KENR7088-01 Harness And Wire Electrical Schematic Symbols

April 2012
Symbols

Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
Component Location through it.
Schematic Machine Schematic Machine
Component Component
Location Location Location Location
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
Air Compressor #1 I-1 21 Relay - Main D-3 B circle indicates that the component has screw terminals and a wire can be disconnected from it.
Alarm - Backup D-11 C Relay - Neutral Start #1 B-3 B
Alternator A-8 C Relay - Neutral Start #2 A-3 B Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
Batteries B-9,B-10 1 Relay - Neutral Start #3 B-2 B No circle indicates that the wire cannot be disconnected from the component.
2 13 Breaker - Alternator B-9 C Relay - Starter B-9 C
3 Ground (Wired): This indicates that the component is connected to a grounded wire. The
8 16 5 Breaker - Battery B-9 C Relay - Water Spray Timer B-1 B
grounded wire is fastened to the machine.
7 Breaker - Glow Plugs B-8 C Resistor - Lift Pump B-11 C
4 11 15 Breaker - Lights D-3 B Sender - Engine Coolant Temperature C-12 C
Ground (Case): This indicates that the component does not have a wire connected to ground.
Breaker - Throttle D-3 B Sender - Engine Oil Pressure C-12 C It is grounded by being fastened to the machine.
Distributor - Air Valve #1 I-1 21 Sender - Hydraulic Oil Temperature C-11 9
Distributor - Air Valve #2 I-1 21 Sensor - Rear Speed C-10 10 Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
6 Flasher C-2 B Solenoid - 2 Speed A-11 11 contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

PS-360C Pneumatic Compactor

Fuses G-3,G-4 A Solenoid - Brake A-11 11
Gauge - Engine Coolant Temperature H-6 A Solenoid - Injection Pump B-11 C Sender: A component that is used with a temperature or pressure gauge. The sender
17 Gauge - Engine Oil Pressure H-7 A Solenoid - Interlock A-11 15 measures the temperature or pressure. Its resistance changes to give an indication to

Electrical System
T
the gauge of the temperature or pressure.
C Gauge - Ground Speed Tachometer H-5 A Solenoid - Lift Pump B-11 C
1 21 Gauge - Hydraulic Oil Temperature H-6 A Solenoid - Throttle Control C-10 C
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
Glow Plugs B-7 C Switch - 2 Speed B-4 B
It has a coil that makes an electromagnet when current flows through it. The
Ground - Engine Block B-10 C Switch - Air Compressor I-2 12 electromagnet can open or close the switch part of the relay.
Ground - Engine Block #2 A-9 C Switch - Air Distributor I-2 12 PJF1-UP
Ground - Frame #2 C-11 2 Switch - Backup Alarm A-4 B Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
B Horn - Warning F-6 18 Switch - Brake B-3 B coil that makes an electromagnet when current flows through it. The electromagnet
Lamp - Front Turn Signals F-1,G-1 3 Switch - Cold Start Temperature A-12 C can open or close a valve or move a piece of metal that can do work.
12
19 Lamp - Front Working G-1 4 Switch - Disconnect C-9 13
Lamp - Rear Turn Signals D-11,E-11 5 Switch - Emulsion Spray E-3 B Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
Lamp - Rear Working D-11 6 Switch - Key F-6 A
that make electromagnet when current flows through them. It also has an internal switch that places
9 Meter - Hour I-4 A Switch - Lights D-2 B the latch coil circuit open at the time the coil latches.
18 A Module - Timer A-6 B Switch - Neutral Start B-11 15
20 6 Motor - Emulsion Spray B-7 7 Switch - Starting Aid G-6 A Harness and Wire Symbols
10 Motor - Front Water Pump H-2 8 Switch - Throttle H-3 A
Wire, Cable, or Harness Harness Identification Letter(s):
Motor - Starter B-9 C Switch - Turn Signal C-3 B
Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
Potentiometer - Water Spray (OFF) E-1 B Switch - Warning Horn A-4 B
4 Harness Identification Letters and
Harness Connector Serialization
Harness Connector Serialization Code:
Potentiometer - Water Spray (ON) E-1 B Switch - Water Spray A-1 B The "C" stands for "Connector" and the
Codes (see sample).
3 5 Relay - Brake #1 A-2 B Timer - Water Spray E-1 B number indicates which connector in the
harness (C1, C2, C3, ...).
Relay - Brake #2 A-2 B Unit - Cold Start Timing A-12 C AG-C4 L-C12 L-C12
111-7898 3E-5179 3E-5179
Relay - Glow Plugs B-8 C
Machine locations are repeated for components located close together. Part Number: for Connector Plug 1
Part Number: for Connector Receptacle
A = Located on or inside of instrument console. 2
B = Located on or inside of right console.
C = Located inside of engine compartment. Plug Receptacle
Pin or Socket Number
5A
1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color

