x 3.00 Long − Steel, Grade 5 (Dacromet Coated) 4
14.b STANDARD MOUNT FRAME ASSEMBLY, EUROPEAN CHASSIS
6 34−06157−00 Nut, Tee, 3/4−10 4
14.c STANDARD MOUNT FRAME ASSEMBLY, QUICK MOUNTING
10 34−00363−18 Hex Nut, 3/4−10 4
11 68−12069−02 Plate, 11 Gage 2
12 62−10396−00 Label, Torque Bolt 4
T-343PL Rev C 56
15 BATTERY
4 2
3
1
2 5
3
11
15
16
10 9 6 ROUTE RED AND BLACK

7 BATTERY CABLES UNDER
8 TRUSS ASSEMBLY AND
THROUGH CUSHION
CLAMPS ON TOP OF
GENERATOR
17
14
16 12
13
18
1 34−06247−02 Bolt, Battery Hold Down 5/16−18 X 4.25 1
2 34−00667−12 Nut, Self Lock 5/16−18 2
3 34−00662−12 Washer, Plain 5/16 Medium 2
4 68−13945−01 Angle, Hold Down 1
5 34−06247−01 Bolt, Battery Hold Down 5/16−18 X 14.38 1
9 86−04444−00 Box Assembly 1
10 58−04503−00 Gasket 1
11 30−00358−02 Battery 12V Interstate 1
12 34−00372−43 Washer, Lock 3/8 1
13 34−06134−07 Nut, Hex M10 X 1.25 1
14 22−01633−20 Cable, Battery Negative Black 38.00 Long 1
15 22−01633−48 Cable, Battery Positive Red 44.00 Long 1
16 58−00848−12 Tube, Slit 1
17 66U1−3882 Wire Tie 8
57 T-343PL Rev C
16 WIRE HARNESS
4
1 5
2 FS ESS
6
3 7 8
9 EG
10
11
LOP 12
13
14
15
16
FH 17
18
19
BC 20
21
22
BC 23
24
25
26
SR 27
32
33
AR 34
28 35
29 36
LCS
30
31
16.a STANDARD
22−04162−00 Harness, Standard, Includes: 1
22−04162−01 Harness, Customer Specific, Includes:
22−04162−03 Harness, Customer Specific, Includes: 1
22−04162−04 Harness, Customer Specific, Includes:
FS Fuel Solenoid (FS) Connector − Includes:
1 22−50098−62 Connector, Female 1
2 22−50098−61C Plug, Rubber 2
3 22−50098−61B Cable Seal 2
T-343PL Rev C 58
16 WIRE HARNESS (Continued)
16.a STANDARD (Continued)
ESS Engine Speed Sensor (ESS) Connector − Includes:
4 22−50098−50 Connector 1
5 22−50098−50D Holder 1
6 22−50098−50A Terminal 3
7 22−50098−50E Cable Seal 3
EG Electronic Governor (EG) Module Connector − Includes:
8 22−50098−61A Terminal 10
9 22−50098−61 Plug Assembly 1
10 22−50098−61C Plug, Rubber 16
LOP Low Oil Pressure (LOP) Connector − Includes:
12 22−01756−01 Terminal 2
13 22−50078−51B Seal 2
14 22−50078−01A Lock, Secondary 2
FH Fuel Heater (FH) Connector − Includes:
16 22−01756−02 Terminal 2
17 22−50078−51C Seal 2
BC Battery Charger (BC) Connector − Includes:
19 22−01660−01 Plug 1
20 22−01613−20 Terminal 2
21 22−01660−08 Plug 1
BC Battery Charger (BC) Connector − Includes:
22 22−50078−39 Connector, Male 1
23 22−01756−00 Terminal 2
24 22−50078−51C Seal 2
SR Safety Relay (SR) Connector − Includes:
26 HY58AS151 Terminal 1
27 22−02245−04 Terminal 2
16.b AUTO RESTART (ALL OF 16.a AND ITEMS BELOW)
22−04162−02 Harness, Auto Restart Unit, Includes:
22−04162−05 Harness, Auto Restart Unit, Includes: 1
22−04162−07 Harness, Auto Restart Unit, Includes:
LCS Low Coolant Sensor (LCS) Plug − Includes:
28 22−50078−25 Connector, Male 1
29 22−50078−46A Terminal 3
30 22−50078−50A Seal 3
AR Auto Restart (AR) Module Connector Includes:
32 20−01613−25 Plug 1
33 22−01613−13 Terminal 3
34 22−01613−20 Terminal 6
35 22−01613−29 Lock, Secondary 1
36 20−01660−08 Plug 3
59 T-343PL Rev C
17 RETROFIT KITS
17.a UG 2 SPEED RETROFIT KIT
1 74−00287−00 Retrofit Kit UG 2 Speed Includes: 1
2 34−00665−09 Nut,Hex 10−32 1
