CAP297-1

MARCH, 2020
REV.C

RS SERIES
OIL-INJECTED ROTARY SCREW COMPRESSORS

PARTS LIST
RSB-40 LOT#04
RSB-50 LOT#04

IMPORTANT
Make a permanent record of the Model and Serial numbers of your machine here.
You will save time and expense by including this reference identification on replacement parts.

MODEL_______________ SERIAL NO._______________________

 DANGER
Air used for breathing or food processing must meet
OSHA 29CFR 1910.134 or FDA 21CFR 178.3570
Regulations. Failure to do so may cause severe
injury or death
 INTRODUCTION

HOW TO USE THE PARTS LIST

Using the List of Illustrations obtain the figure number of the assembly in which your part is
located. Go to the appropriate figure and locate your part on the illustration. Using the key
number, find the part on the parts list.

LIST OF ILLUSTRATIONS
Title Page
Components Group 2
Major Part W/C 7
Components Group W/C 10
Electrical Components Group FVM 13
Electrical Components Group Y-D 15
Tank Group 19
Enclosure Group 22

WARNING
Personal injury and/or equipment damage will result by failing to pay attention
to the vital safety information and instruction in the operating and instruction manual
Carefully read, understand, and retain all safety information and instructions
before operating this unit.

1
 CAP297-1

99 99A 99B
110 105 87 104 115 117 115 111
51
113 113 118 114 91
50
59
112
21 100
36A CONNECTED TO 103 101
83 129 INLET VALVE
34 36 37 14 46
31 91 102
14A 45
90 89 31 60
109
A 13
58
45 48
35
38 56 OUT
46 49
57 IN 12
116 5 95 96
40 49 62 17
55
41 50 61
84A
42 52 53 54 106 107 37 35 98
10 84
6 108 19 86 92
47
119 16 85
48 2 81
4
47 9 49 98 48 93
43 78 86
48 50 45 63 49 94
50 64 66 88 98
49 51
67 18 87
45 46 65 68 78
69
8 50 70 24 134
71
15
51 11
72
50 47 INSIDE CONTROL BOX
46 48
44 7 80
45 121
20 23 122
46
123
B
124

1
DETAIL A
DETAIL B 78 79
82 3
26
B

75 C
77
A 22
27
NOTE:
28
THE THERMO VALVE NOTE: 31
73 74 76 72
MUST BE ROUTATE TO FIT MAKE SURE THAT THE CHECK 29 OUT
VALVE IS MOUNTED IN 32
30
ACCORDING THE DRAWING 27 33
DIRECTION 28 31

Components Group
2
 CAP297-1

PART LIST FOR THE RSB40-50

ITEM PART NUMBER
DESCRIPTION Q
NO RSB40 RSB50
1 BASE 42 X 72 DARK GREY RS40-50F, 50D 1 FRN10116-15 <
2 TANK AIR/OIL SEPARATOR 14" DIA 19 GAL 1 FRN10222-2 <
3 BSA31S(4v5/CURTIS/SingleSeal/RAL7026) 1 2A05190279 <
MOTOR, 3PHASE, 60HZ, 200V, ODP FMT409X2 FMT509X2
4 MOTOR, 3PHASE, 60 HZ, 230/460V ODP 1 FMT403X2 FMT503X2Y
MOTOR, 3PHASE, 60HZ, 575V, ODP FMT408X2Y FMT508X2
MOTOR 1 1/2HP, 3 PHASE, 60HZ, 200V ODP FMT119X4 FMT029X4
5 MOTOR 1 1/2HP, 3 PHASE, 60HZ, 230/460V ODP 1 FMT113X4 FMT023X4
MOTOR 1 1/2HP, 3 PHASE, 60HZ, 575V ODP FMT118X4 FMT028X4
6 FAN SHROUD 1 FCS731 FCS730
7 COOLER SUPPORT-LEFT 1 FCS700 <
8 COOLER AIR/OIL (R/S 40-50) 1 2689510030 <
9 FAN MOTOR MOUNT R/S 40-50 1 FRN10120-8 <
10 BRACKET, OIL FILTER 1 FCS717A <
11 SUPPORT, ELECTRICAL ENCL. 39" 2 FCS677-2 <
12 BELTGUARD, BACK BSA32 R/S40-50F 1 FRN10510-11 <
13 GUARD BELT FRONT R/S 40-50 1 FRN10510 <
14 INLET VALVE DN65 110V 1 2104050162 <
14A O-RING 1 INCLUDED <
15 MOTOR BASE ODP 1 FRN12030 FRN12040
16 GUARD FAN 24 " RD WIRE 1 FRN10456 <
17 SEPARATOR, ELEMENT 1 FRN27518 <
18 TUBE 1 1/2" O.D. 1 FOFE981 <
19 MOUNT BASE BSA31S BOLTED RSB40-50 1 FRN10176 <
20 TUBE-BY-PASS TO OIL FILTER 3/4" OD. 1 FOFE959 <
21 TUBE 1 1/4" O.D.X 0.049 1 FOFE949 <
22 TUBE-SEPARATOR TANK TO BY-PASS 3/4"OD 1 FOFE960 <
CONTROL PANEL SIZE "K" F1330000 <
23 1
CONTROL PANEL SIZE "N" F1330001 <
24 PLUG PLASTIC, 2" SQ. TUBE 2 F1030004 <
26 CONNECTOR 3/4BSPP X 3/4" 37FL 1 FVAC749 <
27 SEAL BONDED W/VAA745 ADAP 3 FVAA746 <
28 ADAPTER 1/8 BSPP MALE X 1/4 NPTF 3 FVAA745 <
29 ELBOW, MALE 90 DEGREE 1/4" NPTM X 1/4" NPTM STEEL 1 FVAA754 <
30 CHECK/SIGHT GLASS/2mm ORIFICE COMBO VALVE 1 2605332920 <
31 COMPRESSION CONNECTOR 1/4"NPTx 3/8”OD ELBOW 2 FRN52150-12 <