© 2012 Caterpillar Printed in U.S.A.

All Rights Reserved

Wire Description
Wire Wire
Wire Color Description Wire Color Description
Number Number
Power Circuits Monitoring Circuits (Continued)
105 BR Key Switch 419 YL Brake Switch to Brake Relay #1 and #2
105 RD Product Link 440 BR Air Distrb. Switch to Air Distrb. Valve #1
109 RD Main Power Relay Input 441 OR Eng. Coolant Temp. Sender to Temp. Gauge
110 GN Water Spray Switch 448 WH Air Distrb. Switch to Air Distrb. Valve #2
112 PU Main Power Relay Output 449 WH Rear Speed Sensor to Speed Tachometer
114 GN Light Switch to Light Breaker 476 PU Eng. Oil Press. Sender to Oil Press. Gauge

(Dimensions: xx inches x xx inches)

121 YL Backup Alarm Accessory Circuits
123 WH Gauges/Speed Tach 537 GN Turn Signal Switch to Flasher
128 PK Warning Horn (Forward) A541 PU Turn Signal Switch to Turn Signal Indicator
135 BU Emulsion Spray Switch Lighting Circuits
12 Connector Location 148 WH Start Aid Switch 605 YL LH Turn Lamps
Schematic Machine 155 PK Brake Switch 606 GY RH Turn Lamps

KENR7088-01
Connector Number
A Location Location 172 GN Tire Inflation 608 GN Rear Working Lamps
CONN 1 Product Link C-11 16 173 YL Flasher 614 PU LH & RH Tail Lamps
CONN 2 D-7 17 177 RD Battery Breaker to Glow Plug Breaker 619 GN Front Working Lamps
CONN 3 C-7 17 Resistor, Sender and Solenoid Specifications 181 GY Throttle Breaker Control Circuits

18 B CONN 4 A-7 17 Part No. Component Description Resistance (Ohms)¹ 185 YL Air Compressor Switch to Air Compressor 720 BU Neutral Start Relay #2 to Brake Relay #2