3 62−02669−02 Label Ih/Ign/2Spd Switch 1
4 62−03957−04 Decal,Warning High Voltage 1
5 66U1−3882 Wire Tie 1/16−1−3/4 15
6 10−00475−00 Timer, Time Delay, 2Hr 1
7 66CH1−1002−89 Label Dt 1
9 22−04181−01 Wire Harness 1
10 62−11447−00 Label Start/Stop 2Spd, Std 1
11 62−11438−00 Label, Schematic 1
12 34−00658−10 Screw, Mach Hex Head 10−32 X 1−1/4 1
13 66U1−5321−8 Washer, Plain 10 Type A 2
14 66U1−5331−3 Washer, Lock 10 Spring 1
17.b UG T4i − CUSTOMER SPECIFIC 2 SPEED RETROFIT KIT
1 74−00291−00 Retrofit Kit T4I UG 2 Speed Includes: 1
2 34−00665−09 Nut,Hex 10−32 1
4 69GC15−3542 Bracket 1
5 66U1−3882 Wire Tie 1/16−1−3/4 15
7 66CH1−1002−89 Label 1
8 10−01129−15 Switch,Toggle 1 Pole 0ff/On 1
9 22−04181−04 Wire Harness 1
11 62−11441−00 Label, Schematic 69Ug T4I, 2Spd 1
12 34−00658−10 Screw,Mach Hex Head 10−32 X 1−1/4 1
17.c UG T4i PROVISIONED − CUSTOMER SPECIFIC 2 SPEED RETROFIT KIT
1 74−00295−00 Retrofit Kit T4I Provisioned 2 Speed Includes: 1
3 69GC15−3542 Bracket 1
8 34−00665−09 Nut, Hex #10−32 1
9 66CH1−1002−89 Label Dt 1
11 66U1−3882 Wire Tie 1/16−1−3/4 6
T-343PL Rev C 60
17.d UG T4i 2−SPEED − WITH FUEL WARMER RETROFIT KIT
1 74−00298−00 Retrofit Kit UG T4I 2 Speed W/Fuel Warmer Includes: 1
2 34−00665−09 Nut,Hex 10−32 1
5 58−00079−02 Sta−Strap 0−1.75 Inch Diameter Cable 15
6 10−00475−00 Timer Time Delay, 2Hr 1
7 66CH1−1002−89 Label Dt 1
9 22−04181−01 Wire Harness 1
11 62−11438−00 Label, Schematic 1
12 34−00658−10 Screw, Mach Hex Head 10−32 X 1−1/4 1
15 58−00658−03 Hose, Fuel 5/16 ID X 15 Inches Long 1
16 44−00045−25 Clamp, Hose 4
17 44−00317−00 Clip 1/2 To 5/8 Tee 1
21 30−00344−04 Fuel Warmer Diesel 1
22 44−00459−00 Clamp, Tube 1
23 34−00373−60 Clamp, Tube 3
24 58−04837−00 Hose, Formed 1
25 58−04838−00 Hose, Formed 1
26 44−00045−02 Clamp, Hose 4
27 58−00658−15 Hose, Fuel 5/16 ID X 11 inches Long 1
28 68−15848−00 Bracket, Fuel Warmer 1
29 34−01153−82 Bolt, Hex 2
31 34−01151−08 Washer, Flat M8 2
32 66U1−8292−1 Cap, Insulating 2
61 T-343PL Rev C
17.e UG T4i 2−SPEED − With FUEL WARMER & AUTO RESTART RETROFIT KIT
1 74−00300−00 Retrofit Kit UG T4I 2 Speed W/fuel Warmer Auto Restart Includes: 1
3 62−02973−06 Label Operating Mode,2Spd 1
4 62−03957−04 Decal,Warning High Voltage 1
7 66CH1−1002−89 Label Dt 1
9 22−04181−00 Wire Harness 1
10 62−11447−01 Label Start/Stop 2Spd,A/R 1
11 62−11440−00 Label,Schematic 69Ug Ar/Lcs/Ir,2Spd 1
12 62−02146−00 Decal,Warning Auto Start 1
13 66U1−5321−8 Washer,Plain #10 Type A 2
14 34−00665−09 Nut,Hex 10−32 1
15 66U1−5331−3 Washer,Lock 10 Spring 1
16 58−00658−03 Hose,Fuel 5/16 ID X 15 Inch Long 1
17 44−00045−25 Clamp,Hose 4
18 44−00317−00 Clip 1/2 To 5/8 Tee 1
19 66U1−5361−25 Screw,Cap Hex Head 1/4−20 X 0.75 inch 4
20 66U1−5321−7 Washer,Plain 1/4 W Type A 4
21 AU11JR171 Washer,Lock 1/4 Spring 4
23 44−00459−00 Clamp,Tube 1.69 Diameter Cushion 1
25 58−04837−00 Hose,Formed 1
26 58−04838−00 Hose,Formed 1
27 44−00045−02 Clamp,Hose 4
29 68−15848−00 Bracket Fuel Warmer 1
30 34−01153−82 Bolt, Hex 8Mm X 16Mm 2
32 34−01151−08 Washer, Flat M8 2
33 66U1−8292−1 Cap, Insulating 2
T-343PL Rev C 62
17.f UG T4i 2−SPEED − WITH FUEL WARMER − CUSTOMER SPECIFIC RETROFIT KIT
