MAXIMUM GVW

294840 kg 650,000 lb
PAYLOAD
172 t 190 U.S. ton
GROSS HORSEPOWER
1491 kW 2,000 HP

ELECTRIC DRIVE TRUCK

S
SPECIFICATIONS
PECIFICATIONS
ENGINE FRAME

Make and model . . . . . . . . . . . . . . . . . . . . . Komatsu SSA16V159 Special alloy steel with integral front bumper, rear tubular
Fuel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Diesel cross members, continuous frame rail beam with variable
Number of cylinders . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 section and rugged continuous horsecollar.
Operating cycle. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 stroke Plate material . . . . . . . . . . . . . . . . . . . . . . . . 482.6 mPa 70,000 psi
*Rated brake power . . . . . . . . . . . 1492 kW 2,000 HP @ 1900 rpm tensile strength steel
**Flywheel power . . . . . . . . . . . . . 1388 kW 1,860 HP @ 1900 rpm Top plate thickness . . . . . . . . . . . . . . . . . . . . . . . . . 38 mm 1.50''
Weight (wet) . . . . . . . . . . . . . . . . . . . . . . . . . . . 5293 kg 11,670 lb Bottom plate thickness . . . . . . . . . . . . . . . . . . . . . . . 38 mm 1.50''
NOTE: This engine requires an engine monitor. The only approved monitor is the Flight Systems Engine Saver. Side plate thickness . . . . . . . . . . . . . . . . . . . . . . . . . 16 mm 0.62''
*Rated brake power is the output of the engine as installed in this machine, at governed rpm and with engine
manufacturer’s approved fuel setting. Accessory losses included are water pump, fuel pump and oil pump.
Drive axle mounting. . . . . . . . . . . . . . Ball and socket joint at front
**Flywheel power is the rated power at the engine flywheel minus the average accessory losses. Accessories Drive axle alignment. . . . . . . . Swing link between frame and axle
include fan and charging alternator. Rating(s) represent gross engine performance in accordance with SAE
J1349 conditions.

BRAKING SYSTEM
ELECTRIC DRIVE
Service brakes: all-hydraulic actuated
AC/DC CURRENT Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheel speed disc.
Alternator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . G.E. GTA-22 Three calipers on a 1060 mm 40.00" O.D. disc.
Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . Statex III Fuelsaver Rear . . . . . . . . . . . . . . . . . . . . . . . . . . Dual disc armature speed
*Motorized wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . G.E. 788 Two discs/side. One caliper/disc.
**Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26.82:1 635 mm 25'' O.D.
Speed (maximum) . . . . . . . . . . . . . . . . . . . 51.0 km/h 31.7 mph Emergency brakes . . . . . . . . . . . . . . . Automatically applied prior
to hydraulic system pressure dropping below level
*Wheel motor application depends upon gross vehicle weight, haul road grade, haul road length,
rolling resistance and other parameters. Komatsu and G.E. must analyze each job condition to required to meet secondary stopping requirements.
assure proper application. Wheel brake locks . . . . . . . . . . . . . . . . . . . . . . . Switch-activated
**Optional ratios available.
Parking brakes. . . . . . . . . . . . . . . . . . . . . . . . . . . Spring-applied,
hydraulically released, with speed application protection.
Electric dynamic retarder )max) . . . . . . . . . . . . . 2811 kW 3700 hp
TIRES AND RIMS Continuously rated (18 element) blown grids. Two-speed
Rock service, tubeless, tires (radial or bias ply) overspeed retarding. Extended range retarding. Reverse retarding.
*Standard tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36.00 51
Standard five (5) piece rim
660 mm x 1295 mm x 127 mm 26'' x 51'' x 5'' patented Phase II SUSPENSION
New Generation™ rim assembly with patented 127 mm 5'' double HYDRAIR® II
forged flanges. Not interchangeable with other manufacturers’ rims Variable rate hydro-pneumatic with integral rebound control.
due to improved design for greater load support and longer fatigue Max. front stroke .......................................................335 mm 13.2''
life. Rated at 827 kPa 120 psi cold inflation pressure. Max. rear stroke ........................................................409 mm 16.1''
*Tires should meet application requirements for tkph/tmph, tread, compound, inflation pressure, ply rating or equivalent, etc. Max. rear axle oscillation.......................................................±10.0°