3
 CAP297-1

32 THERMOWELL 1/4"BSPPx 7/16-24UNS 6MM PRO 1 FRN18694 <

33 SEAL BONDED BSPP 1/4 1 2109120008 <
34 NIPPLE 1 1/4 X 5 1/2 1 FPTN0716AS <
35 CONNECTOR, 1/4OD X 1/4NPT, MALE, ELBOW 2 FRN52150-2 <
36 VALVE MIN PRESS 1 1/4" 1 FRN42126 <
36A KIT REPAIR MIN. PRESSURE VALVE 1 FRN42126-1 <
37 PRESSURE-AIR GAUGE, 300 PSI 2 1/2 " 2 FRN30323 <
38 CONNECTOR 1 1/4"NPT X 1 1/4"OD ELBOW-MALE 1 FVAA722 <
40 TEE REDUCING 1 X 3/4 X 3/4 1 FVAE803 <
41 NIPPLE 1 X 5 1/2" 1 FPTN0616AS <
42 CONNECTOR 3/4"NPT X 3/4"OD.STRAIGHT 1 FVAA717 <
43 FAN-ASSY 45 DEG PITCH 1 FRN32419 FRN32406
44 DRAIN COCK 1/4" 1 FVV514 <
45 HHCS 5/16-18 X 1" GRADE 5 ZINC PLATED 13 FVH12HH1 <
46 FLAT WASHER 5/16 ZINC PLATED 11 FVH32H1 <
47 WASHER-CUT-FLAT 1/4" 7 FVH32F <
48 LOCK WASHER ZINC PLATED 1/4" MEDIUM 19 FVH35F1 <
49 HHCS 1/4-20 X 3/4" LONG ZINC PLATED 21 FVH12FF1 <
50 LOCK WASHER 5/16 SPLIT ZINC PLATED 13 FVH35H1 <
51 NUT HEX 5/16-18 ZINC PLATED 7 FVH15H1 <
52 NUT-HEX 10-24 4 F4440 <
53 GUARD CLIPS 4 FRN10455-1 <
54 SCREW-HEX HD. MACHINE 10-24 4 FVH11DD <
55 SPIN ON OIL FILTER, R/S 15-50 1 FRN28201 <
56 FILTER HEAD OIL (RS15-50) 1 FRN28100 <
57 NIPPLE-BLACK 3/4 X 2 1/2" 1 FPTN0510AS <
58 CONNECTOR 3/4"NPT X 3/4 OD ELBOW 90 DEGREE 1 FRN60084 <
59 HHCS M16 X 90MM" ZINC PLATED 4 2102019850 <
60 NUT HEX M16 x 2.0 2 FVH1531 <
61 VALVE RELIEF 1/2" 200 PSIG 1 FRN42817 <
62 ELBOW-1/2" STREET-BLACK 1 FPTS04AG <
63 HHCS 3/8-16 X 1" GRADE 5 ZINC PLATED 4 FVH12KH1 <
64 LOCKWASHER 3/8" ZINC PLATED 4 FVH35K1 <
65 WASHER FLAT 3/8" ZINC PLATED 4 FVH32K1 <
66 CAP-OIL FILLER/SIGHT GLASS 1 FCS741 <
67 COMBINATION OIL FILL AND SIGHT GLASS 1 FCS740 <
68 ADAPTOR STR ELBW 1 1/16-12 UN X 3/4"NPTF 1 FRN60078 <
69 BUSHING 3/4 X 1/2 1 FPTB0504AG <
70 BALL VALVE,1/2",20KG/CM2 1 2104010213 <
71 PLUG- SQUARE HEAD-STEEL 1/2" 1 FPTP04AG <
72 CONNECTOR ELBOW, 3/4 OD X 1 1/16 - 12UN 2 FRN52141 <

4
 CAP297-1

73 BUSHING REDUCING 1" X 3/4" GALV STEEL 1 FPTB0605AG <

74 ADAPTOR 3/4"NPT X 1 1/16-12UN MALE 1 FRN52139 <
75 O-RING SAE12 VITON 1 FRN52139-1 <
76 VALVE THERMO SAE12 170 DEG F 1 FRN42403 <
77 CONNECTOR 1 1/16"-12UN X 3/4" OD. STRAIGHT, VITON O-RING 1 FRN52143 <
78 LOCKWASHER LIGHT 1/2" ZINC PLATED 12 FVH35P1 <
79 HHCS 1/2-13UNC X 2 3/4 “GRADE 5 4 FVH12PS1 <
80 SCREW,1/4-20 X 0.5 HHCS GR 5 4 FVH12FF1 <
81 HHCS M16-2.0 X 30MM ZN PL 4 FVH1471 <
82 ORIFICE 7.6MM OD 1 FRN52191 <
83 LOCKWASHER SPLIT 5/8" 8 FVH35R1 <
84 FLANGE DISCHARGE SAE24 BSA31S ELBOW 1 FRN10728 <
84A O-RFING#231 VITON FOR FRN10728 1 FRN10728-1 <
85 CONNECTOR 1 1/2"OD X 1 7/8-12 UN STRGHT, VITON O-RING 1 FVAB707 <
86 LOCK WASHER 16MM 8 FVH1234 <
87 SCREW HEX M16 X 2.0 X 90MM CL8.8 Zn PL 4 FVH1485 <
88 TEMP SWITCH 1/2"NPT 1” PROBE 2 FRN18658 <
89 ADAPTER 1/4"BSPP X 1/4"NPT 1 FVAA769-1 <
90 O-RING FOR FVAA769-1 1 FVA769-2 <
91 CLAMP 3 1/8 - 6 2 FRN24076-5A <
92 BELT 1
93 BUSHING, AIR END 1
94 SHEAVE, AIR END 1 SEE TABLE 1
95 BUSHING MOTOR 1
96 SHEAVE, MOTOR 1
98 HHCS 1/2-13UNC X 1 GRADE 5 ZINC PLATED 8 FVH12PH1 <
99 FRG AIR CLEANER R/S40-50 1 FRN24077 <
99A AIR PRIMARY 1 FRN24077-1 <
99B AIR SAFETY 1 FRN24077-2 <
100 MOUNT PLATE, HDF 1 FRN24079-11 <
101 ROD THREADED M16 X 2.0 1 FVL2402 <
102 PLATE MNT, HDF, RS20-50 W/EYE BOLT MOTORS 1 FRN24076-9 <
103 ELBOW REDUCING 3.5" X 3" 1 FRN24077-3 <
104 TUBE STEEL 1/4" OD X.030 WALL 1 FOFE1030 <
105 TEE-REDUCING 1 1/4"NPT X 1/2"NPT X 1 1/4"NPT 1 FVAE804 <
106 NIPPLE, 1/4"NPT X 1 1/2" SHORT 2 FPTN0208AG <
107 TEE 1/4"NPT PIPE GALV 2 FPTT02AG <
108 CONNECTOR 1 1/2"OD.X1 7/8"- 12UN ELBOW 1 FRN52145 <
109 NIPPLE 1 1/4"NPT X 2 1/2"LONG 1 FPTN0710AS <
110 CONNECTOR 1 1/4NPT X 1 1/4OD COMPRESSION 1 FVA788 <
111 TUBE STEEL 1/4" OD X.030 WALL SEPARATOR TO SIGHT GLASS 1 FOFE963 <