1 74−00302−00 Retrofit Kit UG T4i 2 speed W/ Fuel Warmer Includes: 1
2 34−00665−09 Nut,Hex 10−32 1
4 69GC15−3542 Bracket 1
7 66CH1−1002−89 Label Dt 1
9 22−04181−04 Wire Harness 1
10 62−11447−00 Label Start/Stop 2Spd,Std 1
11 62−11441−00 Label,Schematic 1
16 44−00045−25 Clamp,Hose 4
17 44−00317−00 Clip 1/2 To 5/8 Tee 1
18 66U1−5361−25 Screw, Cap Hex Head 1/4−20 X 0.75 Inch 4
23 34−00373−60 Clamp,Tube .81 Diameter Cushion 3
24 58−04837−00 Hose,Formed Fuel Warmer 1
26 44−00045−02 Clamp,Hose 4
29 34−01153−82 Bolt,Hex 8Mm X 16Mm 2
31 34−01151−08 Washer, Flat M8 2
32 66U1−8292−1 Cap,Insulating 2
63 T-343PL Rev C
17.g UG T4i 2−SPEED PROVISION − WITH FUEL WARMER − CUSTOMER SPECIFIC RETROFIT KIT
1 74−00303−00 Retrofit Kit UG T4I 2 Speed Provision W/ Fuel Warmer: 1
3 69GC15−3542 Bracket 1
7 66U1−5331−3 Washer,Lock 10 Spring 1
8 34−00665−09 Nut,Hex 10−32 1
9 66CH1−1002−89 Label Dt 1
10 62−11447−00 Label Start/Stop 2Spd,Std 1
11 58−00079−02 Sta−Strap 0−1.75Inch Diameter Cable 6
13 44−00045−25 Clamp,Hose 4
14 44−00317−00 Clip 1/2 To 5/8 Tee 1
15 66U1−5361−25 Screw, Cap Hex Head 1/4−20 X 0.75 Inch 4
20 34−00373−60 Clamp,Tube .81 Diameter Cushion 3
23 44−00045−02 Clamp,Hose 4
26 34−01153−82 Bolt,Hex 8Mm X 16Mm 2
28 34−01151−08 Washer, Flat M8 2
T-343PL Rev C 64
PART NUMBER INDEX
PART NO. PAGE NO. PART NO. PAGE NO. PART NO. PAGE NO
22−04181−01 60, 61
0 2
22−04181−04 60, 63
02−00083−00 7 20−01613−25 59
22−04225−00 39
04−50012−00 7 20−01660−08 59
22−50078−01A 59
22−00049−00 25
22−50078−02 59
22−00518−01 25
1 22−00519−01 25
22−50078−24A 59
22−50078−25 59
10−00158−02 5 22−00538−01 27, 31
22−50078−39 59
10−00171−12 23, 25, 27 22−00538−01SV 23, 25, 29
29, 31 22−50078−39A 59
22−01030−54 23, 25, 27
10−00171−13 23, 25, 27 29, 31 22−50078−46A 59
29, 31 22−50078−50A 59
22−01286−00 40
10−00286−02 25 22−50078−51B 59
22−01613−13 59
10−00286−03 23, 27, 29 22−50078−51C 59
31 22−01613−20 59
22−01613−29 59 22−50098−50 59
10−00328−00 23, 25, 27
29, 31 22−01633−20 57 22−50098−50A 59
10−00365−00 23, 25, 27 22−01633−48 57 22−50098−50D 59
29, 31 22−50098−50E 59
22−01660−01 59
10−00365−10 23, 25, 27 22−50098−61 59
29, 31 22−01660−08 59
22−01679−00 37, 39 22−50098−61A 59
10−00375−01 25
22−01679−02 37, 39 22−50098−61B 58
10−00448−00 23, 25, 26
29, 31 22−01756−00 59 22−50098−61C 58, 59
10−00469−00 23, 27, 29 22−01756−01 59 22−50098−62 58
31 22−50206−00 7
22−01756−02 59
10−00475−00 27, 31, 60 26−00128−04 5
61, 62, 63 22−01839−00 41
64 22−01942−01 43
10−01129−13 23, 29 22−01946−00 43 3
10−01129−14 27, 31 22−01986−00 39
30−00344−04 10, 61, 62
10−01129−15 27, 31, 60 22−01986−01 39 63, 64
61, 62, 63
64 22−02200−06 23, 25, 27 30−00356−00 11
29, 31
10−01129−18 25 30−00358−02 57
22−02205−00 35
10−01129−19 23, 27, 29 30−00373−02 9
31 22−02245−04 59
30−00397−00 21
12−00097−03 22, 24, 27 22−02302−04 33, 37, 38
40, 41 30−00406−01 12
29, 31
22−04162−00 58 30−00426−05 12
12−00098−04 5
22−04162−01 58 30−00426−25 12
12−00477−02 25
22−04162−02 59 30−00446−00 12
12−00592−00 5
22−04162−03 58 30−00472−00 18
12−00641−00 21
22−04162−04 58 30−00473−04 11
12−01098−04 13, 14, 15
16, 17 22−04181−00 62 30−00473−20 11
Index−1 T-343PL Rev C