COOLING SYSTEM
BODY
L&M radiator assembly with sight gauge. Deaeration-type
Rugged bolster and sill construction. Body is rubbermounted on
top tank.
frame. Deck-mounted mufflers standard. Pivot exhaust heating
optional. Radiator frontal area................................................4.26 m2 45.9 ft2
Bottom plate . . . . . . . . . . . . . . . . . . . . . . 1034 mPa 150,000 psi
tensile-strength-steel, 19 mm 0.75'', two-piece construction
Front and side sheet . . . . . . . . . . . . . . . . . 690 mPa 100,000 psi SERVICE CAPACITIES
tensile-strength-steel, front 12.7 mm 0.50'', side 9.7 mm 0.38''
Cooling system . . . . . . . . . . . . . . . . . . . . . . . . 314 L 83 U.S. gal
*Crankcase . . . . . . . . . . . . . . . . . . . . . . . . . . . 223 L 59 U.S. gal
Hydraulic system . . . . . . . . . . . . . . . . . . . . . . . 549 L 145 U.S. gal
CAB
**Motor gear box. . . . . . . . . . . . . . . . . . . . (788) 40 L 10.5 U.S. gal
Deluxe interior, fully enclosed, superb working comfort, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3217 L 850 U.S. gal
adjustable operator seat with air suspension and lumbar
support, rubber-mounted, horn in center of steering * Includes lube oil filters
** Each wheel
wheel, padded armrest, panel-mounted circuit breaker, electric
“wet” windshield wiper, horizontal sliding windows,
excellent visibility, adjustable steering wheel, tinted safety
glass windshield, 45,000 btu/hr heater and defroster, pressurized
and filtered air intake. Standard ROPS.
 630E
ELECTRIC DRIVE TRUCK

DIMENSIONS

7.01 m 23'0''
7.98 m 26'2'' 3.02 m 9'11'' 6.65 m 21'10''

3.33 m 3.68 m
6.43 m 12'1''
21'1'' 10'11''
11.98 m
EMPTY
39'4'' 2.89 m
RAISED 8'10'' 6.30 m
5.84 m 20'8''
19'2''
2.79 m
9'2''
45°

1.29 m 4'3'' 1.26 m 4'2''

3.42 m 11'3'' 5.44 m 17'10'' 3.08 m 10'1''

11.94 m 39'2'' 4.57 m 15'0''
5.54 m 18'2''
6.50 m 21'4''

All dimensions are with 103 m3 135 yd3 body.

6.98 m 22'11''

6.27 m 20'7''
Loading
Bodies Struck 2:1 Heap Height*
Standard 77 m3 101 yd3 103 m3 135 yd3 5.84 m 19'2''
*Exact load height may vary due to tire make, type, and inflation pressure.

HYDRAULIC SYSTEM

Steering . . . . . . . . . . . Accumulator-assisted twin cylinders provide

constant rate steering. Emergency power steering 2.24 m
7'4''
automatically applied by accumulator(s). 4.42 m 14'6''
Turning circle diameter (SAE) . . . . . . . . . . . . . . . . . . . 24.4 m 80 ft 6.60 m 21'8''
Reservoir . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 496 L 131 U.S. gal
Filtration . . . . . . . . . . . . . . . . . . . . . . . In-line replaceable elements
Suction . . . . . . . . . . . . . . . . . . . . . . . Single, full-flow, 100 mesh
Hoist and steering . . . . . . . Dual, full-flow, in-line, high-pressure,
7 micron.
Brake component cabinet. . . . . . . . . Above-deck, easily accessible
with diagnostic test connections. ELECTRICAL SYSTEM
Hoist . . . . . . . . . . . . . . . . . Two 3-stage cylinders with new-concept
2 x 8D 1450 CCA, 12 volt batteries, in series/parallel, deck-mounted
design and sealing system. Internal cushion
with disconnect switch.
valve and over-center damping provide
Alternator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-volt, 110 amp
reliability and smoother dumping.
Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-volt
Hoist times
Power-up loaded . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 sec
Power-down. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 sec
Float-down empty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 sec
Pumps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Vane-type pump WEIGHT DISTRIBUTION
with output of 538 liters 142 gpm at 1900 rpm
Empty Vehicle kg lb %
System relief pressures Front axle . . . . . . . . . . . . . . . . . . . . . . 60215 132,750 48.5
Hoist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17237 kPa 2,500 psi Rear axle . . . . . . . . . . . . . . . . . . . . . . .63812 140,680 51.5
Steering and Brake . . . . . . . . . . . . . . . . . . 20850 kPa 3,000 psi Total (wet, 50% fuel) . . . . . . . . . . . . .124028 273,430
Quick disconnects standard for powering disabled truck
and for system diagnostics. Loaded Vehicle at maximum GVW rating
Front axle . . . . . . . . . . . . . . . . . . . . .101715 224,244 34.5
Rear axle . . . . . . . . . . . . . . . . . . . . . .193120 425,756 65.5
Total . . . . . . . . . . . . . . . . . . . . . . . . .294840 650,000
NOTE: GVW shall not exceed 294840 kg 650,000 lb including options, liners, fuel and
payload, subject to application approval by Komatsu.