CONN 5 F-5 18 030-2010 Sender: Engine Oil Pressure 10.5 ± 5.5 308 YL Key Switch to Main Relay 751 GN 2 Speed Switch to 2 Speed Switch Solenoid
19 20 CONN 6 F-4 18 Engine Coolant Temperature 5806 - 7264 @ 54.4°C Ground Circuits 765 BR Brake Switch to Brake Relay #1
6N-5926 Sender:
Hydraulic Oil Temperature 524 - 586 @ 115.6°C 200 BK Main Chassis 777 PU Brake Switch Solenoid
CONN 7 F-4 18
¹ At room temperature unless otherwise noted. Basic Machine Circuits A893 OR Emulsion Spray Sw. to Emulsion Spray Motor
CONN 8 F-4 18
304 WH Starter Relay No. 1 Output A919 BU Throttle Control Solenoid to Timer Module
CONN 9 F-2 19
306 GN Starter Relay Coil A982 BR Throttle Switch to Timer Module
CONN 10 F-2 8
C 307 OR Key Switch to Neutral Start Relay #1 A983 BU Throttle Control Solenoid to Timer Module
6 CONN 11 D-9 20
308 YL Key Switch to Main Relay C904 GN Water Spray Switch to Spray Timer Relay
21 CONN 12 I-2 21
309 GY Alternator Output (D+) to Alternator Indicator C922 BR Water Spray Sw. to Front Water Pump Motor
4 3 13
The connectors shown in this chart are for harness to harness connectors. 321 BR Backup Alarm to Backup Alarm Switch F874 PK Water Spray Sw. to Water Spray Timer
Connectors that join a harness to a component are generally located at or near
322 GY Warning Horn (Forward) to Warning Switch F875 PK Water Spray Timer Relay to Water Spray Timer
11 15 the component. See the Component Location Chart.
7 Off Machine Switch Specification
326 PU Fuel Pump Solenoid to Fuel Pump Resistor N927 PU Water Spray Timer (OFF) to Potentiometer
17 9 330 YL Neutral Start Switch to Neutral Start Relay N928 OR Water Spray Timer (OFF) to Potentiometer
Part No. Function Actuate Deactuate Contact Position 384 GN Glow Plug Relay to Glow Plugs N929 YL Water Spray Timer (ON) to Potentiometer
8 1 16 5 107 ± 3°C 93°C MIN Monitoring Circuits N930 BR Water Spray Timer (ON) to Potentiometer
2 3E-2028 Cold Start Temperature
(224.6 ± 5.4°F) (199.4°F MIN)
Normally Closed
403 GN Alternator to Hour Meter R810 GN Start Aid Switch to Glow Plug Relay
406 PU Hyd. Temp. Sender to Hyd. Temp Gauge
10

30 Page,
 12 11 10 9 8 7 6 5 4 3 2 1

200-C35 BK-16
200-C34 BK-16
200-C33 BK-16
200-C32BK-16 HARNESS AS HARNESS AS
200-C31 BK-16
200-C30 BK-16 264-3081 264-3036

200-C29 BK-16
614-C40 PU-16 614-C36 PU-16 CP-C50 AIR COMPRESSOR 1
3E3361 1434796
614-C39 PU-16
614-C37 PU-16 HARNESS AS - INSTRUMENT 185-CP1 YL-16 1
2
251-1079 AIR COMPRESSOR SW
8D2676
172-C64 GN-16
A-C101 CP-C49
I 1552272 3E3376 CP-C103 AIR DISTRIBUTION
1176004
VALVE 1
I
185-A1 YL-16 1 1217602
440-A2BR-16 440-CP2BR-16 1
448-A3WH-16 2
172-C65GN-16
123-C52 WH-16 CONN 12

172A-CP4 GN-16
HOUR METER
123-C53WH-16 1978832
AIR DISTRIBUTOR SW CP-C102 AIR DISTRIBUTION
1176004
VALVE 2
123-C54 WH-16 1V6652 1217602
- + 448-CP3 WH-16 1

614-C39 PU-16
200-C33 BK-16
614-C40 PU-16
123-C52 WH-16

123-C54 WH-16

200-C31 BK-16

614-C37 PU-16
123-C53 WH-16
172-C63 GN-16 2

614-C38 PU-16
200-C35 BK-16
SIG

105-C42 BR-16
200-C28 BK-16

403-C21 GN-16
172-C65GN-16

200-CP8 BK-16
200-CP7 BK-16
200-CP6 BK-16
200-CP5 BK-16
ABBREV COLOR
SYMBOL DESCRIPTION C-C52 C-C51 C-C53
1135183 1135183 1135183
RD RED
CIRCUIT CONNECTED
THROTTLE SW
ENGINE OIL PRESSURE ENGINE COOLANT TEMP HYDRAULIC OIL TEMP GROUND SPEED TACH 8D2676
WIRE GROUP COLOR DESCRIPTIONS WH WHITE 1309153 1104731 1104732 1453343

200-C34 BK-16

200-C30 BK-16
200-C32 BK-16

200-C29 BK-16
CIRCUIT NOT CONNECTED
OR ORANGE
GROUND CIRCUIT ELECTRICAL CONNECTION TO
C-C48 C-C47 C-C49 C-C46 123-C49 WH-16