PART NUMBER INDEX
30−01101−07 9 34−00829−13 5 34−06151−00 56
34−00304−08 7 34−00829−15 5 34−06151−01 56
34−00363−18 56 34−00833−28 5 34−06151−02 56
34−00372−41 23, 25, 27 34−00890−10 5 34−06157−00 56
29, 31, 33 34−00928−01 23, 25, 27 34−06158−00 56
38 49
34−06158−21 56
34−00372−43 57 34−00928−02 5, 49, 55
34−06159−50 56
34−00373−58 9 34−00928−05 53
34−06169−00 53, 55
34−00373−60 10, 61, 62 34−00928−10 9, 12
63, 64 34−06212−12 43
34−00928−13 45, 47, 49
34−00655−04 7, 41 51, 53, 55 34−06247−01 57
34−00655−06 7, 43 34−00928−14 13, 14, 15 34−06247−02 57
34−00655−08 33, 43 16, 17, 45 34−06278−00 7
47, 49, 51
34−00655−12 7 55 34−06280−20 6
34−00658−10 60, 61, 62 34−00932−13 18
63
34−00662−12 57
34−00945−06 5 4
34−00964−00 18
34−00662−15 13, 14, 15 40−00067−01 5
34−01142−01 49, 55
16, 17 40−00081−00 21
34−01145−06 33
34−00663−11 43 40−00107−01 5
34−01146−08 6, 10, 33
34−00665−09 37, 38, 40 61, 62, 63 40−00117−01 21
41, 60, 61 64
62, 63, 64 40−00342−01 13, 14, 15
34−01146−12 18, 33 16
34−00666−08 23, 25, 27
29, 31 34−01151−08 5, 10, 33 40−00342−03 13, 14, 15
61, 62, 63 16, 17
34−00667−05 23, 25, 27 64
29, 31 40−00342−09 17
34−01151−12 18, 33 40−00345−04 9
34−00667−07 23, 25, 27
29, 31 34−01153−15 5, 10 40−00506−00 12
34−00667−11 9, 11, 12 34−01153−82 61, 62, 63 40−00566−00 5
23, 25, 27 64
29, 31, 33 40−00671−00 9
34−01155−20 33
38 42−00174−42 45, 47, 49
34−01155−25 18 51, 55
34−00667−12 33, 57
34−01159−02 23, 25, 27 42−00174−43 45, 47, 49
34−00667−13 5, 6
34−01226−00 45, 49 51, 55
34−00667−15 5, 13, 14
15, 16, 17 34−06003−08 45, 47, 49 42−00174−45 45
51
34−00795−09 23, 27, 29 42−00174−51 18
31, 51 34−06026−02 56
42−00269−06 22, 24, 26
34−00795−17 5 34−06053−03 45, 49
42−00269−08 28, 30
34−00804−18 5 34−06060−01 5
42−00269−09 28, 30
34−00807−08 5 34−06060−02 5
42−00269−10 55
34−06107−00 45
34−00807−10 6, 45, 47 42−00309−00 22, 24, 26
49, 51 34−06134−07 57
42−00324−00 37, 38, 40
34−00807−12 5 34−06136−01 41 41
T-343PL Rev C Index−2

