Marine Engine General Data Sheet

Cummins Inc.
Marine Engine General Data Sheet

Engine Model: QSK60 Data Sheet: D59-MX-1
Date: 1-Dec-09
GENERAL ENGINE DATA Metric [U.S. Customary]

Type …………..…………………………………………………………………………… 4 cycle, 60 Vee, 16 cylinder
Cylinders……………...…………………………………………………………………… 16
Bore …………...…………………………………………………………………………… mm [in] 159 [6.26]
Stroke …………...………………………………………………………………………… mm [in] 190 [7.48]
3
Displacement ………...…………………………………………………………………… liter [in ] 60.2 [3673]
ENGINE MOUNTING & ACCESSORY DRIVES

Max. Allowable Bending Moment at Rear Face of Block …………………………… N·m [ft·lb] 10350 [7634]
Max. Allowable Axial Thrust Load on Crankshaft …………………………...………… N [lb] 4448 [1000]
Min. Axial Clearance at Front Face of Crankshaft for Thermal Expansion ………… mm [in] 3.45 [0.136]
Crankshaft Radial Load Limit…………… ………………………..MAB 0.01.09-12/02/2005
Max. Allowable Radial Load on Front of Crankshaft
At All Angles ..………………………………………………………………………… N [lb] 8852 [1990]
Max. Allowable Radial Load on Rear of Crankshaft
At All Angles ………………………………………………………………………… N [lb] 6116 [1375]
Maximum Operating Angles (see MAB No. 0.16.00-03/27/2007 for definitions and options to gain greater capability)
Continuous Pitch Angle
Engine Front Up From Horizontal ...…………………………………………… Deg. 5°
Engine Front Down From Horizontal ...……………………………………… Deg. 5°
Continuous Roll Angle
"Right" from vertical viewed from flywheel end of engine…………………… Deg. 23°
"Left" from vertical viewed from flywheel end of engine…………………… Deg. 23°
Intermittent Pitch Angle (intermittent operation less than 1 minute)
Engine Front Up From Horizontal ...…………………………………………… Deg. 30°
Engine Front Down From Horizontal ...……………………………………… Deg. 30°
Intermittent Roll Angle (intermittent operation less than 1 minute)
"Right" from vertical viewed from flywheel end of engine…………………… Deg. 45°
"Left" from vertical viewed from flywheel end of engine…………………… Deg. 45°
FUEL SYSTEM
Maximum Allowable Restriction to Fuel Pump
Clean Filter ...………………………………………………………………………… kPa [in Hg] 34 [10.0]
Dirty Filter ...……………………………………………………………………………kPa [in Hg] 54 [16.0]
Maximum Allowable Return Line Pressure ...………………………………………… kPa [in Hg] 68 [20.0]
Maximum Static Pressure at Fuel Pump ..………………………………………………kPa [in Hg] 68 [20.0]
Maximum Height of Fuel In Tank Above Fuel Pump ..………………………………… m [ft] 8.23 [27.0]
EXHAUST SYSTEM
Maximum Allowable Back Pressure ..……………………………………………………kPa [in Hg] 10 [3]
Maximum Bending Moment at Turbine Outlet Mounting Flange …………………… N·m [ft·lb] 22 [16]
Maximum Incremental Direct Load at Turbine Outlet Mounting Flange …………… kg [lb] 9 [20]
AIR INDUCTION SYSTEM
Max. Allowable Intake Restriction - Turbocharged
Clean Filter ……………...……………………………………………………………kPa [in H2O] 4 [15]
Dirty Filter ……………………………………………………………………………… kPa [in H2O] 6 [25]
Maximum Air Cleaner Inlet Temperature Rise Over Ambient ……………………… °C [°F] 17 [30]
TBD= To Be Determined N/A = Not Applicable N.A. = Not Available
CUMMINS ENGINE COMPANY, INC