I
S
G

I
S
G

I
S
G

I
S
G
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF YL YELLOW
MACHINE STRUCTURE
1141749 1141749 1141749 1141749 123-C50 WH-16
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON INTERNAL ELECTRICAL CONNECTION FRAME GROUND 5
TO SURFACE OF COMPONENT
PK PINK 123-C51 WH-16
STARTING CIRCUIT 200-C27BK-16

123-C50 WH-16

123-C51 WH-16
123-C49 WH-16
449-C9 WH-16

A982-C23 BR-16
181-C22 GY-18
BK BLACK
START AID CIRCUIT CONNECTOR 406-C8 PU-16
GY GRAY 441-C7 OR-16
MONITOR CIRCUIT (VIMS) / (CMS) / (EMS) / (OTHER) H# CIRCUIT GROUPING DESIGNATION
476-C6 PU-16
TURN SIGNAL / WIPER WASHER CIRCUIT 200-C28BK-16
HARNESS AS
PU PURPLE

PU-16
PU-16
WH-16
OR-16
W-C17

614-C11 PU-16

200-C26 BK-16
170-8578
ATCH WIRE, CABLE, COMPONENT
1552269
H OTHER COLOR DESCRIPTIONS BR BROWN
1 200-W2 BK-16 H

476-C6
406-C8
449-C9
441-C7
FRONT WATER PUMP

403-C21 GN-16
SPLICE GN GREEN MOTOR 2
HIGHWAYS 2457713
BLADE, SPADE, RING OR SCREW BU BLUE
TERMINAL
FRAME GROUND 4
105-C42 BR-16 C922-W1 BR-16

C922-W1 BR-16
105-C24 BR-16

105-C43 BR-16

172-C62 GN-16
HARNESS AS
170-8577
112-C12PU-6

123-C20 WH-16
112-C62 PU-6
LF-C10 LF-C9
1552267 3E3370 200-LF9 BK-16
605-LF3 YL-16 A S LH SIGNAL LIGHT
614-LF6 PU-16 B T 1475578
STARTING AID SW 109-C13RD-6 C
9D3721 KEY START FUSE GAGES SPEED SENSOR FUSE
10A 109-C47RD-6 10A
148-C41WH-16 FRAME GROUND 3

112-C55 PU-6
112-C56 PU-6
112-C57 PU-6
112-C58 PU-6
112-C59 PU-6
112-C60 PU-6
112-C61 PU-6
R810-C5 GN-16

105-C44 BR-16
200-LF13 BK-16

WARNING HORN FUSE FLASHER FUSE

G 10A 109-C48 RD-6 10A 173-C19YL-16 WORKING LAMP LH FT G
619-LF8 GN-16
9X4381

128-C14 PK-16
200-LF12 BK-16

BRAKE FUSE WATER SPRAY FUSE

10A 15A 110-C18GN-16 619-LF7 GN-16
WORKING LAMP RH FT
9X4381
ALTERNATOR INDICATOR

614-LF1 PU-16

619-LF4 GN-16
KEY SW 2N2371 2V7807

155-C17 PK-16
148-C41 WH-16
9G7641
200-LF11 BK-16
R LF-C7 LF-C8
308-C46YL-16 308-C45 YL-16 309-C4GY-16 1552267 3E3370
OFF C 308-C3YL-16 606-LF2 GY-16 A S
STARTING AID FUSE FUEL SPRAY FUSE 614-LF5 PU-16 B T RH SIGNAL LIGHT
ON S 307-C2OR-16 15A 15A 135-C15BU-16 1475579
ST B C
105-C44BR-16

200-C26 BK-16
200-LF10 BK-16

614-C11 PU-16
441-C7 OR-16
406-C8 PU-16
449-C9 WH-16
476-C6 PU-16
C-C99
1552269
WARNING HORN BK-18 1 200-C25 BK-16 200-C25 BK-16
1631201 BK-18 2 322-C1GY-16 BACK-UP ALARM FUSE TIRE INFLATION FUSE
15A 15A 172-C62GN-16