PART NUMBER INDEX
42−00348−00 7, 33 58−00065−46 9
6
42−00481−00 25 58−00065−76 9
42−00483−00 53 58−00079−02 10, 61, 62 62−02146−00 35, 62
63, 64 62−02181−01 13, 14, 15
42−00484−00 53
58−00412−01 13, 14, 15 16, 17
42−00508−00 43
58−00412−37 16, 17 62−02669−01 23, 29
42−00509−01 43
58−00658−03 61, 62, 63 62−02669−02 27, 31, 60
42−01096−01 23, 25, 27 61, 63, 64
64
42−01133−00 9 62−02670−00 40
58−00658−15 10, 61, 62
42−50010−00 7 63, 64
62−02670−01 40
44−00045−02 10, 61, 62 58−00659−03 9
63, 64 62−02700−03 40
58−00848−02 9
44−00045−25 9, 10, 61 62−02718−02 13, 14, 15
62, 63, 64 58−00848−12 57 16, 17
44−00102−52 9 58−00848−20 21 62−02785−00 35

44−00102−54 9, 33, 41 58−00969−00 9, 21 62−02895−00 35
57 58−01097−00 35 62−02948−00 37, 38, 41
44−00102−56 33 58−01183−10 13, 14, 15 62−02972−00 35
44−00102−59 33 16
62−02973−04 25
44−00317−00 10, 61, 62 58−01183−11 13, 14, 15
63, 64 62−02973−06 62
58−01183−12 17
44−00352−00 45, 47, 49 62−03882−07 13, 14, 15
58−01183−13 16, 17
51, 55 16, 17
58−01206−12 9
44−00388−00 21 62−03957−04 23, 25, 27
58−04015−01 13, 14, 15 29, 31, 35
44−00399−00 53 53, 60, 61
58−04015−04 16, 17
44−00401−00 45, 47, 51 62
55 58−04026−32 23, 25, 27
62−10387−01 25
44−00431−00 14, 16 58−04102−03 12
62−10391−01 35
44−00447−00 11 58−04184−01 21
62−10395−01 35
44−00454−00 12 58−04215−00 21
62−10396−00 56
44−00459−00 10, 61, 62 58−04246−02 33
63, 64 62−10530−02 25
58−04321−16 9
48−00392−00 7 62−10530−25 23, 27, 29
58−04321−29 9 31
48−00405−00 14, 16
58−04389−00 45 62−10572−01 35
58−04428−00 53
62−10573−00 13, 14, 15
5 58−04503−00 57 16, 17
58−04585−00 21 62−10903−00 21
50−60330−03 5
58−04780−00 12 62−10925−00 35
54−00576−03 5, 7
58−04780−01 11 62−11006−00 35
54−50039−00 7
58−04784−00 21 62−11138−00 35
54−50045−00 7
58−04837−00 10, 61, 62 62−11302−00 35
54−50083−00 7
63, 64
54−50084−00 7 62−11417−00 35
58−04838−00 10, 61, 62
54−50085−00 7 63, 64 62−11438−00 60, 61