COLUMBUS, INDIANA
All Data is Subject to Change Without Notice - Consult the following Cummins intranet site for most recent data: http://marine.cummins.com
Cummins Inc.
Marine Engine General Data Sheet
Engine Model: QSK60 Data Sheet: D59-MX-1
Date: 1-Dec-09
LUBRICATION SYSTEM
Oil Consumption Rate (Volume Percent of Fuel Consumption Rate) ……………… % 0.15
Oil Pressure at Normal Operating Temperature
Idle Speed - Minimum in Main Oil Gallery ………………………………………… kPa [psi] 138 [20]
Rated Speed - Measured in Main Oil Gallery (Low) ……………………………… kPa [psi] 345 [50]
Rated Speed - Measured in Main Oil Gallery (High) …………………………… kPa [psi] 483 [70]
Max. Allowable Oil Temperature (Sump) ……………………………………………… °C [°F] 121 [250]
Oil Pan Capacity (Center Sump) OP 6132
Low ……………………………..……………………………………………………… liter [gal] 230.9 [61.0]
High …………………………….……………………………………………………… liter [gal] 261.2 [69.0]
Oil Pan Capacity (Full Length Sump) OP 6133
Low …………………………………………………………………………………… liter [gal] 230.9 [61.0]
High …………………………..……………………………………………………… liter [gal] 261.2 [69.0]
Oil Pan Capacity (Full Length Sump) OP 6141
Low …………………………………………………………………………………… liter [gal] 348.3 [92.0]
High …………………………..……………………………………………………… liter [gal] 378.5 [100.0]
Spin on Filter Capacity (per element)………………………………………………...… liter [gal] 1.5 [0.4]
Eliminator Filter Capacity………………………………………………….……………… liter [gal] 15.1 [4.0]
COOLING SYSTEM
Coolant Capacity
Engine Only …………………………………………………………………………… liter [gal] 232.8 [61.5]
Engine Including Heat Exchanger and Integral Expansion Tank………………… liter [gal] 318.0 [84.0]
Min. Coolant Makeup Capacity ………………………………………………………… liter [gal] 46.6 [12.3]
Max. Pressure Drop Across Any External Cooling System Circuit ………………… kPa [psi] 34.5 [5.0]
Max. Coolant Temperature at Engine Outlet …………………………………………… °C [°F] 96 [205.0]
Min. Block Coolant Temperature (Warm Engine) ……………………………………… °C [°F] 71 [160.0]
Min. Allowable Coolant Expansion Space ………………………………… .% of System Capacity 5%
Sea Water Pump Specifications…………………………………………. Refer to MAB 0.08.17 - 07/16/2001
ELECTRICAL AND STARTER SYSTEM
Electrical 12V 24V
Min. Recommended Battery Capacity
Cold Cranking Amperes Rating (CCA) ……………………………………… N/A 1800
Marine Cranking Amperes Rating (MCA) …………………………………… N/A 2250
Reserve Capacity (Discharging 25 Amps @ 80°F) ………………………… minutes N/A 320
Min. Allowable System Voltage (@ Battery While Running) …………………… Volts N/A 21.0
Min. Allowable System Voltage (@ Battery While Cranking) …………………… Volts N/A 18
Max. Allowable System Voltage (@ Battery While Running) …………………… Volts N/A 31.0
Max. Allowable Voltage Drop of Starting Circuit (While Cranking) ……………… Volts N/A 2.6
Min. Engine Cranking Torque ……………………………………………………… ft·lb N/A 675
Min. Break-away Engine Cranking Torque ………………………………………… ft·lb N/A 1519
Min. Engine Cranking Speed ……………………………………………………… rpm N/A 150
Max. Engine (Running) Current Draw ……………………………………………… Amps N/A 10
Min. Ambient Temperature for Cold Start (No Aids) ……………………………… °C [°F] N/A [N/A] -12 [10]
Air Starter
Regulated Pressure for Air Starter System ……………………………………… kPa [psi] 1034 [150]
Min. Air-Flow for Air Starter System ……………………………………………… l/sec [cfm] 684 [1450]
Min. Recommended Tank Volume ………………………………………………… liter [gal] 1136 [300]
TBD= To Be Determined N/A = Not Applicable N.A. = Not Available
CUMMINS ENGINE COMPANY, INC

COLUMBUS, INDIANA
All Data is Subject to Change Without Notice - Consult the following Cummins intranet site for most recent data: http://marine.cummins.com

Marine Engine General Data Sheet

Uploaded by

Copyright:

Available Formats

Marine Engine General Data Sheet

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Marine Engine General Data Sheet

Uploaded by

Copyright:

Available Formats

Cummins Inc.

Marine Engine General Data Sheet

GENERAL ENGINE DATA Metric [U.S. Customary]

ENGINE MOUNTING & ACCESSORY DRIVES

TBD= To Be Determined N/A = Not Applicable N.A. = Not Available

CUMMINS ENGINE COMPANY, INC

TBD= To Be Determined N/A = Not Applicable N.A. = Not Available

CUMMINS ENGINE COMPANY, INC

You might also like