R810-C5 GN-16
322-C1 GY-16
307-C2 OR-16
308-C3 YL-16
309-C4 GY-16
200-C10 BK-16

A982-C23 BR-16
181-C22GY-18
F F

403-C21GN-16
R810-C5 GN-16
309-C4GY-16

200-C10BK-16
614-C11PU-16
476-C6 PU-16
441-C7 OR-16
406-C8 PU-16
449-C9 WH-16
307-C2OR-16
322-C1GY-16
308-C3YL-16

109-C13 RD-6

C922-W1 BR-16
105-C24 BR-16
112-C12 PU-6

A982-C23 BR-16
181-C22 GY-18
135-C15 BU-16
121-C16 YL-16

403-C21 GN-16
128-C14 PK-16

155-C17 PK-16
110-C18 GN-16
173-C19 YL-16
123-C20 WH-16

614-LF1 PU-16
606-LF2 GY-16
605-LF3 YL-16
619-LF4 GN-16
HARNESS AS
C-C1 C-C3 C-C4 C-C2 W-C16 LF-C17 170-8577
3E5179 9G4351 3E3364 1552272
HARNESS AS - ENGINE 9G4348 1552252

10
11
12
1
2
3
4
5
6
7
8
9

1
2
1
251-1982 M-C1 M-C3 M-C4

10
11
12
M-C2 M-C16 M-C17

1
2
3
4
5
6
7
8
9

1
2
3
4
1552252 9G4348 9G4351 3E5179 1552269 3E3376
HARNESS AS - MAIN

109-M29 RD-6
CONN 5 CONN 6 CONN 7 CONN 10 CONN 9

322-M23GY-16
307-M24OR-16
308-M25YL-16
309-M11GY-16
R810-M21GN-16
476-M7 PU-16
441-M8 OR-16
406-M6 PU-16
449-M10WH-16
200-M26BK-16
614-M27PU-16
CONN 8

A982-M37 BR-16
112-M28 PU-6

128-M30 PK-16
135-M31 BU-16
121-M32 YL-16
155-M33 PK-16
110-M34 GN-16

181-M36 GY-16
105-M12 RD-16
173-M35 YL-16
403-M9 GN-16

C922-M38 BR-16
251-1989

614-M39 PU-16
606-M40 GY-16
605-M41 YL-16
619-M42 GN-16
135-M31 BU-16
173-M35 YL-16
A982-M37 BR-16
181-M36 GY-16
110-M34 GN-16
105-M12 RD-16

121-M32 YL-16
128-M30 PK-16
155-M33 PK-16
403-M9 GN-16
476-M7PU-16
441-M8OR-16
406-M6PU-16
449-M10WH-16

308-M25YL-16
309-M11GY-16
R810-M21GN-16
614-M27PU-16

200-M26BK-16

322-M23GY-16
307-M24OR-16
EMULSION SPRAY SW
9D3721 POTENTIOMETER
1379997
135-M31BU-16

E E

N928-M89 OR-16
N927-M90 PU-16

N929-M88 YL-16
N930-M87 BR-16
E-C35 E-C36
3E3376 1552272
S RD-16 1 605-E35 YL-16 605-E35 YL-16
LEFT TURN/TAIL LAMP T WH-16 2 200-E39 BK-16
1478567 T BR-16 3 614-E34 PU-16 614-E34 PU-16 7 6 5 4
BK-16 4 A893-M22 OR-16 WATER SPRAY TIMER OFF ON
1379996 TIME TIME
1 2 3

HARNESS AS
608-L2 GN-16 262-4804

614-M39 PU-16
606-M40 GY-16
605-M41 YL-16
WORKING LAMP LH
9X4381
200-L5 BK-16
L-C1 E-C48 C922-M38BR-16
3E3364 1552269

F875-M92 PK-16
608-L1 GN-16 1 608-E30 GN-16 109-M43 RD-6

C922-M38 BR-16

F874-M91 PK-16
200-M68 BK-16
200-L4 BK-16 2 200-E41 BK-16 476-M7 PU-16
(Dimensions: 39 inches x 28 inches)