PART NUMBER INDEX
62−11439−00 35 66U1−2823−3 5 66U1−5371−14 33
62−11440−00 62 66U1−3662−21 23, 25, 27 66U1−5371−6 22, 24, 26
29, 31 28, 30, 33
62−11441−00 60, 63
37, 38, 40
62−11447−00 60, 61, 63 66U1−3803−1 33
66U1−5371−8 11
64 66U1−3863−1 40
66U1−5371−9 53
62−11447−01 35, 62 66U1−3882 9, 13, 14
65−00131−02 13, 14, 15 15, 16, 17 66U1−6651−15 23, 25, 26
16, 17 23, 25, 27 29, 31
29, 31, 33 66U1−6811−12 45, 49
65−00164−01 13, 14, 15 45, 57, 60
16, 17 66U1−6811−8 53, 55
66U1−5321−17 6
65−00178−51 13, 14, 15 66U1−7842−11 37, 38, 41
66U1−5321−2 23, 25, 27
65−00178−52 13 29, 31 66U1−7842−6 37, 40, 41
65−00187−81 16 66U1−5321−3 5, 7, 11 66U1−7842−7 37, 38, 40
65−00187−83 17 12, 18, 23 41
25, 27, 29,
66CH1−1002−132 23, 25, 27 66U1−7842−8 40
31, 33, 40
29, 31 41, 45, 47 66U1−8292−1 61, 62, 63
66CH1−1002−38 23, 25, 27 49, 51
66U1−8472−3 41
29, 31 66U1−5321−4 33
66U1−8772 33
66CH1−1002−5 23, 25, 27 66U1−5321−5 9, 18, 45
29, 31 47, 49, 51 66U1−9042 35
66CH1−1002−89 27, 31, 60 57 66U1−9132 12
61, 62, 63 66U1−5321−7 9, 10, 21 66U1−9592−13 23, 25, 27
64 38, 45, 47 29, 31
66CH1−1022−5 40, 43 49, 51, 61
62, 63, 64 66U1−9752 23, 25, 27
66CH1−1092−4 37, 38, 40 29, 31
41 66U1−5321−8 22, 24, 26
28, 30, 33 66U2−1132 33
66CH1−1172−102 18 37, 38, 40 66U2−1391−1 37, 38, 40
66CH1−1172−26 21 41, 51, 60 41
61, 62, 63
66CH1−1172−50 5 64 68−11862−01 56
66CH1−1172−51 5 66U1−5321−9 5 68−11876−00 13, 14, 15
66CH1−1172−94 5 17
66U1−5331−3 22, 24, 26
66CH1−153−86 41 29, 30, 33 68−11899−00 5
37, 38, 40 68−11900−00 5
66CH1−163−26 9 41, 60, 61
66CH1−163−27 9 62, 63, 64 68−11901−00 5
66CH1−163−31 9 66U1−5331−4 23, 25, 27 68−11903−07 13, 15

