N-03453 - 2023-11-11 - AD Status - ESN V12884 - AD ESN V12884 A595

AIRWORTHINESS 11.Nov.
2023
DIRECTIVE ESN V12884 Page 1/11
For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Selection: AIRWORTHINESS DIRECTIVE
Document-Number Type Rev Compliance A|C Subject Status

2000-11-25 AD 00 Mandatory COMP FMU COMMON FLOW Not Applicable
Complete document sign-up hierarchy
2000-11-25/AD Rev.00 FMU COMMON FLOW Not Applicable
> V2500- ENG-73-0150/SB* FUEL METERING UNIT-INTRODUCTION OF A LUCAS FUEL METERING UNIT WITH Not Applicable
Rev.00 REVISED MAXIMUM FUEL FLOW STOP
> V2500−ENG−73−0157/SB* FUEL METERING UNIT - INTRODUCTION OF A WOODWARD GOVERNOR;COMPANY Not Applicable
Rev.00 FUEL METERING UNIT WITH REVISED MAXIMUM FUEL FLOW STOP
2000-22-07 AD 00 Mandatory COMP ENGINE - HIGH PRESSURE TURBINE MODULE - REMOVAL FROM SERVICE Not Applicable
Remarks
Applicability: International Aero Engines AG (IAE) V2500-A5 and -D5
series turbofan engines
listed by Serial Number (S/N) as follows:
V10011 V10054 V10121 V10166 V10341 V20023
V10035 V10067 V10123 V10172 V20001 V20033
V10036 V10079 V10124 V10174 V20013 V20037
V10039 V10080 V10130 V10180 V20017
V10040 V10084 V10131 V10199 V20019
V10041 V10111 V10139 V10221
2000-22-07/AD Rev.00 ENGINE - HIGH PRESSURE TURBINE MODULE - REMOVAL FROM SERVICE Not Applicable
> V2500-ENG-72-0242/VSB* HP TURBINE ROTOR AND STATOR ASSEMBLY - PROVIDE NEW STAGE 1 HPT BLADES Not Applicable
Rev.00
2003-11-23 AD 00 Mandatory COMP SUPERSEDED BY FAA AD 2006-25-01 Superseded (Not Applicable)

Replacement Information
This Document has been SUPERSEDED BY 2006-25-01/AD Rev.00
2003-231-IMP AD 02 Mandatory COMP SUSPECT #3 BEARING FAILURE Not Applicable
2004-12-08 AD 00 Mandatory COMP TIME LIMITS / MAINTENANCE CHECKS - CRITICAL LIFE-LIMITED PARTS Open (Next Shop Visit)
produced by AMOS www.swiss-as.com

AIRWORTHINESS 11.Nov.2023


This Document SUPERSEDES 2000-12-05/AD Rev.00
Due Dim1 (D) Due Dim2 Due Dim3 New W/O Time-Requirement of Document
No limit
2005-0012 AD 01 Mandatory COMP ENGINE OIL - FUEL COOLED OIL COOLER FILTER COVER - INSPECTION / MODIFI Not Applicable
2005-0012/AD Rev.01 ENGINE OIL - FUEL COOLED OIL COOLER FILTER COVER - INSPECTION / MODIFI Not Applicable
> V2500-ENG-79-0086/VSB* ENGINE OIL - FUEL COOLED OIL COOLER FILTER COVER - INSPECTION / MODIFI Not Applicable
Rev.00
2006-07-05 AD 00 Mandatory COMP ENGINE - FORWARD MOUNT BOLT Not Applicable

Reason for this Status
N.A due to ESN
2006-25-01 AD 00 Mandatory COMP ENGINE - MASTER MAGNETIC CHIP DETECTOR / BEARING / HIGH PRESSURE COMPR Not Applicable
2006-25-01/AD Rev.00 ENGINE - MASTER MAGNETIC CHIP DETECTOR / BEARING / HIGH PRESSURE COMPR Not Applicable
> V2500−ENG−72−0452/VSB* ENGINE - MAGNETIC CHIP DETECTOR (MCD) INSPECTIONS FOR ENGINES FROM Not Applicable
Rev.04 V10600 TO V11365 WITH PN 2A1165 (FAG) NUMBER 3 BEARINGS INSTALLED
> V2500−ENG−72−0459/VSB* ENGINE - IN SHOP ACTION FOR ENGINES V10600 TO V11365 WITH P/N 2A1165 (FAG) Not Applicable
Rev.04 NUMBER 3 BEARINGS INSTALLED
> V2500−ENG−72−0460/VSB* IN SHOP ACTION FOR ENGINES IN THE RANGE V10600 TO V11304- P/N 2A1170 NUMBER Not Applicable
Rev.02 3 BEARINGS WITH A LOW ENERGY STANDARD OF HPC HARD FACE
2007-21-05 AD 00 Mandatory COMP N2 VIBRATION MONITORING - HIGH PRESSURE TURBINE STAGE 2 AIR SEALS REPL Not Applicable
Remarks