441-M8 OR-16 181-M83GY-16

CONN 11 406-M6 PU-16
E-C5 M-C5 449-M10 WH-16
3E5179 1552252 403-M9 GN-16 403-M9 GN-16
1 614-M2 PU-16 614-M39 PU-16

A982-M37 BR-16
110-M34 GN-16
121-M32 YL-16
128-M30 PK-16
155-M33 PK-16
608-L3 GN-16 605-E35 YL-16 2 605-M1 YL-16

181-M62GY-16

109-M58 RD-6

112-M28 PU-6
WORKING LAMP RH 614-E33 PU-16 614-E32 PU-16 3 614-M2 PU-16
9X4381 606-E38 GY-16 606-E38 GY-16 4 606-M3 GY-16
200-L6 BK-16 321-E31 BR-16 321-E31 BR-16 5 321-M4 BR-16 321-M4 BR-16 321-M4 BR-16
608-E30 GN-16 608-E30 GN-16 6 608-M5 GN-16
D 406-E29 PU-16 7 406-M6 PU-16 D
KENR7088-01

200-E39 BK-16

E-C29 476-E28 PU-16 8 476-M7 PU-16 608-M5 GN-16 608-M5 GN-16 608-M5 GN-16
1552269 441-E27 OR-16 9 441-M8 OR-16 605-M1 YL-16 605-M1 YL-16 LIGHT BREAKER
BACKUP ALARM BK-18 1 321-E31 BR-16 403-E27 GN-16 10 403-M9 GN-16 606-M3 GY-16 606-M3 GY-16 MAIN RELAY
6T3643

619-M42 GN-16
2418368
2441090 BK-18 2 200-E21 BK-16 11

606-M3 GY-16
605-M1 YL-16
449-E26 WH-16 449-E26 WH-16 12 449-M10 WH-16 112-M79 PU-6 15A 114-M80GN-12
CONN 2

2360872
E-C50 E-C37

BAR BUS
THROTTLE BREAKER
3E3376 1552272 6T3643
403-E27 GN-16
S RD-16 1 606-E38 GY-16
RIGHT TURN/TAIL LAMP T WH-16 2 200-E43 BK-16 200-E43 BK-16 B
15A
1478566 T BR-16 3 614-E33 PU-16 200-M13BK-16 M-C11 614-M81 PU-16

1
2
T-D

181-M83 GY-16
BK-16 4 200-M76 BK-16 3E3364
109-M43 RD-6
308-M20YL-16 308-M75 YL-16
200-E50 BK-16 200-E50 BK-16 E-C8 M-C8 309-M11GY-16 200-M78 BK-16 H
403-E49 GN-16 1552252 3E5179 R810-M21GN-16 606-M40GY-16 608-M5 GN-16
200-E42 BK-16 200-E42 BK-16 309-E25 GY-16 1 309-M11 GY-16 605-M41YL-16 R
200-E6BK-16 105-E24 RD-16 105-E24 RD-16 2 105-M12 RD-16 105-M12 RD-16 105-M12 RD-16
200-E17 BK-16 200-E40 BK-16 200-E48 BK-16 200-E23 BK-16 3 200-M13 BK-16 A893-M22 OR-16 A893-M22 OR-16 LIGHT SW
3K1650
200-E41 BK-16 E-C30 777-E2 PU-16 777-E2 PU-16 4 777-M14 PU-16 TURN SIGNAL SW TURN SIGNAL INDICATOR LAMP
REAR SPEED SENSOR 1552267 A919-E19 BU-16 5 A919-M15 BU-16 1733064 7N5876

200-M48 BK-16
200-M49 BK-16
322-M23GY-16
1230960 A A983-E10 BU-16 6 A983-M16 BU-16 A541-M86 PU-16 2
BK B 200-E48 BK-16 306-E37 GN-16 7 306-M17 GN-16
WH C 449-E26 WH-16 751-E1 GN-16 751-E1 GN-16 8 751-M18 GN-16 3
FRAME GROUND #2 330-E16 YL-16 9 330-M19 YL-16

A541-M85 PU-16
E-C25 308-E11 YL-16 10 308-M20 YL-16 M-C62 FLASHER

200-M77 BK-16
3E3379 R810-E36 GN-16 11 R810-M21 GN-16 5C6158 8V2514
1 105-E24 RD-16 THROTTLE CONTROL SOLENOID A893-E5 OR-16 12 A893-M22 OR-16 6 49 +BATTERY TURN SIGNAL
2 200-E44 BK-16 1197017 E-C38 C TURN INDICATOR
5
3 308-E52 YL-16 1552269 CONN 3 49A SIGNAL LAMPS
309-E25 GY-16
403-E45 GN-16