NOTE: Komatsu trucks comply with SAE specifications for cab noise, ROPS, steering and
braking. Cover photos and illustrations may show optional equipment. Materials and
specifications subject to change without notice.
 STANDARD EQUIPMENT

● Air cleaners, dry-type SRG ● Dynamic retarding with continuous rated ● Indicator lights for dynamic retarding,
● Air start grids overspeed, service brakes
● Air system filter/moisture ejector ● Hoist interlock ● Insulation
● Alternator (24V/110A) ● Horns (back-up – electric; front – air) ● Motorized wheel temperature warning
● Auto lubrication system ● Maintenance and power lockout alarm
● Batteries (2 x 8D, 1450 CCA 12 volt) ● Parking brake with warning light and ● Operator seat (adjustable with air
● Body down indicator/body up buzzer speed application protection suspension and lumbar support)
● Body over center device ● Power steering with auto emergency ● Panel lighting (adjustable)
● Brakes: Wheel speed disc front, dual disc steering ● Passenger seat
(armature speed) rear ● Protective deck handrails ● Pressurized cab air system
● Fast-fill fuel system (in tank, right side) ● Pump drive guard ● Recessed door handles
● Filters, high pressure hydraulic ● Radiator fan guard ● Sliding glass windows
● FLOC – Fast Lube Oil Change ● ROPS, cantilevered ● Speedometer
● Fuel Saver – G.E. Control ● Seat belts (wide, retractable) ● Starter key switch
● Gate valve on hydraulic tank ● Skid-resistant coating on walkways ● Steering system warning light and buzzer
● Komatsu control cabinet ● Slippery road brake switch ● Sun visor (adjustable)
● Mirrors, LH flat & RH rectangular convex ● 24-volt circuit breakers ● Tachometer
● Mud flaps CAB: ● Tilt steering wheel
● Muffled exhaust, deck-mounted ● Voltmeter (battery output)
● Accumulator pre-charge light
● On-board load box ● Warning system lights and buzzers for
● Air cleaner vacuum gauges
● PLM I – Komatsu Payload Weighting coolant low level, coolant high
● Air conditioner, HFC 134A
System temperature, electric cooling blower, low
● Air pressure gauge
● Power Supply (25 amp) oil pressure, ground relay
● Armrest (padded, driver’s door)
● Quick disconnects (air, steering, hoist) ● Wheel brake lock w/drive system interlock
● Automatic buzzer for low air pressure
● Radiator sight gauge ● Windshield wiper and washer (electric)
● Blower pressure indicator light
● Removable power module unit (radiator, LIGHTING:
● Dome light
engine, alternator, blower)
● Engine hourmeter, oil pressure gauge, ● Back-up lights (2)
● Retard speed control
coolant temperature gauge ● Clearance lights
● Reverse retarding
● Engine oil high temperature alarm ● Control cabinet service light
● Rock ejectors
● Engine shutdown ● Dynamic retarding, rear (2) and top of
● Thermostatic fan clutch
● Flight Systems Engine Saver cab (2)
● Two-speed overspeed retarding
● Floor mat ● Headlights, bumper (4)
● Vari-volt alternator control
● Fuel gauge in cab and on tank ● Ladder lights
● Fast Fill Fuel System (in tank)
● Fuel low level light and buzzer ● Manual back-up light switch
SAFETY: ● Gauges (backlighted) ● Service light in rear axle
● All-hydraulic service brakes with ● Headlight switch ● Stop and tail lights (2)
emergency auto apply ● Heater and defroster (heavy-duty) ● Turn signals
● Battery disconnect switch ● Heater switch ● Under-hood service lights
● Body prop cable ● High beam selector and indicator
● Brake lock and drive system interlock ● Horn (center of steering wheel)

OPTIONAL EQUIPMENT

● Additional high-mounted headlights ● Body liners – standard body* ● Hot start (engine oil, coolant, hydraulic
● Aftercooler ● Deck metered back-up lights tank)
● Air cleaner dust evacuators ● Fast-fill fuel system - LH ● Hubodometer
● AM/FM/Cassette radio ● Filtered air inlet system ● Radiator shutters (thermostatically
● Arctic protection package (suspensions, ● Fire extinguisher (20 lb.) controlled)
antifreeze/lube below -40º C) ● Fog lights ● Service center - RH

*Available factory-installed or non-installed. All other options and accessories listed are available factory installed only.

AESS563-01 ©2001 Komatsu Printed in USA DK11(3M)EH Datakom 11/01 (EV-1)

Komatsu Mining Systems, Inc.

568 Atrium Drive
P.O. Box 8131
Vernon Hills, IL 60061-8131

www.komatsumining.com Materials and specifications are subject to change without notice

is a trademark of Komatsu Ltd. Japan