BASIC - 1

GENERAL DESCRIPTION OF CCPP

PUBLIC INTERNE LIMITE CONFIDENTIEL

1
INDEX
Chapitre 1 Introduction

Chapitre 2 Operating Parameters

Chapitre 3 General Description of CCPP

General View
Chapitre 4
Chapitre 5 Configuration of Plant

Chapitre 6 Principal Equipment

BASIC - 1 2
INTRODUCTION
The purpose of this session is to provide an overview of the 1131.1 MW RAS-DJINET DE Combined Cycle
Power Plant.

The RAS DJINET plant consists of three (3) single-shaft combined cycle power plant (CCPP) modules as
well as Balance of Plant (BOP) Equipment.

Each module of the CCPP has one (1) gas turbine (model: SIEMENS SGT5-4000F), one (1) associated
HRSG, one (1) steam turbine (Model: SIEMENS SST5-3000 H-IL ) and a common hydrogen-cooled
generator (Model: SIEMENS SGEN 5-2000 H) located on the same shaft between the gas turbine (GT) and
the steam turbine (ST).

Gas turbines are designed to burn natural gas as the base fuel and diesel fuel as the backup fuel.

HOW A COMBINED CYCLE POWER PLANT

WORKS

BASIC - 1 3
OPERATING PARAMETERS

• Reference Conditions
− Ambient Temperature : 35 0C

− Relative Humidity : 76%

− Barometric Pressure : 1.01

− Frequency : 50 Hz

− Fuel Gas Lower Heating Value : 45001.3 KJ/Kg

− Fuel Oil Lower Heating Value : 43100.0 KJ/Kg

− Generator Terminal Power Factor : Lagging 0.9

− Cycle Make-up : 0%

− HRSG Blow Down : 0%

BASIC - 1 4
OPERATING PARAMETERS

• Various Plant operating parameters at above reference conditions and at 100% load are as follows.
Description Units With Natural Gas Firing With Oil Firing
Net Power Output of each block MW 377 311.3
Net Plant Heat Rate KJ/Kwh 6165 6599
Gas turbine Power Output MW 249.2 210.5
Steam Turbine Power Output MW 127.8 100.8
Fuel Consumption kg/s 14.3 13.24
Exhaust gas temperature 0
C 607.6 557.4
Exhaust gas flow kg/s 616.2 610.9
HP Super Heater Outlet Pressure Bar (a) 120.81 101.81
HP Superheater Outlet Temperature 0
C 566.50 530.10
HP Steam Turbine Inlet Pressure Bar (a) 117.92 99.39
HP Steam Turbine Inlet Temperature 0
C 565.02 528.27

BASIC - 1 5
OPERATING PARAMETERS
Description Units With Natural Gas Firing With Oil Firing
HP Steam Flow kg/s 71.99 61.66
Reheater Outlet Pressure Bar (a) 29.91 25.91
Reheater Outlet Temperature C
0
565.70 526.20
IP Steam Turbine Inlet Pressure Bar (a) 29.10 25.20
IP Steam Inlet Turbine C
0
564.94 524.99
Temperature
IP Steam Flow kg/s 71.99 76.02
IP Superheater Outlet Pressure Bar (a) 31.31 27.11
IP Superheater Outlet Temperature C
0
337.50 324.30
LP Superheater Outlet Pressure Bar (a) 4.51 4.21
LP Superheater Outlet Temperature C
0
232.60 237.70
LP Superheater Outlet Steam Flow kg/s 10.14 2.58
LP Turbine Exhaust Flow kg/s 98.25 80.31
LP Turbine Exhaust Temperature C
0
33.35 31.56

BASIC - 1 6
OPERATING PARAMETERS

Description Units Parameters (With Natural Gas Parameters (With Oil Firing)
Firing)
HP Economizer Inlet Flow Kg/s 71.99 61.66
IP Economizer Inlet Flow Kg/s 23.57 17.03
Condenser Back Pressure Bar (a) 0.0514 0.0464
Condenser Cooling Water Inlet C
0
24 24
Temperature
Condenser Cooling Water Outlet C
0
30 28.63
Temperature

BASIC - 1 7
GENERAL DESCRIPTION OF CCPP

EXISTING

EXISTING

BASIC - 1 8
 GENERAL DESCRIPTION OF CCPP
VIEW OF RDPP
EXISTING POWER PLANT
UNIT#70 UNIT#60 UNIT#50

400 kV GIS

TURBINE BUILDING HRSG CHIMNEY

BASIC - 1 9
GENERAL DESCRIPTION OF CCPP – VIEW OF ST, GENERATOR, GT & HRSG

Condensor

Chimney

BASIC - 1 10
GENERAL VIEW (GAS TURBINE -GENERSTOR – STEAM TURBINE)
AIR INLET
STEAM FILTER
GENERAL VIEW OF ONE
TURBINE
UNIT (GAS TURBINE -
GENERSTOR – STEAM
TURBINE ETC.)

GAS
TURBINE

GENERATOR
TO
HRSG

BASIC - 1 11
GENERAL VIEW (GAS TURBINE -GENERSTOR – STEAM TURBINE)

 Generator is connected with Gas Turbine with direct coupling

 Generator is coupled with Steam Turbine through « Self Shifting & Synchronising »-
(SSS) Clutch
BASIC - 1 12
GENERAL VIEW (GAS TURBINE -GENERSTOR – STEAM TURBINE)
GENERATEUR
TURBINE À VAPEUR
(IP & LP) CONDENSEUR

CLUTCH
TURBINE À GAZ

TURBINE À VAPEUR
(HP)

BASIC - 1 13
PLANT CONFIGURATION

BASIC - 1 14
PLANT CONFIGURATION

PLEASE KLICK ON THE LINK FOR OVERALL CONFIGURATION

BASIC - 1 15
MAIN EQUIPMENT
Followings are the Main Equipment of CCPP

Sr. No. Equipment Sr. No. Equipment

1 GAS Turbine (GT) 9 Circulating Cooling water System
2 Steam Turbine (ST 10 Closed Circuit Cooling Water
System
3 Single Shaft Generator 11 Condensate Extraxtion Pump
4 HRSG 12 Boiler (HRSG) Feed Pump
5 Chimney 13 Auxiliary Boiler
6 Bypass Valves HP, IP et LP 14 Fuel Oil Pump
7 Condensor 15 Fuel Oil Storage Tanks
8 Steam Jet Ejector 16 Transformer

BASIC - 1 16
MAIN EQUIPMENT

Sr. No. Equipment Sr. No. Equipment

1 Natural Gas System 8 Chemical Dosing System
2 Black Start Diesel Generator (BSDG) 9 Steam Water Analysis System
3 400 kV Gas Insulated Substation (GIS) 10 Generator Circuit Breaker (GCB)

4 Electric Overhead Crane 11 Desalinated Water System

5 Compressed Air System 12 Auxiliary Cooling sytem

6 Water Treatment System 13 Electrical Systems

7 Waste Water Treatment System 14 DCS

BASIC - 1 17
Restons en
contact

Façonner notre monde

tractebel-engie.com