5
 CAP297-1

112 HHCS 5/8-11UNC X 1 1/2 GRADE 5 8 FVH12RH1 <

113 SLEEVE 1/4 OD 2 FVAA757 <
114 NYLON TUBE 3/8" BLACK - FVA1626 <
115 NUT 1/4" OD STEEL 2 FVAA756 <
116 HOSE ASSEMBLY 5/8ID X 41.75"LG WITH SAE 37 FEMALE SWIVEL 1 FRN60717 <
117 UNION 1 FVAA701 <
118 CONNECTOR SCAVENGER COMPR. 1 FRN52151 <
119 COOLER SUPPORT-RIGHT 1 FCS701 <
120 MTG BRACKET 8" DI 1 FRN24077-4 <
121 SWITCH-PRESSURE W/O BLEEDER 1/4"NPT 1 F1240007 <
122 NIPPLE 1/4 X CLOSE, 304SS 1 FPTN0200AG <
123 1/4"X1/2" BULKHEAD FITTING 1 FRN10616 <
124 CONNECTOR, 1/4OD X 1/4NPT, MALE, STR. 1 FRN52150-5 <
125 O-RING #246 1 FRN10713-1 <
126 VALVE INJECTION 1 FRN24589 <
127 ADAPTER 3/8 BSPPM X 3/8 NPTF 1 FVA770 <
128 CONNECTOR, 3/8 OD X 3/8NPT 1 FRN52150-10 <
129 INSERT 3/8 TUBE 2 FRN52150-12 <

6
 CAP297

14
22
18
19
13

24 5
23
23
24

20
21

15 36 35
37 32
3
33
15
8
12
9

26 26 29

27 27
10 4 28 11
7 29 25
24
31
23
1
26 17 11
27 16
28 33
32 38
6
2

26
27
28

Major Components Group Water Cooled

7
 CAP297-1

PARTS LIST FOR MAJOR PARTS GROUP

ITEM NO. DESCRIPTION QTY. RSB40 W/C RSB50 W/C
1 BASE 1 FRN10176 <
2 SEPARATOR, OIL/AIR 1 FRN10222-2 <
4 MOUNTING PLATE, AIR END 3 1 FRN10127 <
6 PANEL, CONTROL 1
SIZE, “K” F1330000 <
SIZE, “N” F1330001 <
7 COOLER, OIL, W/C 1 FRN33157 <
8 AFTERCOOLER, W/C 1 FCX740 <
9 COOLER SUPPORT ASSEMBLY, L.H. 1 FCS700 <
10 COOLER SUPPORT ASSEMBLY, R.H. 1 FCS701 <
11 SUPPORT, CONTROL PANEL 2 FCS667-2 <
15 BOLT M16 2 FVH1471 <
16 BOLT, M12 4 FVH1485 <
17 LOCKWASHER, M12 4 FVH1240 <
23 SCREW, HEX WASHER HEAD, ¼-20 x ¾” LG. 13 FVH12FF1 <
24 LOCKWASHER, 1/4" 17 FVH35F1 <
25 WASHER, FLAT, 1/4" 4 FVH32F1 <
26 SCREW, HEX HEAD CAP, 5/16-18 x 1" LG. 14 FVH12HH1 <
27 LOCKWASHER, 5/16" 14 FVH35H1 <
28 WASHER, FLAT, 5/16" 14 FVH32H1 <
29 BOLT 5/8-11 X 1” 4 FVH12RH1 <
31 LOCKWASHER 5/8” 4 FVH35R1 <
32 LOCKWASHER, 1/2" 8 FVH35P1 <
33 WASHER, FLAT, 1/2" 8 FVH32P1 <
34 AIR END SEAL KIT (NOT SHOWN) 1 FRN90437-1 <
36 AFTERCOOLER BRACKET 1 FRN10171A <
37 AFTERCOOLER BRACKET 1 FRN10171B <
38 BOLT 1/2-13 X 2 3/4” LG 4 FVH12PH1 <

8
 CAP297-1

TABLE 1: SHEAVES, BUSHING AND BELTS

ITEM R/S 40 R/S 50
PSI DESCRIPTION
N QTY PART NO. QTY PART NO.