4 403-E49 GN-16 BK-18 1 A919-E19 BU-16 4 1 30B +BATTERY HAZARD

5 BK-18 2 A983-E10 BU-16 31 GROUND
6 CONN 1 537-M84 GN-16 C2 TUV INDICATOR
ENGINE OIL PRESSURE SENDER PRODUCT LINK 777-E2 PU-16 173-M35 YL-16 173-M35 YL-16
302010 200-M76 BK-16 200-M76 BK-16
C 751-E1 GN-16 C
476-E28 PU-16
200-E40 BK-16
7N-0781
308-E11 YL-16

6N5926 DISCONNECT SW
HYDRAULIC TEMP SENDER 306-M17 GN-16 306-M17 GN-16 306-M17 GN-16
406-E29 PU-16
ENGINE COOLANT TEMP SENDER CBL-PM RD-00 751-M18 GN-16 751-M18 GN-16
6N5926 T°
A919-M15BU-16
CBL-PC RD-00

441-E27 OR-16 308-E52 YL-16 A983-M16BU-16

J 777-M14 PU-16 777-M14 PU-16 777-M14 PU-16
T°
308-E12 YL-16

307-M24 OR-16 307-M24 OR-16

330-M19YL-16 330-M19YL-16 330-M59 YL-16
30 Page,

200-E17 BK-16 330-M60YL-16

200-E18 BK-16 200-E18 BK-16 CBL-PL RD-00 110-M34GN-16 F875-M92 PK-16

330-M61 YL-16
326-E22 PU-16
E-C27 POS NEG POS NEG
155-2269
A893-E5 OR-16
200-E40 BK-16

1552269 E-C39

110-M63 GN-16
330-M60 YL-16
110-M64 GN-16
RESISTOR AS FUEL PUMP 1552269
1 BK-18 FUEL PUMP SOLENOID BATTERY 2 BATTERY 1 200-M57 BK-16 200-M56 BK-16 C922-M93 BR-16
2 BK-18 BK-18 1 308-E13 YL-16
CBL-PARD-00

3T-5760 3T-5760 C904-M65 GN-16 C904-M66 GN-16

BK-18 2
M-C64 M-C60 M-C66
9X1054 9X1054 9X1054
326-E22 PU-16 E-C21
200-E20 BK-16
308-E14 YL-16
308-E15 YL-16
308-E23 YL-16
330-E16 YL-16

1552269

1
5
2
4
3
1
5
2
4
3

1
5
2
4
3
BK-18 1 306-E37 GN-16

85
86
E-C24

85

85
86

86
BK-18 2 200-E45 BK-16
LIFT PUMP 1552269

C904-M67 GN-16
RD-20 1

87
30
87

87
ENGINE

30

30
BK-20 2 E-C42 E-C23
1
2

87a
87a

87a
SOLENOID ENGINE BLOCK 304-E51 WH-6 1552269 3E3364
E-C28 BK-18 1 R810-E36 GN-16 WATER SPRAY TIMER RELAY
24V RESISTOR 3E3370 118-3534 BK-18 2 200-E50 BK-16 NEUTRAL START RELAY 1 NEUTRAL START RELAY 3
239-5818 A 308-E14 YL-16 STARTER RELAY 3E5239 3E5239 3E5239
B BK-20 BRAKE SW B
RD-20 B 200-E20 BK-16 1805617
C STARTER MOTOR 1165275
2253150 MOTOR 1166565
155-2208
CBL-PK BK-00

CBL-PG RD-6 GLOW PLUG RELAY

G S

751-M18 GN-16
200-M48 BK-16

322-M23GY-16
200-M49 BK-16

128-M30 PK-16
A982-M37BR-16

321-M4 BR-16
181-M62 GY-16

121-M32 YL-16

110-M34 GN-16
155-M33 PK-16

200-M68 BK-16
EMULSION SPRAY PUMP 155-M47 PK-16
BATTERY BREAKER ALT BREAKER 1 2
MTR BAT 1712208 BUSS BAR 9S0174 765-M69BR-16
E-C22 7V9275 384-E51 BU-8 4 419-M71YL-16
1552269 E-C41 155-M45 PK-16
CBL-PH RD-6