29, 31 68−11903−08 14
66HC1−1002−18 25
66U1−5331−8 5 68−11928−07 22
66U1−1251−2 41
66U1−5361−25 5, 9, 10 68−11928−08 24
66U1−2552 45, 47, 49 12, 18, 21
51 33, 40, 45 68−11928−09 26
66U1−2552−173 45, 47, 49 47, 49, 51
68−12010−00 5
51, 55 61, 62, 63
64 68−12069−02 56
66U1−2583−45 33
66U1−5361−36 5 68−12082−01 45
66U1−2823 23, 25, 27
29, 31 66U1−5361−7 9, 57 68−12082−02 45, 47, 49

PART NUMBER INDEX
68−12082−03 51, 55 68−15492−01 49
8
68−12513−00 21 68−15492−02 45
81−01379−01 21
68−12814−01 49 68−15492−03 51
68−15522−00 45, 47, 49 81−04042−01 21
68−12814−02 45, 47, 51
55 51 86−04119−01 45, 47, 49
68−12973−00 29, 31 68−15575−00 49 51
68−13439−00 53 68−15602−00 9 86−04136−03 41
68−13439−02 53 68−15848−00 10, 61, 62 86−04152−02 37, 38

63, 64 86−04152−03 40
68−13441−00 23, 25, 27
69GC−15−3812 31 86−04152−05 39
68−13791−00 43
69GC15−3542 31, 60, 63 86−04377−00 24
68−13794−01 43 64
68−13945−01 57 86−04430−01 43
69GC15−3812 23, 25, 27
68−14126−00 21 86−04444−00 57
69GS4−1582−1 23, 25, 26
68−14252−00 49 29, 31 86−04524−01 5
68−14266−00 37, 38 69GS4−1702 21 86−04597−00 45
68−14266−01 40, 41 69NT35−2692−1 21 86−04679−02 30
68−14266−02 39 69NT41−982−2 23, 25, 27 86−04687−00 6
29, 31, 38
68−14535−00 45, 47, 51 86−04706−00 22, 28
55
86−04706−02 26
68−14535−01 49 7
68−14535−02 45
73−00175−01 5
68−14698−01 7 9
73−00198−01 5
68−14699−01 7 91−00320−00 37, 38
73−00205−00 6
68−14709−00 45, 47, 49
74−00287−00 60 91−00320−01 40
51
74−00291−00 60 91−00320−04 41
68−14809−00 6
74−00295−00 60 91−00320−06 39
68−14812−00 6
68−14858−01 16, 17 74−00298−00 61 91−00320−08 39
68−14871−0 16 74−00300−00 62 91−00320−09 39
68−15029−00 45, 51 74−00302−00 63 91−00334−01 43
68−15029−01 47, 49 74−00303−00 64 91−00387−01 28
68−15029−03 55 76−00663−10 47, 49, 51 91−00387−02 30