97 SHEAVE, MOTOR 1 FRN14106 1 FRN14134

96 BUSHING, MOTOR 1 FVDC215 1 FRN14177-5

100 95 SHEAVE, AIR END 1 FRN14106 1 FRN14137

94 BUSHING, AIR END 1 FRN14177-11 1 FRN14177-11
93 BELT 4 FRN14315-1 5 FRN14315-1

97 SHEAVE, MOTOR 1 FRN14109 1 FRN14134

96 BUSHING, MOTOR 1 FVDC215 1 FRN14177-5
125 95 SHEAVE, AIR END 1 FRN14110 1 FRN14135
94 BUSHING, AIR END 1 FRN14177-11 1 FRN14177-11
93 BELT 4 FRN14316-1 6 FRN14316-1
97 SHEAVE, MOTOR 1 FRN14106 1 FRN14134
96 BUSHING, MOTOR 1 FVDC215 1 FRN14177-5
150 95 SHEAVE, AIR END 1 FRN14110 1 FRN14134
94 BUSHING, AIR END 1 FRN14177-11 1 FRN14177-11
93 BELT 4 FRN14316-1 5 FRN14316-1
97 SHEAVE, MOTOR 1 FRN14106 1 FRN14135
96 BUSHING, MOTOR 1 FVDC215 1 FRN14177-5
175 95 SHEAVE, AIR END 1 FRN14186 1 FRN14134
94 BUSHING, AIR END 1 FRN14177-11 1 FRN14177-11
93 BELT 4 FRN14316-1 5 FRN14316-1

9
 CAP297-1

95
92 100
92A
92B 101
102

98 102
93
103
97
94 99
7 96

CONTROL VALVE KIT 79 93

79 11
72
69
81 11A 9
6 8
74
71 76
77
75 71
73 72
84 73
72 86 35
85
71 33 39
40
52
54A 1
ENCLOSURE 42 41
69 59
80 13 60
61
86
38 18
26 59
83 41 34 35 60 19
85 57 66
84 56 3
42
25 65 2
58 66
64 29
27 63 29A 15
46 44 54 5
46A 20 30 62
33 4
28A 21 19
24 67 35
28
23 32 51
73 53
74 75 68 68 31
17 16
73
77 14
76 68 43
72 22
71 70 45
55
37
89
88 70 36
87

49
50
47
44 48

Water and Oil Piping Group

10
 CAP297-1

PARTS LIST FOR AIR AND OIL PIPING GROUP

ITEM DESCRIPTION QTY. RSB40 RSB50
NO. W/C W/C
1 AIR END 1 2A05190279 <
2 FLANGE, DISCHARGE 1 FRN10728 <
3 "O" RING #231 1 FRN10728-1 <
4 SCREW HEX M16 X 2.0 X 90MM CL8.8 Zn PL 4 FVH1485 <
5 LOCK WASHER, 16mm 4 FVH1234 <
6 ADAPTER 1/4"BSPP X 1/4"NPT 1 FVAA769-1 <
7 BOLT M16-1.75 X 90MM 4 2102019850 <
8 COMPRESSION CONNECTOR 1/4"NPTx 3/8”OD ELBOW 1 FRN52150-12 <
9 O-RING FOR FVAA769-1 1 FVA769-2 <
11 VALVE, INLET DN65 1 2104050162 <
11A O-RING FOR 1 INCLUDED <
13 ELBOW,1 1/4”NPT STREET 1 FVAA722 <
15 CONNECTOR, STRAIGHT 1 FVAB707 <
16 TUBE, STEEL 1 FOFE981 <
17 CONNECTOR, ELBOW 1 FRN52145 <
18 CONNECTOR 3/4BSPP X 3/4" 37FL 1 FVAC749 <
19 HOSE, ASSEMBLY 1 FRN60713 <
20 CONNECTOR, 3/4” OD FL x 3/4" NPT, ELBOW 1 FRN60084 <
21 OIL FILTER HEAD 1 FRN28100 <
22 ELEMENT, OIL FILTER 1 FRN28201 <
23 TEE - 3/4" NPT GALV. 1 FVAE803 <
24 NIPPLE, 1/4" NPT, CLOSE 1 FPTN0200AG <
25 CONNECTOR, ELBOW, 3/4" OD x 3/4"NPT 1 FRN60084 <
26 TUBE, BY-PASS TO OIL FILTER 1 FOFE960 <
27 CONNECTOR, STRAIGHT, 3/4"OD x SAE12 1 FRN52143 <
28 ADAPTOR, MALE - 3/4" NPT x SAE12 1 FRN52139 <
28A O-RING FOR RN52139 1 FRN52139-1 <
29 THERMOWELL 1/4"BSPPx 7/16-24UNS 6MM PRO 1 FRN18694 <
29A SEAL BONDED BSPP 1/4 1 2109120008
30 ELEMENT, SEPARATOR 1 FRN27518 <
32 TEE - 1/4" 4 FPTT02AG <
33 CONNECTOR, 1/4” ID X 1/4” NPT MALE, ELBOW 2 FRN52150-2 <
34 TEE, RUN – 1/4” NPT X 1/4” OD TUBE X 1/4” OD TUBE 2 FVA745 <
35 TUBE, NYLON, BLACK, #11, 1/4" O.D. - FVA1626 <
36 COMBINATION OIL FILL AND SIGHT GLASS 1 FRN52171 <
37 CAP W/ VENT HOLE 1 FCS741 <
39 VALVE, MINIMUM PRESSURE 1 FRN42126-4 <
40 KIT, SERVICE, MINIMUM PRESSURE VALVE 1 FRN42126-1 <
41 CONNECTOR, 1 l/4"OD FL x 1 1/4"NPT STR 2 FVAA722 <
42 HOSE, 0.375"IDX41.75" 1 FRN60717 <
43 TEE, 1 1/4"NPT 1 FVAE804 <
44 CONNECTOR, ELBOW, 3/4"OD x SAE12 2 FRN52I41 <
45 TUBE, SEPARATOR TANK TO BY-PASS 1 FOFE995 <
46 VALVE, THERMO BY-PASS, 170° F 1 FRN42403 <
46A KIT, SERVICE, THERMO BY-PASS VALVE, 170° F 1 FRN42403-1 <
47 ADAPTOR STR ELBW 1 1/16-12 UN X 3/4’NPTF 1 FRN60078 <
48 BUSHING 3/4”NPT X 1/2”NPT 1 FPTB0504AG <
49 VALVE, BALL-1/2” 1 2104010213 <
50 PLUG 1/2” NPT. 1 FPTP04AG <