This AD applies to International Aero Engines (IAE) model V2500-A1,
V2522-A5, V2524-A5, V2527-A5, V2527E-A5, V2527M-A5, V2530-A5,
V2533-A5, V2525-D5, and V2528-D5 turbofan engines with high pressure
turbine (HPT) stage 2 air seals, part numbers (P/Ns) 2A0487,
2A1159, 2A1160, 2A3108, 2A3179, 2A3185, 2A3425, and 2A3596,
installed.
NA DUE TO NOT INSTALLED AFFECTED PART NUMBER, INSTALLED HPT STG 2 AIR
SEAL P/N 2A4157
2008-14-15 AD 00 Mandatory COMP NO. 4 BEARING OIL SYSTEM COMPONENTS - REMOVAL FROM SERVICE Not Applicable
2008-14-15/AD Rev.00 NO. 4 BEARING OIL SYSTEM COMPONENTS - REMOVAL FROM SERVICE Not Applicable
> V2500−ENG−72−0541/VSB* V2500-A1/A5/D5 SERIES PROPULSION SYSTEMS NON-MODIFICATION SERVICE Not Applicable
Rev.04 BULLETIN
2008-25-06 AD 00 Mandatory COMP A319/A320/A321 A/C POWERED;WITH V2500-A1 AND V2500-A5;ENGINE AFT MOUNT Not Applicable
BARREL NUT;INCORRECT P/N IN AIRBUS IPC
N/A DUE TO BARREL NUT P/N 92707-1612 INSTALLED
2009-22-06 AD 00 Mandatory COMP HIGH-PRESSURE COMPRESSOR (HPC) STAGE 9-12 DISC ASSEMBLY Not Applicable
N.A due to P/N not affected
2010-06-18 AD 00 Mandatory COMP ENGINES - VORTEX REDUCERS - INSPECTION Not Applicable

2010-20-07 AD 00 Mandatory COMP SUPERSEDED BY FAA AD 2012-09-09 Superseded (Superseded)




2011-25-08 AD 00 Mandatory COMP ENGINES - HIGH-PRESSURE TURBINE (HPT) AIR SEAL INSPECTION / INSTALLATION Ex Factory
2011-25-08/AD Rev.00 ENGINES - HIGH-PRESSURE TURBINE (HPT) AIR SEAL INSPECTION / INSTALLATION Ex Factory
> V2500−ENG−72−0580/VSB* BORESCOPE INSPECTION OF HIGH PRESSURE TURBINE (HPT) STAGE 1 DUCT Ex Factory
Rev.04 SEGMENTS
complied at Factory on 27-MAR-2008
2012-09-09 AD 00 Mandatory COMP SUPERSEDED BY FAA AD 2015-10-04 Superseded (Superseded)

2015-10-04 AD 00 Mandatory COMP ENGINE - HIGH-PRESSURE COMPRESSOR (HPC) STAGE 3 TO 8 DRUMS INSPECTIONS / Performed by prev. Operator
REPLACEMENT
2015-10-04/AD Rev.00 ENGINE - HIGH-PRESSURE COMPRESSOR (HPC) STAGE 3 TO 8 DRUMS INSPECTIONS / Performed by prev. Operator
REPLACEMENT
> V2500-ENG-72-0632/VSB* ENGINE — HIGH PRESSURE (HP) COMPRESSOR DISCS INTRODUCTION;OF SILVER FREE Performed by prev. Operator
Rev.01 NUTS
Perf Dim1 (D) Perf Dim2 Perf Dim3 W/O Remarks
PerfRev.:'01' / Reason: PERFORMED BY
PREV. OPERATOR 04/06/2014 / Return
04.Jun.2014 36965:34/H 25'491/C
Information: PERFORMED BY PREV.
OPERATOR 04/06/2014