55
68−15034−00 45 91−00400−00 22
76−00663−12 45
68−15037−00 18 91−00400−01 24
76−00663−14 55
68−15038−00 18 91−00400−02 26
76−00803−00 45
68−15467−00 28 91−00406−00 39
76−50110−00 7
68−15467−01 30 91−00406−01 39
79−01795−00 45, 47, 49
68−15486−00 55 51, 53 91−00415−00 39
68−15491−00 12 79−01795−01 53 91−00415−02 39
68−15492−00 47, 55 79−01909−06 35 91−00415−03 39

PART NUMBER INDEX
AU11JR241 5, 9, 45
A 47, 49, 51
H
57
HY58AS151 59
AT39QA132 23, 25, 27 AU51YA−012 16
29, 31
AU51YA012 14 K
AU−11JR2−41 6
AU53VA061 45, 53 KA69JM824 21
AU11JR−171 33, 45, 47 KA69JM840 11, 12
49 KK71EW−223 31
KK71EW223 23, 24, 27
AU11JR171 7, 9, 10
18, 21, 40
C 29
41, 51, 61 KK71GW007 23, 25, 27
62, 63, 64 CA61JA151 5 31

Carrier Transicold Division,
Carrier Corporation
Container Products Group
P.O. Box 4805
Syracuse, N.Y. 13221 U.S A
A member of the United Technologies Corporation family. Stock symbol UTX www.carrier.transicold.com
©2010 Carrier Corporation D Printed in U. S. A. 05/14

Diesel Generator Set: T 343PL Rev C

Uploaded by

Copyright:

Available Formats

Diesel Generator Set: T 343PL Rev C

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Diesel Generator Set: T 343PL Rev C

Uploaded by

Copyright:

Available Formats

Diesel Generator Set

SERVICE PARTS LIST

PARAGRAPH NUMBER Page

MANUAL/ ENGINE EQUIPMENT TYPE OF

MODEL AND PRODUCT IDENTIFICATION (PID) NUMBERS

CARRIER TRANSICOLD DIVISION

PAINT COLOR PART NO.

Overview of the new numbering system:

Panels & Doors

Panels & Doors

Panels & Doors

Panels & Doors

Item Part Number Description Qty

Item Part Number Description Qty

OIL BATH AIR FILTER (4.a)

6.b ONLY 6.b ONLY

Item Part Number Description Qty

8.c ONLY 8.d AND 8.e ONLY

CONTROL PANEL CONTROL BOX

Item Part Number Description Qty

Item Part Number Description Qty

CONTROL PANEL 3 CONTROL BOX

Item Part Number Description Qty

Item Part Number Description Qty

Item Part Number Description Qty

Item Part Number Description Qty

Item Part Number Description Qty

OPTION 14.a AND 14.b OPTION 14.c

Item Part Number Description Qty

10 9 6 ROUTE RED AND BLACK

Index−1 T-343PL Rev C

T-343PL Rev C Index−2

44−00102−52 9 58−00848−20 21 62−02785−00 35

Index−3 T-343PL Rev C

66CH1−163−31 9 66U1−5331−4 23, 25, 27 68−11903−07 13, 15

T-343PL Rev C Index−4

68−13439−00 53 68−15602−00 9 86−04136−03 41

68−13439−02 53 68−15848−00 10, 61, 62 86−04152−02 37, 38

68−14871−0 16 74−00300−00 62 91−00320−09 39

68−15029−00 45, 51 74−00302−00 63 91−00334−01 43

68−15029−01 47, 49 74−00303−00 64 91−00387−01 28

68−15029−03 55 76−00663−10 47, 49, 51 91−00387−02 30

Index−5 T-343PL Rev C

T-343PL Rev C Index−6

You might also like