11
 CAP297-1

ITEM RSB40 RSB50

DESCRIPTION QTY.
NO. W/C W/C
51 SWITCH, TEMPERATURE 1/2”NPT 1 FRN18658 <
52 SWITCH, TEMPERATURE 1/4”NPT 1 FRN18659 <
53 ELBOW, STREET 1/2”NPT 1 FPTS04AG <
54 AIR GAUGE, 2 1/2” DIA., 1/4”NPT LIQUID FILLED 1 FRN30323 <
54A AIR GAUGE, 2 1/2” DIA., 1/4”NPT LIQUID FILLED 1 FRN30322 <
56 COMPRESSION CONNECTOR, 1/4” NPT X 1/4”,SCAV.LINE 1 FRN52151 <
57 STEEL TUBE, 1/4” OD 1 FOFE963 <
58 STEEL TUBE, 1/4” OD 1 FOFE968 <
59 NUT, 1/4” OD, STEEL 2 FVAA756 <
60 SLEEVE, 1/4” OD, STEEL 2 FVAA757 <
61 SIGHT GLASS 1 FRN52174 <
62 ORIFICE SCAVENGER COMPRESSION CONNECTOR 1 FRN52131-3 <
63 CHECK VALVE IN-LINE 1/4” 1 FVV834 <
64 ELBOW 1/4 NPTM X 1/4” NPTM 1 FVAA754 <
65 ADAPTER 1/8 BSPP MALE X 1/4 NTF 3 FVAA745 <
66 BOND SEAL VITON USE W/VAA745 ADAP 3 FVAA746 <
67 VALVE, RELIEF – 1/2” 200 PSI 1 FRN42817 <
68 BUSHING, 1 ” NPT X 3/4” NPT 3 FPTB0605AG <
69 BUSHING, 2” NPT X 1 1/4” NPT 2 FPTB0907AG <
71 BUSHING, 3/4” NPT X 1/2” NPT 4 FPTB0504AG <
72 NIPPLE, 1/2”” NPT, CLOSE. 4 FPTN0200AG <
73 ELBOW, 1/2” NPT 4 FPTS04AG <
75 CONNECTOR, 1/2” (WATER HOSE) 2 FVE676 <
76 HOSE, 1/2” OD, MULTI-PURPOSE 3’ FRN60070 <
77 CLAMP, WORM DRIVE HOSE 2 FRN60072 <
78 NIPPLE,1 1/4”NPT X 2 1/2”LG 1 FPTN0716AS <
79 WATER MODULATING VALVE, 1/2” 1 FCF1552 <
80 WELL, WATER VALVE, 3/4” X 4 1/2” 1 FCF1559 <
81 UNION, 1/2” NPT 1 FVAC883 <
83 BULCKHEAD FITTING 1/2”(FOR ENCLOSED UNIT ONLY) 1 FRN10617-1 <
84 HOSE 1/2” OD, MULTI PURPOSE( FOR ENCLOSED UNIT ONLY) 5’ FRN60070 <
85 CLAMP, WORM DRIVE HOSE( FOR ENCLOSED UNIT ONLY) 2 FRN60072 <
86 CONNECTOR, 1/2” (WATER HOSE)( FOR ENCLOSED UNIT ONLY) 2 FRN60071 <
88 BALL VALVE 3/8” NPT 1 2104010213 <
89 PLUG 1/4”NPT 1 F1479239 <
90 SEPARAOR TANK CROSS (NOT SHOWN) 1 FRN10140 <
92 HD AIR FILTER 1 FRN24077 <
92A FILTER ELEMENT PRIMARY 1 FRN24077-1 <
92B FILTER ELEMENT SAFETY 1 FRN24077-2 <
93 CLAMP 3 1/8-16 2 FRN24076-5A <
94 ELBOW 3.5 1 FRN24077-5 <
95 MOUNTING BRACKET 8”DIA 1 FRN24077-4 <
96 MOUNTING PLATE MOTOR 1 FRN24076-9 <
97 THREAD ROD M16 0.5’ FVL2402 <
98 MOUNTING PLATE HDF 1 FRN24079-11 <
99 NUT HEX M16 2 FVH1531 <
100 HHCS 5/16-18 X 1" GRADE 5 2 FVH12HH1 <
101 FLAT WASHER 5/16” 4 FVH32H1 <
102 LOCK WASHER 5/16” 2 FVH35H1 <
103 NUT HEX 5/16-18 ZINC PLATED 2 FVH15H1 <