PERFORMED BY PREV. OPERATOR 04/06/2014
> V2500-ENG-72-A0615/VSB* NMSB-HIGH PRESSURE (HP) COMPRESSOR;— STAGE 3 TO 8 COMPRESSOR DRUM Performed by prev. Operator
Rev.09 ULTRASONIC INSPECTION (USI) FOR STRESS;CORROSION CRACKING
Was due at: 20'451/C and 31.Dec.2025
PerfRev.:'09' / Reason: CW SB 72-0632 ON
30.Oct.2017 29573:00/H 19'999/C
25-JAN-2019 / Return Information: CW SB
72-0632 ON 30-OCT-2017
CW SB 72-0632 ON 30-OCT-2017
2016-18-10 AD 00 Mandatory COMP ENGINE - HIGH-PRESSURE TURBINE STAGE 1 & STAGE 2 HUBS INSPECTION Not Applicable
2016-18-10/AD Rev.00 ENGINE - HIGH-PRESSURE TURBINE STAGE 1 & STAGE 2 HUBS INSPECTION Not Applicable
> V2500-ENG-72-0661/VSB* NMSB- ENGINE — STAGE 1 AND STAGE 2 HPT HUB —;OVER INSPECTION FOR Not Applicable
Rev.05 MANUFACTURING DEFECTS
NA DUE TO NOT INSTALLED AFFECT PN, HPT STG1 HUB PN 2A5001 SN PKLBRK8352,
HPT STG2 HUB PN 2A4802 SN PKLBRL7159
2016-25-11 AD 00 Mandatory COMP ENGINE - NO. 3 BEARING INSPECTION / REMOVAL Not Applicable
2016-25-11/AD Rev.00 ENGINE - NO. 3 BEARING INSPECTION / REMOVAL Not Applicable
> V2500-ENG- 72-0671/VSB* NMSB - NO. 3 BEARING — REDUCED MASTER MAGNETIC CHIP DETECTOR Not Applicable
Rev.00 INSPECTION INTERVAL FOR SUSPECT POPULATION (LOT A
2017-14-07 AD 00 Mandatory COMP TURBINE ENGINE - HIGH-PRESSURE TURBINE (HPT) REPLACEMENT Not Applicable
2017-14-07/AD Rev.00 TURBINE ENGINE - HIGH-PRESSURE TURBINE (HPT) REPLACEMENT Not Applicable



> V2500-ENG-72-0676/VSB* NON-MODIFICATION SERVICE BULLETIN - HIGH PRESSURE TURBINE; STAGE 2 AIR Not Applicable
Rev.00 SEAL - REPLACEMENT OF
NA DUE TO NOT INSTALLED AFFECTED PN, HPT STG2 AIR SEAL PN 2A4157 SN
PKLBP93867, HPT STG1 AIR SEAL PN 2A3423 SN PKLBP93120, HPT STG2 RING PLATE PN
2A3437 SN PKLBP93442
> V2500-ENG-72-0677/VSB* CAT 3- SEAL; AIR; HPT; 1 STAGE -;REPLACEMENT Not Applicable
Rev.01
N/A DUE TO S/N INSTALLED NOT AFFECTED
Rev.01
N/A due to S/N installed not affected
Rev.02
Rev.00
2019-06-06 AD 00 Mandatory COMP JOINT AIRCRAFT SYSTEM COMPONENT (JASC) CODE 7240, TURBINE ENGINE COMBU Superseded (Not Applicable)
Reference(s) (Document No/Doc-Type/Revision)
2021-05-18 AD 00
2019-06-06/AD Rev.00 JOINT AIRCRAFT SYSTEM COMPONENT (JASC) CODE 7240, TURBINE ENGINE COMBU Not Applicable