1358072 MOTOR 60A 60A GLOW PLUG 3 +

NETURAL START SW BK-18 1 308-E15 YL-16 1275483 2339834 419-M70 YL-16
BK-18 2 330-E16 YL-16 1 -
GLOW PLUG BREAKER 200-M68BK-16
155-M33PK-16 330-M61YL-16
CBL-PARD-00

1712208
200-M55 BK-16

C922-M93 BR-16
177-E46 RD-6 155-M46PK-16
CBL-PJ RD-00

C922-M38 BR-16
110-M64 GN-16
CBL-PE RD-00 GLOW PLUGS
200-E6BK-16

419-M74 YL-16
419-M73 YL-16
FRAME GROUND 2

419-M72 YL-16

200-M56 BK-16
155-M44PK-16

200-M57 BK-16
200-M55 BK-16
COLD START TEMP SW 720-M62 BU-16
3E2028 177-E47RD-6 2 SPEED SW
8D2676
CBL-PF RD-00

308-E23 YL-16 M-C61 M-C65

403-E45 GN-16 NORMALLY
BACKUP ALARM SW OPEN FOR 9X1054 9X1054 4
T° 2500629 LOW SPEED 5

200-M52 BK-16
ENGINE BLOCK 2

765-M69 BR-16
200-M48 BK-16
1
5
2
4
3

1
5
2
4
3
177-E47 RD-6

INTRELOCK SOLENOID 2 SPEED SW SOLENOID BRAKE SW SOLENOID

COLD START 1G9759 1G9759 1G9759

85

85
86

86
200-M51 BK-16
TIMING C904-M67 GN-16
UNIT 3

87

87
2

30

30
2253146

200-M54 BK-16
200-M53 BK-16
87a

87a
ALTERNATOR E-C9 M-C9 WATER SPRAY SW
W 9G4348 9G4351 1V6653
BK-18
BK-18

BK-18
BK-18

BK-18
BK-18

B+ D+ 309-E25 GY-16 1 109-M43RD-6 NEUTRAL START RELAY 2 BRAKE RELAY 2

B- 3E5239 3E5239
CONN 4 TIMER MODULE M-C67 M-C6 200-M52 BK-16

1
2
1607395 1552273 3E3364
1
2

1
2

1
2

E-C26 E-C20 E-C19 +16 TO +32 VDC PWR INOR 1 181-M62GY-16 419-M72 YL-16

200-M49 BK-16
200-M50 BK-16
200-E6 BK-16

A 1552269 1552269 1552269 ENGINE BLOCK 1 - PWR GND IN BK 2 200-M50BK-16 200-M53 BK-16 A
777-E3 PU-16

+ OUT GY 3 A983-M16BU-16 777-M14 PU-16

- OUT BR 4 A919-M15BU-16 WARNING HORN SW

200-M54 BK-16
+ AUX IN WH 5 A982-M37BR-16 3T2357 M-C63
PLUG 6 9X1054
200-E7 BK-16 322-M23GY-16

1
5
2
4
3
200-E8 BK-16
200-E9 BK-16

85
86
200-M49BK-16
777-E4 PU-16 777-E2 PU-16 200-M48BK-16

87
30
200-M50BK-16

87a
751-E1 GN-16
BRAKE RELAY 1 UNLESS OTHERWISE SPECIFIED ALL WIRE IS 16 GAUGE
251-1982 251-1989 3E5239

HARNESS AS - ENGINE HARNESS AS - MAIN

12 11 10 9 8 7 6 5 4 3 2 1

THIS SCHEMATIC IS FOR THE PS-360C PNEUMATIC COMPACTOR

ELECTRICAL SYSTEM
MEDIA NUMBER: KENR7088-01
SCHEMATIC PART NUMBER: 266-3104, CHANGE: 00
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.