12
 CAP297-1

29

28

7
8 2
9 3
25 4

17
13 11
14 12
15
19 27
20 10
18 16
5
6
28
21

13
 CAP297-1

ITEM NO. DESCRIPTION QTY. RSB40 RSB50

1 CONTROL BACK PANEL
2 STARTER WITH INTERCHANGEABLE HEATERS SEE TABLE 2
3 STARTER SIZE “A” WITH INTERCHANGABLE HEATERS 1 FRN18959 <
4 FUSE BLOCK - 30A, 600V 1 FRN18314-1 <
5 TERMINAL BLOCK 6 F1330042 <
6 TERMINAL BLOCK END STOP 1 F1330043 <
7 TRANSFOMER, 150VA,FUSED, 200/208/230/460-120V
8 FUSE, TRANSFORMER, PRIMARY SEE TABLE 2
9 FUSE, TRANSFORMER, SECONDARY
10 RELAY, 4 POLE, 120V, DPDT 1 F1330062 <
11 SOCKET 1 F1330049 <
12 TIMER, 60 MIN., PLUG-IN 1 F1330026 <
13 PUSH BUTTON START SWITCH 1 FRN18116-M22 <
14 PUSH BUTTON STOP SWITCH (RED) 1 FRN18118-M22 <
15 2 POSITION SELECTOR SWITCH (CONST/AUTO) 1 FRN18104-9M22 <
16 2 POSITION SELECTOR SWITCH (LOAD/UNLOAD) 1 FRN18104-7M22 <
17 HOURMETER 1 F1330048 <
18 AMBER LIGHT (STAND BY) 1 FRN18218-M22 <
19 RED LIGHT (STOP) 1 FRN18217-M22 <
20 GREEN LIGHT (POWER ON) 1 FRN18219-M22 <
21 TEMPERATURE GAUGE 1 FRN18692 <
22 HEATER - MAIN (NOT SHOWN)
23 HEATER - FAN (NOT SHOWN) SEE TABLE 2
24 FUSE, FAN (NOT SHOWN)
25 AUX CONTACTOR 1 FVSB886 <
26 CONTACTOR NO/NC (Y-DELTA ONLY) 1 N/A <
27 ANTI-START PRESSURE SWITCH 1 FRN18134 <
28 LUG, GROUNDING 2 FVE779 <
29 ENCLOSURE 1 F1330058 <

ELECTRICAL COMPONENTS GROUP-FVM

14
 CAP297-1

14

28

32
5
6
12,13
10
30

29 11

19
15 2 31
16

21 17
7
22 8
20 18
9
25
23
30

3
4
1
27 26

ELECTRICAL COMPONENTS GROUP – Y-DELTA

15
 CAP 297-1

ITEM
DESCRIPTION QTY. RSB40-50
NO.
1 CONTROL PANEL ASSEMBLY
2 STARTER WITH INTERCHANGEABLE HEATERS (MAIN MOTOR) SEE TABLE 3
3 STARTER WITH INTERCHANGABLE HEATERS (FAN)
4 FUSE BLOCK - 30A, 600V 1 FRN18314-1
5 TERMINAL BLOCK 26 F1330042
6 END STOP 2 F1330043
7 TRANSFORMER
8 FUSE, TRANSFORMER, PRIMARY SEE TABLE 2
9 FUSE, TRANSFORMER, SECONDARY
10 RELAY, 4 POLE, 120V, DPDT 2 F1330062
11 SOCKET 2 F1330049
12 TIMER, 60 MIN., PLUG-IN 1 F1330026
13 TIMER, 30 SEC., PLUG-IN 1 F1330031
14 ENCLOSURE 1 FRN18059
15 PUSH BUTTON START SWITCH (GREEN) 1 FRN18116-M22
16 PUSH BUTTON STOP SWITCH (RED) 1 FRN18118-M22
17 2 POSITION SELECTOR SWITCH (CONST/AUTO) 1 FRN18104-9M22
18 2 POSITION SELECTOR SWITCH (LOAD/UNLOAD) 1 FRN18104-7M22
19 HOURMETER 1 F1330048
20 AMBER LIGHT (STAND BY) 1 FRN18218-M22
21 RED LIGHT (STOP) 1 FRN18217-M22
22 GREEN LIGHT (POWER ON) 1 FRN18219-M22
23 TEMPERATURE GAUGE 1 FRN18683
24 HEATER - MAIN (NOT SHOWN)
25 HEATER - FAN (NOT SHOWN) SEE TABLE 3
26 FUSE, FAN (NOT SHOWN)
27 VALVE, SOLENOID 1 FRN18422
28 SWITCH, PRESSURE 1 FRN18133-2
29 SWITCH, ANTI-START PRESSURE 1 FRN18134
30 LUG, GROUNDING 2 FVE779
31 CONTACTOR REV. M1-S/M1-S WITH NO/NC SEE TABLE 3
32 NIPPLE 1/4”NPT X CLOSE 1 FVA13BAV
WIRING DIAGRAM FOR Y-DELTA FCAB1665A

ELECTRICAL COMPONENTS GROUP – Y-DELTA

16
 CAP297-1

ITEM DESCRIPTION QTY.

200 VOLT 230 VOLT 460 VOLT 575 VOLT
NO.
1 CONTROL PANEL 1 F1330001 F1330001 F1330000 F1330078
2 SIZE “K” STARTER 1 N/A N/A FRN18960 <
2 SIZE “N” STARTER 1 FRN18963 < N/A N/A
2 SIZE “S” STARTER 1 N/A N/A N/A N/A
3 SIZE “A” STARTER (FAN) AIR COOLED ONLY 1 FRN18959 < < <
3 SIZE “B” STARTER (FAN) AIR COOLED ONLY 1 N/A N/A N/A N/A
7 TRANSFORMER, 150VA,FUSED, 120V 1 F1330075 < < F1330055
7 TRANSFORMER, 250VA,FUSED, 120V 1 N/A N/A N/A N/A
RSB 8 FUSE, TRANSFORMER, PRIMARY 2 FRN18345-1 < < <
40 9 FUSE, TRANSFORMER, SECONDARY 1 FRN18351 < < <
24 HEATER - MAIN (NOT SHOWN) 1 FRN18990 FRN18989 FRN18982 FRN18981
25 HEATER - FAN (NOT SHOWN) AIR COOLED ONLY 1 FRN18975 FRN18974 FRN18972 FRN18971
26 FUSE, FAN (NOT SHOWN) AIR COOLED ONLY 3 FRN18317-1 FRN18317 FRN18316-1 FVE396
1 CONTROL PANEL 1 F1330061 F1330001 F1330000 F1330078
2 SIZE “K” STARTER 1 N/A N/A FRN18960 <
2 SIZE “N” STARTER 1 N/A FRN18963 N/A N/A
2 SIZE “S” STARTER 1 FRN18860 N/A N/A N/A
3 SIZE “A” STARTER(FAN) AIR COOLED ONLY 1 N/A FRN18959 < <
3 SIZE “B” STARTER(FAN) AIR COOLED ONLY 1 FRN18950 N/A N/A N/A
RSB
7 TRANSFORMER, 150VA,FUSED, 120V 1 N/A F1330075 < <
50
7 TRANSFORMER, 250VA,FUSED, 120V 1 F1330076 N/A N/A N/A
8 FUSE, TRANSFORMER, PRIMARY 2 FVE385 FRN18345-1 < <
9 FUSE, TRANSFORMER, SECONDARY 1 FRN18354 FRN18351 < <
24 HEATER - MAIN (NOT SHOWN) 1 FRN18972 FRN18990 FRN18983 FRN18982
25 HEATER - FAN (NOT SHOWN) AIR COOLED ONLY 1 FRN18976 FRN18975 FRN18973 FRN18972
26 FUSE, FAN(NOT SHOWN) AIR COOLED ONLY 3 FVE399 FRN18317-1 FRN18316-2 FRN08316-1