> V2500-ENG-72-A0706/SB ENGINE-DIFFUSER CASE REAR OUTER FLANGE DIFFUSER CASE M FLANGE Not Applicable
Rev.00 REPETITIVE VISUAL INSPECTION FOR CRACKS
> > A320-72-0002/EO* Rev.00 BORESCOPE INSPECTION OF THE DIFFUSER CASE REAR OUTER FLANGE TURBINE Superseded
ENGINE COMBUSTION SECTION ON V2500 ENGINE MODELS
This Document has been SUPERSEDED BY A320F-72-0001/EO Rev.00
Manually deassigned after Document Cancelled or Superseded
2019-16-01 AD 00 Mandatory COMP ENGINE - TURBINE EXHAUST CASE INSPECTION Not Applicable
Remarks
N/A TO V2527-A5 AND V2524-A5
N/A BY ENGINE MODEL A5
2019-18-01 AD 00 Mandatory COMP TURBINE - LOW-PRESSURE TURBINE STAGE 6 DISKS REPLACEMENT Not Applicable
2019-18-01/AD Rev.00 TURBINE - LOW-PRESSURE TURBINE STAGE 6 DISKS REPLACEMENT Not Applicable
> V2500-ENG-72-A0697/VSB* NON-MODIFICATION SERVICE BULLETIN - ENGINE - DISK STAGE 6 LOW PRESSURE Not Applicable
Rev.01 TURBINE (LPT) - REMOVAL OF SUSPECT DISKS
Not applicable due to Engine serial number not affected
2020-07-51 AD 00 Mandatory COMP INTERNATIONAL AERO ENGINES AG (IAE) TURBOFAN ENGINES Not Applicable
US-2020-07-51 EAD 00
NA due to Engine SN and SN of HPT Disk 2A5001 not affected
2020-09-03 AD 00 Mandatory COMP ATA 72–V2500 ENGINE- REPLACEMENT OF SUSPECT DIFFUSER CASE ASSEMBLIES Not Applicable



Not applicable due to Engine serial number not affected.
2021-01-03 AD 00 Mandatory COMP ATA 72-50 TURBINE SECTION, PREVENT FAILURE OF THE HPT 1ST-STAGE AND HPT Not Applicable
2ND-STAGE DISKS
N/A DUE TO S/N INSTALLED NOT AFFECTED
2021-05-18 AD 00 Mandatory COMP BORESCOPE INSPECTION OF THE DIFFUSER CASE REAR OUTER FLANGE TURBINE Open
2021-05-18/AD Rev.00 BORESCOPE INSPECTION OF THE DIFFUSER CASE REAR OUTER FLANGE TURBINE Open
> V2500-ENG-72-0709/VSB* MODIFICATION OF THE DIFFUSER CASE ASSEMBLY REAR OUTER FLANGE Open (Next Shop Visit)
Rev.01
This Document terminates V2500-ENG-72-A0706/VSB Rev.02
27'999/C Perform initially before 22000/C
> V2500-ENG-72-A0706/VSB DIFFUSER CASE REAR OUTER FLANGE- DIFFUSER CASE M FLANGE REPETITIVE Repetitive
Rev.02 VISUAL INSPECTION FOR CRACK
This Document is terminated with implementation of V2500-ENG-72-0709/VSB Rev.01
> > A320F-72-0001/EO* Rev.00 V2500-ENGINE-BSI OF THE DIFFUSER CASE REAR OUTER FLANGE Repetitive
This Document SUPERSEDES A319-72-0001/EO Rev.00
This Document SUPERSEDES A320-72-0002/EO Rev.00



Perform initially before 24310/C / Interval
30'461/C
2100/C
26.Jul.2023 40721:34/H 28'361/C 814954 Was due at: 28'481/C PerfRev.:'00'
2021-11-15 AD 00 Mandatory COMP ATA 72-50, TURBINE SECTION, PREVENT FAILURE OF THE HPT 1ST-STAGE DISK AND Superseded (Superseded)
HPT 2ND-STAGE DISK
2021-11-51 AD 00 Mandatory COMP V2500-USI OF THE AFFECTED HPT DISKS Not Applicable
N/A DUE TO S/N INSTALLED ARE NOT AFFECTED
2021-14-19 AD 00 Mandatory COMP ATA 72-50, TURBINE SECTION, PREVENT FAILURE OF THE HPT 1ST-STAGE DISK AND Not Applicable
HPT 2ND-STAGE DISK
2022-02-09 AD 00
2021-14-19/AD Rev.00 ATA 72-50, TURBINE SECTION, PREVENT FAILURE OF THE HPT 1ST-STAGE DISK AND Not Applicable
HPT 2ND-STAGE DISK
> SI 112F-21/SL* Rev.00 CAT 3_V2500 HPT HUBS – REQUIRE REMOVAL IAW V2500 SB 72-0713 Not Applicable
N/A due to HPT Stg 1 Disk and HPT Stg 2 Disk S/N are not affected refer P&W SI No. 112F-21,
dated May 24, 2021
2022-02-09 AD 00 Mandatory COMP V2500 HPT STG 1 AND STG 2 HUBS - ANGLE SCAN ULTRASONIC INSPECTION Open
This Document SUPERSEDES US-2021-11-15/AD Rev.00