Table 2: CONTROL PANEL, HEATERS AND FUSES

17
 CAP 297-1

ITEM 200 230 460 575

DESCRIPTION QTY
NO VOLT VOLT VOLT VOLT

1 CONTROL PANEL ASSEMBLY 1 F1330089 F1330088 F1330088 F1330088

2 SIZE “N” STARTER 1 RN18963 N/A N/A N/A
SIZE “K” STARTER 1 N/A FRN18960 FRN18960 FRN18960
CONTACTOR REV. M1-S/M1-S WITH
31 1 FRN18540 N/A N/A N/A
NO/NC, SIZE “N”
SIZE “K” 1 N/A FRN18536 FRN18536 FRN18536
RSB 3 SIZE “E” STARTER (FAN) 1 FRN18965 FRN18965 FRN18965 FRN18965
40-50
7 TRANSFORMER, 250VA, FUSED, 120V 1 F1330076 F1330054 F1330054 F1330054
8 FUSE, TRANSFORMER, PRIMARY 2 FVE334 FVE334 FVE334 FVE334
9 FUSE, TRANSFORMER, SECONDARY 1 FRN18393 FRN18393 FRN18393 FRN18393
24 HEATER - MAIN 1 FRN18988 FRN18983 FRN18981 FRN18980
25 HEATER - FAN 1 FRN18975 FRN18975 FRN18973 FRN18972
26 FUSE, FAN 3 FVE399 FVE399 FRN18316-3 FRN18316-2

TABLE 3. CONTROL PANEL, STARTERS, HEATERS AND FUSES – Y-DELTA

18
 CAP297-1

OPTIONAL ELECTRIC DRAIN

16
7 3 12 9 11
8 6

15
13
1
14 14 2
12 3 8 6 2 1 5 4 11
13 4
9 14
26 19 5 10
6
OPTIONAL AUTOMATIC TANK DRAIN

7 1
16
20 21 5 6 9 11 12
23 13 15
8 21
24 14
22
9 25
18 17
17 OPTIONAL
11 FEATURE
16
27 15 8 13 3 2 7 4 12
1
10 11
10 1
NOTE: OPTIONAL FEATURES

Tank And Base Group

19
 CAP297-1

PART LIST FOR THE RSB40-50 TANK MOUNTED

ITEM PART NUMBER
DESCRIPTION Q
NO RSB 40 RSB 50
1 SCREW,5/16-18 X 3/4" GRADE 5 1 FVH12HH1 <
2 LOCKWASHER-KANTLINK-SPLIT 1 FVH35H <
3 WASHER-FLAT-CUT 5/16" 1 FVH32H <
4 MOUNTS-VIBRATION 1 FRN60255 <
6 NIPPLE 1/4 X CLOSE 1 FPTN0200AG <
7 VALVE-BALL 1/2" 1 2104010213 <
8 ELBOW, 1/4" X 1/4", 90 DEGREE MALE (LONG) 2 FRN52150-2 <
9 BUSHING, 2"NPT X 1 1/4"NPT GALV 1 FPTB0907AG <
10 ASME TANK 200 GAL GRASS 1 FOFD247A <
11 BUSHING 1" X 3/4" 1 FPTB0605AG <
12 PLUG-SQUARE HEAD-STEEL 1/4" 1 F1479239 <
13 PLUG-SQUARE HEAD-CORED 1 1/4" 1 F1030004 <
14 PLUG- SQUARE HEAD-STEEL 1/2" 2 FPTP04AG <
15 BUSHING 3/4 X 1/2" 1 FPTB0504AG <
16 NIPPLE-CLOSE 1/2" 1 FPTN0400AG <
19 ELBOW-STREET 1/4" 1 FVAA754 <
21 GAUGE,AIR 2"DIAL,1/4"NPT BACK MOUNT CONN., 0-300 PSI 2 FRN30323 <
22 ELBOW-90 DEGREE 1/4" 1 FVAA754 <
23 TEE 1/4" 150# M.I. 1 FPTT02AG <
24 CONNECTOR 1 1/4" NPT X 1 1/4" OD. 1 FVAA722 <
25 TUBING-NYLON 1/4" 1 FVA1626 <
26 HOSE ASSY 1 FRN60144 <
27 DRAIN COCK 1/4" 1 FVV514 <

20
 CAP297-1

OPTIONAL ELECTRIC DRAIN

ITEM PART NUMBER
DESCRIPTION Q
NO RSB 40 RSB 50
1 BALL VALVE-3/8", 200# PRESSURE 1 FVV539 <
2 TEE-BLACK 3/8" 1 FPTT03AB <
3 NIPPLE-GALV. 3/8 X 6" 1 FPTN0317AG <
4 UNION-GROUND JOINT-GALV. 3/8" 1 FVAC806 <
5 NIPPLE-GALV. 3/8 X 3" 2 FPTN0311AG <
6 BUSHING 3/8 X 1/4, GALV 2 FPTB0302AG <
7 NIPPLE-GALV.-CLOSE 3/8" 1 FPTN0311AG <
8 DRAIN COCK 1/4" 1 FVV514 <
9 LOCK WASHER ZINC PLATED 1/4" MEDIUM 4 FVH35F1 <
10 NUT-FINISHED-HEX 1/4-20 ZINC PLATED 2 FVH15F1 <
11 WASHER FLAT CUT 1/4" 4 FVH32F1 <
12 HHCS 1/4-20 X 3/4" LONG ZINC PLATED 2 FVH12FF1 <
13 BRACE-AUTO. DRAIN PIPING 1 FOFE950 <
14 DRAIN, AUTO-TIMER,1/60/115V 300PSI 7/16" ORIFICE, 3/8" 1 FVA536-1 <
15 U BOLT #401 1 FVH2202 <
16 BUSHING-GALV. 1/2 X 3/8" 1 FPTB0403AG <
OPTIONAL AUTOMATIC DRAIN
ITEM DESCRIPTION Q PART NUMBER
NO RSB 40 RSB 50
1 CONDENSATE AUTOMATIC DRAIN #508 3/8"NPT 175 PSIG 1 FVAA511 <
2 BALL VALVE-3/8", 200# PRESSURE 1 FVV539 <
3 TEE 3/8 PIPE GLV 1 FVA10CF <
4 UNION-GROUND JOINT-GALV. 3/8" 1 FVAC806 <
5 NIPPLE-GALV.-CLOSE 3/8" 1 FPTN0300AG <
6 NIPPLE-GALV. 3/8 X 6" 1 FPTN0317AG <
7 NIPPLE-GALV. 3/8 X 3" 2 FPTN0311AG <
8 DRAIN COCK 1/4" 1 FVV514 <
9 HHCS 1/4-20 X 3/4" LONG ZINC PLATED 2 FVH12FF1 <
10 NUT-FINISHED-HEX 1/4-20 ZINC PLATED 2 FVH15F1 <
11 LOCK WASHER ZINC PLATED 1/4" MEDIUM 4 FVH35F1 <
12 WASHER FLAT CUT 1/4" 4 FVH32F1 <
13 BUSHING 3/8 X 1/4", GALV 2 FPTB0302AG <
14 BRACE-AUTO. DRAIN PIPING 1 FOFE950 <
15 U BOLT #401 1 FVH2202 <
16 BUSHING-GALV. 1/2 X 3/8" 1 FPTB0403AG <
17 TUBING-NYLON 1/4" 1 FVA1601 <

21
 CAP 297-1

ENCLOSURE GROUP

22
 CAP 297-1

PARTS LIST FOR ENCLOSURE GROUP

ITEM DESCRIPTION QTY RSB 40-50

1 FRONT PANEL 1 FRN10042-1F

1A FRONT PANEL – FOR C-H CONTROL PANEL 37.5" X 21.5" 1 FRN10042D-1F
2 LEFT SIDE PANEL 1 FRN10042-2F
3 RIGHT SIDE PANEL 1 FRN10042-3F
4 BACK PANEL 1 FRN10042-4F
5 TOP PANEL 2 FRN10042-5F
6 TOP CROSS SUPPORT 1 FRN10042-6DG
SCREW, SOCKET HEAD CAP, BUTTON HEAD, 1/4-20 x 1
7 8 FVH1737
1/2” LG .
8 SCREW 1/4-20 X 7/8”LG. 8 FVH12FG1
9 LOCKWASHER, 1/4” 8 FVH35F1
10 WASHER, FLAT, 1/4” 8 FVH32F1
11 GAUGE, AIR PRESSURE, 2 1/2”, LIQUID FILLED 2 FRN30322
CONNECTOR 1/4”OD X 1/4”NPTF,COMPREESION
12 2 FRN52150-7
STRAIGHT
13 TEE RUN 1/4”OD X 1/4”OD X 1/4”NPT 2 FVA745
14 TUBING 1/4"OD, BLACK NYLON - FVA1626
16 LATCH 4 FCS914
17 LOCKWASHER, INTERNAL TOOTH, 1/4” 12 FVH38F
18 PIN 8 FRN10020-1F
19 CONTROL PANEL, C-H (USE WITH FRONT PANEL (1A) 1 N/A
20 WEATHER STRIP (USE WITH FRONT PANEL (1A) 10FT FRN60424

23
 ROUTINE MAINTENANCE KITS
FS-Curtis Maintenance Kits Quick Reference
RSB40-50
KIT PART # INTERVAL Kit Includes
AIR FILTER PRIM FRN24077-1
AIR FILTER SEC FRN24077-2
2000 Hour Service Kit FSK-1RS4050 2000 hour
OIL FILTER FRN28201
OIL ANALYSIS KIT FVO701
AIR FILTER PRIM FRN24077-1
AIR FILTER SEC FRN24077-2
4000 Hour Service Kit FSK-4RS4050 4000 hour OIL FILTER FRN28201
OIL ANALYSIS KIT FVO701
SEPARATOR ELEMENT FRN27518
AIR FILTER PRIM FRN24077-1
AIR FILTER SEC FRN24077-2
6000 Hour Service Kit FSK-1RS4050 6000 hour
OIL FILTER FRN28201
OIL ANALYSIS KIT FVO701
FILTER ELEMENT OIL FRN28201
FILTER PRIMARY FRN24077-1
FILTER SAFETY FRN24077-2
SEPARATOR ELEMENT FRN27518
FSK-8RS4050-1 INLET VALVE DN65 2104050162
8000 Hour Service Kit 8000 hour
KIT FOR RN42403 THERM VLVE FRN42403-1
KIT MIN PRESSURE VALVE KIT FRN42126-1
OIL SAMPLE TEST FVO701-POL

Order Service Parts under FS Curtis Part Number

Always use FS-Curtis genuine parts and lubricants.

All RSB rotary screw air compressors are shipped fully charged with factory fluid
Fluid part # FSC-8000-5 (5 gallon pail)

24
 Curtis-Toledo, Inc.

1905 Kienlen Avenue | St. Louis, Missouri 63133

314-383-1300 or 800-925-5431

www.fscurtis.com | [email protected]