2022-02-09/AD Rev.00 V2500 HPT STG 1 AND STG 2 HUBS - ANGLE SCAN ULTRASONIC INSPECTION Open
This Document SUPERSEDES US-2021-11-15/AD Rev.00
> V2500-ENG-72-0713/VSB* CAT 3_ HPT S1 AND S2 HUB ANGLE SCAN ULTRASONIC INSPECTION Open (Next Shop Visit)
Rev.01
Perform initially within 6700/C (effective
31'908/C
from 13.Jul.2021)
99-04-03 AD 00 Mandatory COMP ENGINE - HIGH PRESSURE COMPRESSOR STAGE 9-12 DRUMS - REMOVAL FROM SERV Not Applicable
99-04-03/AD Rev.00 ENGINE - HIGH PRESSURE COMPRESSOR STAGE 9-12 DRUMS - REMOVAL FROM SERV Not Applicable
> V2500-ENG-72-0293/VSB* TO ANNOUNCE A REDUCTION IN CYCLIC LIFE DEPENDENT ON THRUST RATING Not Applicable
Rev.00
99-13-01 AD 00 Mandatory COMP ENGINE - HIGH PRESSURE TURBINE STAGE 1 INNER ROTATING AIRSEAL - INSPEC Not Applicable
99-13-01/AD Rev.00 ENGINE - HIGH PRESSURE TURBINE STAGE 1 INNER ROTATING AIRSEAL - INSPEC Not Applicable
> V2500-ENG-72-0190/VSB* ENGINE - HIGH PRESSURE TURBINE STAGE 1 INNER ROTATING AIRSEAL - INSPEC Not Applicable
Rev.00
99-21-19 AD 00 Mandatory COMP IAE V2500-A5 FORWARD THRUST LINKS REPLACEMENT Not Applicable
99-25-10 AD 00 Mandatory COMP FRONT ENGINE MOUNT MODIFICATION Not Applicable




F-1999-102-IMP(B) AD 00 Mandatory COMP HPC STG 9-12 DRUMS Not Applicable
F-1999-379-IMP(B) AD 00 Mandatory COMP V2500 HPT FAILURE Not Applicable
F-2000-299-IMP AD 01 Mandatory COMP PREVENT CRITICAL LIFE LIMITED ROTATING ENGINE PART FAILURE Not Applicable

N-03453 - 2023-11-11 - AD Status - ESN V12884 - AD ESN V12884 A595

Uploaded by

Copyright:

Available Formats

N-03453 - 2023-11-11 - AD Status - ESN V12884 - AD ESN V12884 A595

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

N-03453 - 2023-11-11 - AD Status - ESN V12884 - AD ESN V12884 A595

Uploaded by

Copyright:

Available Formats

AIRWORTHINESS 11.Nov.

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

2003-11-23 AD 00 Mandatory COMP SUPERSEDED BY FAA AD 2006-25-01 Superseded (Not Applicable)

2003-231-IMP AD 02 Mandatory COMP SUSPECT #3 BEARING FAILURE Not Applicable

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

2006-07-05 AD 00 Mandatory COMP ENGINE - FORWARD MOUNT BOLT Not Applicable

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

2010-06-18 AD 00 Mandatory COMP ENGINES - VORTEX REDUCERS - INSPECTION Not Applicable

2010-20-07 AD 00 Mandatory COMP SUPERSEDED BY FAA AD 2012-09-09 Superseded (Superseded)

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

2012-09-09 AD 00 Mandatory COMP SUPERSEDED BY FAA AD 2015-10-04 Superseded (Superseded)

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

99-25-10 AD 00 Mandatory COMP FRONT ENGINE MOUNT MODIFICATION Not Applicable

produced by AMOS www.swiss-as.com

For P/N: `V2527-A5` S/N: `V12884` (ENGINE V2500 FOR A320)

Document-Number Type Rev Compliance A|C Subject Status

F-1999-379-IMP(B) AD 00 Mandatory COMP V2500 HPT FAILURE Not Applicable

produced by AMOS www.swiss-as.com

You might also like